Dewalt DXGNR8000 Support Question
Dewalt DXGNR8000 Support Question
Find answers below for this question about Dewalt DXGNR8000.Need a Dewalt DXGNR8000 manual? We have 1 online manual for this item!
Question posted by adkinse6262 on January 18th, 2022
Generator Smokes Real Bad.
generator is not very old but was used on job sites now it burns oil I have replaced the head gasket but it didn't change
Current Answers
Answer #1: Posted by SonuKumar on January 19th, 2022 9:49 AM
SonuKumar
Member since:
May 9th, 2021 Points: 16,638,170
Member since:
May 9th, 2021 Points: 16,638,170
https://www.youtube.com/watch?v=7te1gN86c4A
https://www.youtube.com/watch?v=7te1gN86c4A&t=82
https://www.youtube.com/watch?v=7te1gN86c4A&t=98
https://www.youtube.com/watch?v=7te1gN86c4A&t=122
https://www.youtube.com/watch?v=7te1gN86c4A&t=149
https://www.youtube.com/watch?v=7te1gN86c4A&t=173
Why is my generator bringing out smoke?
The smoke may be caused by a simple problem, poor combustion efficiency or from excessive idling, stop start operation or short run times. At the other end of the scale, it may be your last chance to act, before a catastrophic engine failure occurs (e.g. piston seizure, valve or turbocharger failure).
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Dewalt DXGNR8000 Manual Pages
Instruction Manual - Page 1
BC
If you have questions or comments, contact us.
1-888-431-6871 • dewalt.com
INSTRUCTION MANUAL
Generator DXGNR6500 DXGNR8000
WARNING
To reduce the risk of injury, read and follow these instructions before operating product.
Instruction Manual - Page 3
... ...7 Battery Replacement/Connection ...8 Emissions Information ...8
Operation ...9
Know the Generator ...9 Connection Plugs ...10 CO PROTECT ...11 How to Use the Generator ...12 Know Generator Limits ...12 Wattage Reference Guide ...13 Before Starting Generator ...13 Starting Pull Start Engines ...14 Starting Electric Start Engines ...15 Manual Start ...15 Generator Shut Down ...15 Low Oil Level...
Instruction Manual - Page 4
... also available from windows, doors, and vents.
000657
This instruction manual contains information important for you recognize information important to the engine documentation for Portable Generator
ONLY USE OUTDOORS AND FAR AWAY FROM WINDOWS, DOORS,
VENTS, CRAWL SPACES AND IN AN AREA WHERE
ADEQUATE VENTILATION IS AVAILABLE AND WILL
NOT ACCUMULATE DEADLY...
Instruction Manual - Page 5
... and Use of Farm Standby Electric
Power. IMPROPER USE OF THIS GENERATOR CAN
RESULT IN ELECTROCUTION, INJURY OR DEATH. NEVER OPERATE THIS GENERATOR
INDOORS. TROCUTION. IF THIS GENERATOR IS ...CLEARANCE COULD DAMAGE YOUR GEN-
DO NOT PERMIT
SMOKING WITHIN 50FT OF THIS GENERATOR SET.
WARNING
DO NOT OPERATE THIS GENERATOR IF THE AMBIENT TEMPERA-
TRICAL LOAD. TOR.
...
Instruction Manual - Page 6
... in good mechani- ing in water or if standing in this generator unless it is in a level position before starting the generator.
• Generators operating on job or construction sites may be used.
• Do not cover the generator while it is running or immedi- THE
GENERATOR OPERATES AT A NOMINAL SPEED OF
3600 RPM. INCREASES IN SPEED OVER...
Instruction Manual - Page 7
...CONTACT DEALER CONTACTO DISTRIBUIDOR CONTACTER UN REVENDEUR
5 Safety
Accessories
Recommended accessories for use identical replacement parts. Date of Purchase Place of Purchase
Data Label
000756
Repairs
To assure... - If you need assistance in locating any accessory for Portable Generator
AUTOMATIC SHUTOFF - Always use with your tool are available for purchase from your warning labels ...
Instruction Manual - Page 8
Safety
6
Instruction Manual for Portable Generator
Instruction Manual - Page 9
... 1-888-431-6871. DXGNR8000
1. Insert cotter pin (F) and bend tabs to enhance portability. Install into ½" flat washer (G). M
H
J B
K
C F
G
E
D
L
003605
A
Instruction Manual for overthe-road use .
Table -1. NOTICE:
The wheels are not intended for Portable Generator
7 Insert hair pin (F) through wheel, 1/2" flat washer (G), and wheel bracket on frame.
2.
Accessories...
Instruction Manual - Page 10
...the Battery (electric start units only)
IMPORTANT: Running the generator does not charge battery. Battery Replacement/Connection
NOTICE:
The battery shipped with exhaust and evaporative ...compliance decal on gasoline. Fuel Tank / Cap - Slide M8 bolt (J) through holes in use for prolonged periods
of time. tive battery cable when working on unit.
Install M8 flange ...
Instruction Manual - Page 11
....
24. Save this manual for details. 9. Supplies
electrical power for the operation of power being used from the starter motor (electric start engine manually. 15. Use to the engine airbox. 17. Grounding Lug - Used to start engine from the generator (8000W models only). 21. Muffler - Add and check oil here. 14. Valve between the carbon canister and...
Instruction Manual - Page 12
... Manual for Portable Generator The hours will flash one hour before and one hour after each socket to
10
power 120 Volt AC,...Use only high quality, well-insulated, 3- sage will illuminate every 100 hours. Oil Change Interval (Every 100
hrs)
• 200 hours - Ensure this receptacle to operate 120 Volt AC, 60 Hz, single phase loads requiring up to 3600 watts (3.6 kW) of power...
Instruction Manual - Page 13
... system fault has occurred and no longer provides protection, the portable generator is pointed at the dealer. AUTOMATIC SHUTOFF - The RED light will detect the accumulation of Carbon Monoxide from other fuel burning sources such as engine powered tools or propane heaters used outdoors, far from occupied buildings and the exhaust pointed away from...
Instruction Manual - Page 14
...power for starting than the wattage capacity of the generator.
• The rated wattage of the generator.
Add to the intended use inside a home or garage, EVEN IF doors and windows are approximate. ONLY use... to be registered
with any problems operating the generator, call the generator helpline at a construction site, there may be performed by a qualified electrician and ...
Instruction Manual - Page 15
... Pump (1/2 HP 1500
*Sump Pump 800 to 1050
*Table Saw (10 1750 to 2000
Television 200 to 500
Toaster 1000 to each use synthetic 5W-30
Use petroleum based oil for Portable Generator
13 Wattage Reference Guide
Device
Running Watts
*Air Conditioner (12,000 Btu 1700
*Air Conditioner (24,000 Btu 3800
*Air Conditioner...
Instruction Manual - Page 16
...Generator Gasoline is highly FLAMMABLE and its vapors are as permanent damage may occur. ity while handling gasoline. non-ethanol premium fuel is important to Run (manual start - IMPORTANT: It is recommended).
• DO NOT use E85. • DO NOT use... to use one oil fill ...Replace oil fill cap and hand-tighten. If fuel tank is only necessary to storage. 1. Add recommended engine oil...
Instruction Manual - Page 17
... that breaker opens and electrical output to do so could result in the Run position. Open the fuel shut-off all electrical loads from generator panel receptacles.
2. Use one of any circuit breaker is exceeded, that receptacle is running.
Disconnect electrical loads prior to RUN position. Let engine run , move choke lever...
Instruction Manual - Page 18
... the engine shuts down the engine automatically when the oil level drops below a specified level. Charging the Battery (electric start units only)
WARNING
Explosion. RUNNING THE GENERATOR DOES NOT
CHARGE THE BATTERY. Battery charging should be in use for use . Plug wall receptacle end of burns. Failure to do so could cause death or serious...
Instruction Manual - Page 19
... above 16° C (60° F) ambient temperature. C (77 deg. Maximum power decreases about component replacement. Clean generator daily or before each 1,000 feet above sea level; Generator can cause improper operation and equipment damage. NOTICE:
Adverse conditions will also decrease about 1% for each use . Replace parts if they cannot be each 6° C (10° F) above 25...
Instruction Manual - Page 22
...storage. Change Oil
Change engine oil before storage.
• DO NOT store fuel from one season to another unless
properly treated.
• Replace fuel ...generator.
If fuel stabilizer is rec- Pour tablespoon (5-10cc) of fuel stabilizer in severe burns or fire.
1. Gently release recoil. tion sources. Use of clean engine oil or spray a suit- Remove spark plug. 3. Replace...
Instruction Manual - Page 23
...Maintenance
CORRECTION
1. Connect another device that is bad. 4. See Know Generator Limits .
3.
Spark plug wire not connected to spark plug.
6. Replace spark plug.
7. Contact IASD.
11. Fill...if a RED light blinks on the side panel
generator shuts-off due to no choke position.
9. Replace fuel filter. Low oil level.
9. Fill crankcase to be serviced. 4.
...
Similar Questions
What Size Spark Plug Do I Need?
I have the DeWalt DXGnr 8000. What size spark plug do I need. 13/16?
I have the DeWalt DXGnr 8000. What size spark plug do I need. 13/16?
(Posted by Thomassponberg 9 months ago)
Can I Use 5w30 Synthetic Oil In My Dewalt Dxgnr8000 Generator?
(Posted by bwcook1861 1 year ago)
Engine Mounts
Just found out that the engine mounts for my Dewalt DXGNR8000 are broken due to vibration I guess, d...
Just found out that the engine mounts for my Dewalt DXGNR8000 are broken due to vibration I guess, d...
(Posted by arredondourrea 1 year ago)
