Craftsman 25cc Support Question
Craftsman 25cc Support Question
Find answers below for this question about Craftsman 25cc - Propane Curved Shaft Trimmer Powered by Lehr.Need a Craftsman 25cc manual? We have 1 online manual for this item!
Question posted by zekSURVIS on June 22nd, 2014
Craftsman 25cc Weed Eater Won't Stay Running
The person who posted this question about this Craftsman product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Craftsman 25cc Manual Pages
Operation Manual - Page 1
OPERATOR'S MANUAL
PROPANE POWERED LINE TRIMMER
16.4 oz Propane Bottle Not Included
TABLE OF CONTENTS
Service and Safety
2
Safe Operation Rule.s
3
Understanding Your Trimme...r
4
Assembly
5
Oil Information
6
Understanding Propan.e
7
Installing the Propane Canist.e..r
8
Installing Attachment.s
9
Starting / Stopping
10
Operation
11
Maintenance
12
...
Operation Manual - Page 2
...line. USE OF ANY OTHER PA RTS MAY CREATE A HAZARD OR CAUSE
PRODUCT DAMAGE.
2
LEHR | ALL RIGHTS RESERVED 2008-2009 Forest Land and in the states of children, bystanders, and ...printing. SERVICE AND SAFETY
S
LEHR ECO-TRIMMER
IMPORTANT SAFETY INSTRUCTIONS
DU
4-CYCLE PROPANE TRIMMER
READ ALL INSTRUCTION BEFORE OPERATING
• Ne
For service call 1-866-941-LEHR in the United States, to...
Operation Manual - Page 3
...is turned o . Do not run the unit inside
a building where vapor may become entangled with propane canister attached inside a closed ...sandals or go barefoot. These are marked as a trimmer.
parts get extremely hot from your war ranty.... THESE INSTRUCTIONS
LEHR | ALL RIGHTS RESERVED 2008-2009
3 SAFE OPERATION RULES
DURING OPERATION • Never start or run the engine...
Operation Manual - Page 4
...OTHER OPTIONAL ACCESSORIES MAY BE USED WITH YOUR UNIT
4
LEHR | ALL RIGHTS RESERVED 2008-2009 May be used in place...rotating cutting attachment. These parts get burned.
UNDERSTANDING YOUR TRIMMER
SAFETY AND INTERNATIONAL SYMBOLS
This operator's manual describes safety ...operator and/or bystanders. I
ON/OFF STOP CONTROLS ON/START/RUN
o
ON/OFF STOP CONTROL OFF or STOP
KEEP SYSTANDERS AWAY...
Operation Manual - Page 5
... sleeve on your unit is not installed.
FOR CURVED SHAFT TRIMMERS Place the cutting attachment shield and spacer against tube...LEHR | ALL RIGHTS RESERVED 2008-2009
5 Do not completely tighten.
3.While holding the unit in (Fig. 3), positioning the handle parts evenly over the tube in (Fig. 1). Attaching Screws
D-Handle
Cap
Washer
Fig. 1
Attaching Screws
FOR STRAIGHT SHAFT TRIMMERS...
Operation Manual - Page 6
... bottle of oil into the oil ll hole (Fig. 7).
4-Cycle Motor Oil
Fig. 5
WARNING:
Overfilling crankcase may have spilled and reinstall the oil plug/dipstick.
6
LEHR | ALL RIGHTS RESERVED 2008-2009 Check the oil before you attempt to meas-ure the correct amount during future oil changes.
Operation Manual - Page 7
... 1. To discard, contact local refuse hauler or recycle cen ter. Turn trimmer o . 3. Never use .
Turn trimmer o and let cool. 2. Replace cap to tighten. LEHR | ALL RIGHTS RESERVED 2008-2009
7 If the leak persists, remove the pro pane canister. Always remove the propane canister from any time the smell of escaping gas. CARBON MONOXIDE HAZARD...
Operation Manual - Page 8
... PROPANE CANISTER
3. Remove the empty canister.
1. Dispose of propane as it
onto threads clockwise (Fig. 9B). If the propane canister to Federal, State and local Regulations. to be normal to the trimmer... CONTENTS UNDER PRESSURE.
Fig. 9A
Canister Clamp
8
LEHR | ALL RIGHTS RESERVED 2008-2009
WARNING:
PROPANE IS EXTREMELY FLAMMABLE. DO NOT SMOKE. KEEPS SPARKS AND OPEN FLAMES AT...
Operation Manual - Page 9
...11), so that the engine is upright (propane tank on straight out of a trimmer being used in the receiving hole only....). A secondary receiving hole is provided for edging only. Upper Shaft Housing
Knob Fig. 10
Attachment Housing
Coupler
Release Button
90°...trimmer head cut ting attachment) lock the release button of the cut ting attachment into coupler (Fig. 10).
LEHR | ALL RIGHTS...
Operation Manual - Page 10
....
3. Throttle Control Fig. 13
10
LEHR | ALL RIGHTS RESERVED 2008-2009
WARNING:
ALWAYS WEAR EYE, HEARING, FOOT AND BODY PROTECTION TO REDUCE THE RISK OF INJURY WHEN OPERATING THIS UNIT. Place trimmer rmly on OFF until the engine warms up the engine for the day, disconnect the propane canister from the throttle control...
Operation Manual - Page 11
...engine drag.
• Slowly move the trimmer into objects such as opposed to the ground.
• Do not force the cutting attachment. What vegetation is cut
3. Run engine at a 30-degree angle to ... Trim only when grass and weeds are dry.
• The life of your cutting line is tapped. Proper adherence to the ground (Fig. 16).
30°
Fig. 16
LEHR | ALL RIGHTS RESERVED 2008-2009...
Operation Manual - Page 12
...THE UNIT WITH THE LEVEL BELOW THE BOTTOM OF THE DIPSTICK. NOTE: Failure to maintain your trimmer at the recom mended schedule may result in the crankcase cannot be performed by any seasonal ...PAGE 13 PAGE 13 PAGE 14 PAGE 17
Perform these pro cedures call 1-866-941-LEHR for the location of your trimmer
NOTE: Some maintenance procedures may require special tools or skills. Oil should also be...
Operation Manual - Page 13
... measure approximately 1.7 fluid oz/50 ml. Do not over fill (Fig. 17).
6. Replace the oil ll plug/dipstick. 7. Wash the lter in detergent and water.
LEHR | ALL RIGHTS RESERVED 2008-2009
13
Operation Manual - Page 14
.... (0.5 mm). Turn the 5/8 in . (0.5 mm)
Fig.23
14
LEHR | ALL RIGHTS RESERVED 2008-2009 CLEAN AIR FILTER The condition of the air... operation and check its condition. 1.Stop the engine and allow it run at 0.02 in. (0.5 mm.) using a torque wrench torque to... ADJUSTMENT The idle speed of the engine is a loss of engine power
Check the spark plug for proper gap and condition. Refer to :...
Operation Manual - Page 15
... the direction it engages groove inside. Snap the lines through top notches in these instructions.
2. Trimmer Head Body
Spring
Reel
Bump Feed Button
Nut
Fig.25
4.
Fig.29
11. Retention Hook
Retention... Insert allen key into hole tighten by turning body as shown (Fig. 26). LEHR | ALL RIGHT RESERVED 2008-2009
15 Lock shaft by turning CW (Fig. 29). Pull reel out of the line left on...
Operation Manual - Page 16
... through cover
16
LEHR | ALL RIGHTS RESERVED 2008-2009
Fig.3 7
Insert each line into one of the holes on each retention hook opposite of the direc tion of the head (Fig. 33). Fig.34
Snap to groove to pull through holes trimmer head body (Fig. 34). If your model is a curved shaft, loosen by...
Operation Manual - Page 17
... blade remove
the bottom shield attachment by using line trimmer head (Fig. 41). If you
feel unsure or unqualified to perform this, take the unit
to lock the shaft.
Remove in a clean dust free environment. Engine cover screws
Fig.42
Engine cover screws
LEHR | All Rights Reserved 2008-2009
17 Remove the four...
Operation Manual - Page 18
... top of the cover. WARNING:
TO PREVENT SERIOUS INJURY, NEVER PERFORM MAINTENANCE OR REPAIRS WITH UNIT RUNNING. Clean dirt from around the rocker arm cover.
6. Jam Nuts
Feeler Gauge Exhaust Valve Intake Valve
Fig.44
18
LEHR | ALL RIGHTS RESERVED 2008-2009 Reinstall the spark plug wire. If this statement is set...
Operation Manual - Page 19
...CLEAN THE CUTTING ATTACHMENT
DIRTY AIR FILTER ENGINE LACKS POWER OR STALLS WHEN CUTTING CAUSE BAD SPARK PLUG
CLEAN....
NOTE: Remove the spark plug and drain all of children.
LEHR | ALL RIGHTS RESERVED 2008-2009
19 Change the oil, referring .... • Remove propane canister. TRANSPORTING • Allow the engine to cool before attempting to start the trimmer after storage. 3....
Operation Manual - Page 20
...SHAFT HOUSING THROTTLE CONTROL APPROXIMATE UNIT WEIGHT CUTTING MECHANISM LINE SPOOL DIAMETER TRIMMING LINE DIAMETER CUTTING PATH DIAMETER
AIR COOLED 4-CYCLE 25.4 CC
CENTRIFUGAL 6,800-9300 R.P.M. 3,000-3,400 R.P.M. ELECTRONIC PUSH ON/OFF SWITCH 0.076-0.152MM (0.003-0.006 IN)
0.020 INCH (0.5 MM) SAE 10W-30 OIL
1.7 FLUIDOZ. (50mL) PROPANE... WITHOUT NOTICE.
20
LEHR | ALL RIGHTS RESERVES 2008-2009
Similar Questions
Craftsman 25cc Weed Wacker Wont Stay Running
(Posted by bijbcar 9 years ago)
Blower Hard To Start And Stay Running
(Posted by peiffer4 10 years ago)
Craftsman 25cc Weed Wacker Wont Start
(Posted by miJwiggin 10 years ago)
Why Won't My Trimmer Stay Running?
my trimmer will start and run fine for 3-5 minutes. Then it dies and is impossible to start. If I wa...
my trimmer will start and run fine for 3-5 minutes. Then it dies and is impossible to start. If I wa...
(Posted by Dblume12 14 years ago)