Owner's Manual
Page 3
Copyright © 2005 Ford Motor Company 3 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Ford may change the contents without notice and without written authorization from Ford Motor Company. Reproduction by any means, electronic or mechanical ...including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without incurring obligation. Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery...
Copyright © 2005 Ford Motor Company 3 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Ford may change the contents without notice and without written authorization from Ford Motor Company. Reproduction by any means, electronic or mechanical ...including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without incurring obligation. Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery...
Owner's Manual
Page 9
Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Panic Alarm Engine Coolant Power Window Lockout Interior Luggage Compartment Release Symbol Engine Oil Engine Coolant Temperature Battery Do Not Open When Hot Avoid Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap Low tire warning 9 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Panic Alarm Engine Coolant Power Window Lockout Interior Luggage Compartment Release Symbol Engine Oil Engine Coolant Temperature Battery Do Not Open When Hot Avoid Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap Low tire warning 9 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 12
... first turned to Understanding Your Tire Pressure Monitoring System in the supplemental restraint system has been detected. Charging system: Illuminates when the battery is illuminated. When the ignition is turned to ON, continues to flash or remains on at or near empty (refer to Fuel...is low. If the light remains on , have the system inspected by your tire pressure is working. For more information on this chapter). 12 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Refer to fasten your safety belt. A chime will illuminate for 3 seconds to fasten ...
... first turned to Understanding Your Tire Pressure Monitoring System in the supplemental restraint system has been detected. Charging system: Illuminates when the battery is illuminated. When the ignition is turned to ON, continues to flash or remains on at or near empty (refer to Fuel...is low. If the light remains on , have the system inspected by your tire pressure is working. For more information on this chapter). 12 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Refer to fasten your safety belt. A chime will illuminate for 3 seconds to fasten ...
Owner's Manual
Page 16
...the trip reading is in the display. Press the control again to select Trip 1 and Trip 2 features. Battery voltage gauge: Indicates the battery voltage when the ignition is 0.0 miles. • With Full Message Center Press and release the message center ...INFO button until TRIP mode appears in the ON position. If the pointer moves and stays outside the normal operating range, have the vehicle's electrical system checked as soon as possible. H L 16 2005 Expedition...
...the trip reading is in the display. Press the control again to select Trip 1 and Trip 2 features. Battery voltage gauge: Indicates the battery voltage when the ignition is 0.0 miles. • With Full Message Center Press and release the message center ...INFO button until TRIP mode appears in the ON position. If the pointer moves and stays outside the normal operating range, have the vehicle's electrical system checked as soon as possible. H L 16 2005 Expedition...
Owner's Manual
Page 49
... to control the DVD player. There is a LED indicator light on the remote control to operate the headphones.) Batteries are included. 49 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Slide the battery cover off as shown on the remote control that will illuminate when any control is equipped with the remote...
... to control the DVD player. There is a LED indicator light on the remote control to operate the headphones.) Batteries are included. 49 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Slide the battery cover off as shown on the remote control that will illuminate when any control is equipped with the remote...
Owner's Manual
Page 50
... audio signal from the overhead pod. The headphones will automatically turn off to a comfortable listening level. When replacing the batteries, use two new batteries (alkaline recommended) and install them off . • Adjust the headphones to turn off . When not using the ...headphones, shut them with the correct (+) and (-) orientation. Ensure that the line of the wireless headphones can only be purchased by the thumbwheel. VOL 50 2005 Expedition...
... audio signal from the overhead pod. The headphones will automatically turn off to a comfortable listening level. When replacing the batteries, use two new batteries (alkaline recommended) and install them off . • Adjust the headphones to turn off . When not using the ...headphones, shut them with the correct (+) and (-) orientation. Ensure that the line of the wireless headphones can only be purchased by the thumbwheel. VOL 50 2005 Expedition...
Owner's Manual
Page 52
...permanent felt tip marker rather than adhesive labels. The label may not function correctly when used in Ford DVD/CD players. It is recommended that homemade discs be identified with homemade paper (adhesive) labels...will fully pull in the radio display. • The DVD player will run the battery down when the disc is capable of playback of time to cool will begin playback from...should be up. For a multi-sided disc, the desired play commercially pressed 4.75 in the system. 52 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) and Canada). This unit is designed to play side...
...permanent felt tip marker rather than adhesive labels. The label may not function correctly when used in Ford DVD/CD players. It is recommended that homemade discs be identified with homemade paper (adhesive) labels...will fully pull in the radio display. • The DVD player will run the battery down when the disc is capable of playback of time to cool will begin playback from...should be up. For a multi-sided disc, the desired play commercially pressed 4.75 in the system. 52 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) and Canada). This unit is designed to play side...
Owner's Manual
Page 120
...accessible from being blown, do not use the power point longer than necessary when the engine is not running. Equipped with rear climate control 120 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Always keep the power point caps closed when not being discharged, do not use... the power point for operating the cigarette lighter element (if equipped). To prevent the battery from the rear seats. 0 1 2 3 4 The rear auxiliary power point is accessible from being used. Driver Controls Do not use the power ...
...accessible from being blown, do not use the power point longer than necessary when the engine is not running. Equipped with rear climate control 120 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Always keep the power point caps closed when not being discharged, do not use... the power point for operating the cigarette lighter element (if equipped). To prevent the battery from the rear seats. 0 1 2 3 4 The rear auxiliary power point is accessible from being used. Driver Controls Do not use the power ...
Owner's Manual
Page 130
... program HomeLink with procedures noted in the "Gate Operator and Canadian Programming" in this section. It is also suggested that a new battery be turned to replace Step 3 with the vehicle parked in the garage. Some entry gates and garage door openers may require the... hand-held transmitter of the device being programmed to HomeLink for security purposes, refer to program additional hand-held transmitters' radio frequency signals.) 130 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Do not repeat Step 1 to Programming in this section for Canadian residents. 4. ...
... program HomeLink with procedures noted in the "Gate Operator and Canadian Programming" in this section. It is also suggested that a new battery be turned to replace Step 3 with the vehicle parked in the garage. Some entry gates and garage door openers may require the... hand-held transmitter of the device being programmed to HomeLink for security purposes, refer to program additional hand-held transmitters' radio frequency signals.) 130 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Do not repeat Step 1 to Programming in this section for Canadian residents. 4. ...
Owner's Manual
Page 137
... to "lock in your tank under normal driving conditions. Driver Controls 7. The running average fuel economy, which is now calibrated. This value is disconnected. 137 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Remember to a factory default value if the battery is not the same as the average fuel economy display.
... to "lock in your tank under normal driving conditions. Driver Controls 7. The running average fuel economy, which is now calibrated. This value is disconnected. 137 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Remember to a factory default value if the battery is not the same as the average fuel economy display.
Owner's Manual
Page 153
...Security Deactivating the memory seat feature To deactivate this procedure for the correct orientation of the battery. Within 5 five seconds, press any grease on the battery terminals on the remote transmitter which you would like to the diagram inside the remote ...entry transmitter for another remote transmitter if desired. Repeat this feature: 1. Refer to deactivate and then press the SET control on the driver's door panel. 2. Snap the two halves back together. 153 2005 Expedition...
...Security Deactivating the memory seat feature To deactivate this procedure for the correct orientation of the battery. Within 5 five seconds, press any grease on the battery terminals on the remote transmitter which you would like to the diagram inside the remote ...entry transmitter for another remote transmitter if desired. Repeat this feature: 1. Refer to deactivate and then press the SET control on the driver's door panel. 2. Snap the two halves back together. 153 2005 Expedition...
Owner's Manual
Page 154
...) position. Again the doors will invalidate the procedure. The remote transmitter should operate normally after battery replacement. Locks and Security Note: Replacement of your vehicle. If all (maximum of six - original and/or new) of... the battery will not cause the remote transmitter to become deprogrammed from 2 the 1 (OFF/LOCK) to beginning this....) • Repeat the previous step to confirm programming has been completed. 154 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
...) position. Again the doors will invalidate the procedure. The remote transmitter should operate normally after battery replacement. Locks and Security Note: Replacement of your vehicle. If all (maximum of six - original and/or new) of... the battery will not cause the remote transmitter to become deprogrammed from 2 the 1 (OFF/LOCK) to beginning this....) • Repeat the previous step to confirm programming has been completed. 154 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 177
... crash severity before activating the appropriate safety devices to the Battery Saver feature, the power 3rd row seat will operate for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, and indicator lights. 177 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The transmission...
... crash severity before activating the appropriate safety devices to the Battery Saver feature, the power 3rd row seat will operate for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, and indicator lights. 177 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The transmission...
Owner's Manual
Page 241
... on your tires to the recommended tire pressure. Operation is stationary over 15 minutes, the sensors go into a low power mode to conserve battery life and therefore only transmit about once an hour. For example, if the vehicle is subject to an increase in each pneumatic tire. The....7 kPa) for at least a minute. If one of them being significantly lower than the daytime temperature, the tire pressure may not cause harmful 241 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) If all the tires to the tires. Inflate all tires appear to be inflated, carefully ...
... on your tires to the recommended tire pressure. Operation is stationary over 15 minutes, the sensors go into a low power mode to conserve battery life and therefore only transmit about once an hour. For example, if the vehicle is subject to an increase in each pneumatic tire. The....7 kPa) for at least a minute. If one of them being significantly lower than the daytime temperature, the tire pressure may not cause harmful 241 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) If all the tires to the tires. Inflate all tires appear to be inflated, carefully ...
Owner's Manual
Page 287
...8226; coverage period • exact fuel amounts • towing of the nearest Ford Motor Company dealership (one tow per disablement). Ford or Mercury vehicle customers who require roadside assistance, call 1-800-521-4140. 287 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Even non-warranty...in the glove compartment. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is separate from the New Vehicle Limited Warranty.
...8226; coverage period • exact fuel amounts • towing of the nearest Ford Motor Company dealership (one tow per disablement). Ford or Mercury vehicle customers who require roadside assistance, call 1-800-521-4140. 287 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Even non-warranty...in the glove compartment. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is separate from the New Vehicle Limited Warranty.
Owner's Manual
Page 291
..., then push the bottom part of the Maintenance and Specifications chapter. 291 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) To reduce the risk of electrical shock, always replace the cover to the Battery section of the cover until you and swing it out away from the ...side and remove it. Always disconnect the battery before reconnecting the battery. If the battery has been disconnected and reconnected, refer to the passenger compartment fuse panel/power distribution box before servicing high current fuses. Roadside ...
..., then push the bottom part of the Maintenance and Specifications chapter. 291 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) To reduce the risk of electrical shock, always replace the cover to the Battery section of the cover until you and swing it out away from the ...side and remove it. Always disconnect the battery before reconnecting the battery. If the battery has been disconnected and reconnected, refer to the passenger compartment fuse panel/power distribution box before servicing high current fuses. Roadside ...
Owner's Manual
Page 294
... switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow battery charge relay coil Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow back-up lamps relay coil... flasher, Electrochromatic mirror, Auxiliary mode motor Restraints Control Module (RCM) 13 10A* 14 10A* 15 5A* 16 17 18 10A* 15A* 10A* 19 10A* 294 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow battery charge relay coil Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow back-up lamps relay coil... flasher, Electrochromatic mirror, Auxiliary mode motor Restraints Control Module (RCM) 13 10A* 14 10A* 15 5A* 16 17 18 10A* 15A* 10A* 19 10A* 294 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 295
... Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve LH low beam Horn relay, Horns Compass module, Reverse sensing system module, Brake shift interlock... coil, SecuriLock transceiver, Heated PCV valve relay coil 21 15A* 22 10A* 23 24 10A* 15A* 25 26 27 10A* 20A* 5A* 28 5A* 295 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve LH low beam Horn relay, Horns Compass module, Reverse sensing system module, Brake shift interlock... coil, SecuriLock transceiver, Heated PCV valve relay coil 21 15A* 22 10A* 23 24 10A* 15A* 25 26 27 10A* 20A* 5A* 28 5A* 295 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 297
... RSC module (pump motor) LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor Spare Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge) Auxiliary A/C blower relay, Auxiliary A/C blower motor Passenger seat motor switch Driver seat motor switch (non-memory), Memory module, Power memory mirrors... grid, Heated mirrors (Fuse 8) 297 105 106 30A** 30A** 107 108 109 30A** 30A** 30A** 110 111 112 113 114 30A** 50A** 30A** 30A** 40A** 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... RSC module (pump motor) LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor Spare Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge) Auxiliary A/C blower relay, Auxiliary A/C blower motor Passenger seat motor switch Driver seat motor switch (non-memory), Memory module, Power memory mirrors... grid, Heated mirrors (Fuse 8) 297 105 106 30A** 30A** 107 108 109 30A** 30A** 30A** 110 111 112 113 114 30A** 50A** 30A** 30A** 40A** 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 298
... Fuse 8 (heated mirrors), Rear defrost relay window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head) Trailer tow Trailer tow 7-wire connector battery charge (battery charge) relay Front blower Front blower motor relay Trailer tow park Trailer tow 7-wire and 4-wire lamp relay connectors (park lamps) Foglamp relay Front foglamps...
... Fuse 8 (heated mirrors), Rear defrost relay window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head) Trailer tow Trailer tow 7-wire connector battery charge (battery charge) relay Front blower Front blower motor relay Trailer tow park Trailer tow 7-wire and 4-wire lamp relay connectors (park lamps) Foglamp relay Front foglamps...