2012 Polaris Turbo IQ Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2012 Polaris Turbo IQ manuals!
Problems with 2012 Polaris Turbo IQ?
Ask a Question
Other Models
Free 2012 Polaris Turbo IQ manuals!
Problems with 2012 Polaris Turbo IQ?
Ask a Question
Other Models
Popular 2012 Polaris Turbo IQ Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this manual and on all product labels. Failure to follow all of the instructions and safety precautions in serious injury or death. WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 5
... excellence for minor maintenance, but information about major repairs is interested in your door!
1 Have your accessories and clothing delivered right to your total satisfaction. Many years of experience have gone into the engineering, design, and development of your vehicle, be performed only by a factory certified Master Service Dealer® (MSD) technician. For safe and enjoyable...
Owners Manual - Page 7
... an optimum riding experience.
Pre-Ride Inspections ...64
This section explains procedures that should be performed before riding. POLARIS Products...135 Troubleshooting ...136 Warranty ...142 Maintenance Log ...151 Index ...154
3 Safety ...8
This section describes safe vehicle operation and identifies warning decals and their locations.
Features ...27
This section identifies the...
Owners Manual - Page 21
... and ice. SAFETY
Operator Safety
Ice and Snow Build-up
Before driving, manually turn the skis to the left and right steering. If your snowmobile, ... driving on long downhill stretches, pump the brakes. WARNING!
Apply just enough throttle to keep the clutch engaged, allowing the engine's compression to overheat, which may...perform this check in serious injury or death.
17
Owners Manual - Page 27
... by POLARIS at no charge. Never run engine with engine running. See your snowmobile, always read and...manual differ from the decals on your dealer. If any decal becomes illegible or comes off, contact your protection. Do not attempt adjustment with drive belt removed. Test or replace when changing coolant. If any of applicable liquid cooled models:
WARNING Do not open . Never service...
Owners Manual - Page 29
NOTE: For more information, see Owner's Manual. SAFETY
Safety Decals and Locations
Reverse Warning Operation Warning Reverse Warning Operation ...LH control to or from reverse only when stopped. • Apply throttle slowly. If electric reverse: • Machine stopped and engine at low speeds, can cause loss of control, always: • Look behind before and while backing up. • Avoid ...
Owners Manual - Page 30
... to turn or stop. • To maintain vehicle control on ice or hard-packed surfaces, you to react to terrain changes, to avoid unexpected obstacles, or to stop safely. • Never consume alcohol or drugs before operation. Oil injection system: Use unmixed fuel only. If manual is missing, contact a POLARIS dealer for proper...
Owners Manual - Page 37
...range. FEATURES
Engine Management System
Malfunction Indicator Lamp (MIL)
Illuminated MIL The MIL (Check Engine Indicator) will flash if an error with the turbo boost regulation system... when a problem with continued operation. A flashing MIL may occur with engine management system components is permissible. 2. If the light illuminates again, determine whether engine RPM or vehicle speed is ...
Owners Manual - Page 38
... System
To protect the engine, the engine management system will flash) Fuel octane is at or above 203 F (95 C) Intake manifold air temperature is at or above 158 F (70 C) Overboost condition occurs (Check Engine light will limit engine RPM, vehicle speed or turbo boost if the following conditions are encountered. Vehicle Speed is Limited...
Owners Manual - Page 40
... knock sensor system prevents damage to regain full power. The rider will be reconnected or repaired to the engine from damage if the sensor fails, becomes disconnected or is used. Engine performance will experience a loss in decreased engine RPM and performance. See fuel recommendations on page 78. Fail-Safe
The knock sensor includes a sensor fail-safe system...
Owners Manual - Page 85
.... 5. If the engine doesn't start the engine. OPERATION
n Throttle Lever
WARNING! If the throttle lever operates properly, turn the ignition switch on turbo-charged models.
81 If this occurs, return the snowmobile to the idle position quickly and completely. 4.
The lever and cable must return to an authorized POLARIS dealer for service. An improperly...
Owners Manual - Page 89
...The ECI label is permanently affixed to perform any service that the specified maintenance is available to your snowmobile to this vehicle.
85 Reverse (if equipped) must take your qualified service technician. These items are responsible for diagnostic service.
Owner's Responsibilities
Please read the Snowmobile Engine Emissions Limited Warranty, and read the maintenance section of...
Owners Manual - Page 97
... in completely. Position the vehicle on the dipstick, check the oil system for the presence of oil. 7. If no more than 5 seconds, stop the engine, and recheck for the presence...dipstick with the oil level check procedure beginning on the dipstick. 3. Remove the dipstick. Turn the engine off. 2. If oil is present, continue with a clean shop towel and reinstall it, screwing it to...
Owners Manual - Page 108
When operating in poor engine performance. If low fuel pressure or reduced engine performance occurs between the recommended fuel filter service intervals, the filter may occur. NOTICE: Kinking the fuel lines or using a pliers or similar tools to remove fuel lines may cause damage to service the fuel pump. Do not attempt to the lines. Contaminated or poor quality fuel will shorten the life...
Owners Manual - Page 113
...Cooling System
To ensure that the coolant maintains its ability to protect the engine, the system should be added. Bleeding the Cooling System
Bleed the cooling... be completely drained every two years and a fresh mixture of the cooling system has been serviced or replaced (including coolers, radiator, engine, coolant lines and oil cooler) • A cooling system failure occurs, resulting in the...
Owners Manual - Page 146
... supersede information contained in this manual. Model number 3. When contacting us about parts, service, or warranty, always provide the following information:
1. Details of your POLARIS dealer for replacement parts, service or warranty. Contact your snowmobile and its engine. WARRANTY
Service And Warranty Information
Obtaining Service and Warranty Assistance
Read and understand the...
Owners Manual - Page 149
... selected any type of extended warranty coverage as part of POLARIS engine oil. 2. WARRANTY
Limitations of transportation to and from the dealer is needed. These warranties can be covered by POLARIS. POLARIS recommends that you must take it to a POLARIS dealer authorized to perform warranty service. If any POLARIS Servicing Dealer to repair POLARIS snowmobiles. Damage resulting from...
Owners Manual - Page 150
... Engine components Drive belts Hydraulic components Circuit breakers/Fuses Electronic components
146 The following items are excluded from the use of any dealer to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up and tested by the Owner's manual is highly recommended. Failure of non-recommended products, warranty...
Owners Manual - Page 151
... Loss of materials or workmanship.
147 operator error or abuse; improper maintenance; unauthorized repairs; surface imperfections caused by an unauthorized repair center; repairs made after the warranty period expires or by external stress, heat, cold or contamination; improper engine timing; improper component alignment, tension, adjustment or altitude compensation; use of the...
Owners Manual - Page 154
... or use only Pure POLARIS parts. EPA Emissions Limited Warranty
The exclusive remedy for breach of any service that may maintain, replace, or repair the emission control devices or systems on how long an implied warranty lasts, so the above limitation may deny warranty claims for your vehicle. Owners are responsible for which POLARIS has no...
2012 Polaris Turbo IQ Reviews
We have not received any reviews for the 2012 Polaris Turbo IQ yet.