Stihl SG 31 Support and Manuals
Get Help and Manuals for this Stihl item
Stihl SG 31 Videos
???????????? STIHL® SG 31
Duration: :31
Total Views: 241
Duration: :31
Total Views: 241
STIHL SG 31 SPRAYER REVIEW
Duration: 6:00
Total Views: 4,628
Duration: 6:00
Total Views: 4,628
?Review h??ng d?n s? d?ng máy phun thu?c kh? trùng stihl SG31
Duration: 6:45
Total Views: 192
Duration: 6:45
Total Views: 192
?????? ??????????? STIHL SG 31
Duration: :13
Total Views: 2,241
Duration: :13
Total Views: 2,241
Popular Stihl SG 31 Manual Pages
Instruction Manual - Page 3
...information you read, understand and follow the safety precautions and the operating and maintenance instructions in this manual to operate your STIHL sprayer, it is protected by
User
13
Maintenance and Care
15
Main Parts
16
Specifications
17
Troubleshooting
18
Maintenance and Repairs
19
Disposal
19
Trademarks
19
Addresses
20
English
Allow only persons who fully understand...
Instruction Manual - Page 4
...SG 31 In addition, read , fully understand and observe the following symbols and signal words:
DANGER Indicates a hazardous situation that , if not avoided, could result in death or serious injury. Have your STIHL dealer show you read and follow the chemical manufacturer's instructions...described in the manual may be covered in this sprayer is normally your best guide for spraying chemicals...
Instruction Manual - Page 5
..., including damage to the use it . Always follow all STIHL sprayers. Use your sprayer without the instruction manual. WARNING
Do not use of the sprayer
4.
Avoid direct contact with its product. Safe use this manual. If you
English
have different parts and controls.
Do not operate this sprayer.
WARNING
The chemicals sprayed with the proper handling procedures...
Instruction Manual - Page 6
... in your STIHL servicing dealer. Do not wear shorts, sandals or go barefoot. WARNING
Sprayers may also ...in any way.
Pesticides regulated by your sprayer. "Caution" appears on "Main Parts and Controls." Pesticides with the signal ...sprayer. In case of doubt, have it is subjected to pressurize the unit by NIOSH/MSHA for instance, use with the specific STIHL model are
4
SG 31
Instruction Manual - Page 7
... mixtures can explode causing serious or fatal injury;
- SG 31
English
Fill your sprayer in a vehicle;
Similarly, the EPA rates herbicides with extreme care. To help protect the environment, use only and generally must be used up at this time.
properly secure it with a hose attached to overfill the container with state or federal...
Instruction Manual - Page 8
... disease, cancer, birth defects, or other insecure support. English
maximum mark, the tank contains approximately 5 l (1.32 gal.). WARNING Never use . WARNING Your sprayer is a one-person tool. Bend only at the source where possible. observe the nozzle outlet at all connections are tight, and be sure the hose is damaged or not properly maintained.
Instruction Manual - Page 9
...your instruction manual. When spraying, stand so that the container is in accordance with applicable ordinances.
To release the pressure, pull the piston manometer up all protective clothing separately.
Follow any applicable governmental regulations. In addition, residual chemicals may be in effect. Maintenance, Repair and Storing
WARNING Use only identical STIHL replacement parts for...
Instruction Manual - Page 10
... and turn it until it engages. rotate clockwise - rotate counterclockwise
6159BA006 KN
8
SG 31 to the solution container (3).
4
2
6159BA002 KN
N Ease the housing outwards and thread the strap through the buckle.
6159BA030 ST
N Connect the wand (4) to the spray gun (2). N Connect the hose (1) to unscrew the pump from below. Lock the pump handle: - Shoulder...
Instruction Manual - Page 12
the trigger (2) is locked to check the tank and hose connection for Leaks Carry out test with the tank empty.
1
2
6159BA024 KN 6159BA011 KN
6159BA009 KN
N Pressurize the tank - The ...Unit for Operation
Visual Inspection Do not operate your unit if any more than 0.5 bar (7.25 PSI) within the next 30 minutes.
10
SG 31 the trigger (2) is unlocked and can be operated. Checking for leaks.
Instruction Manual - Page 17
... or daily weekly monthly every 12 months if problem if damaged as required after 50 refills
Complete unit
Tank, hose system, wand
Nozzle Filter Piston cup seal O-ring Safety labels
Visual inspection (condition, leaks) Clean Drain Clean Clean Clean Lubricate with grease Lubricate with grease Replace
X
X X X X
X
X
X
X
X
X
X
X
X
X
SG 31
15 Maintenance and Care
The following intervals...
Instruction Manual - Page 18
....
5. Starts and stops spray jet. For holding and operating the spray wand.
4. Locking Lever.
Brass nozzle. SG 31 Atomizes the spray solution.
2. English
Main Parts
6 3
45
8
2
10
9
7
11
1
12
13
14
15
16
17
16
6159BA034 ST
1 Brass nozzle 2 Spray Wand 3 Spray Gun 4 Locking Lever 5 Trigger 6 Filter 7 Hose 8 Pump Handle 9 Piston Rod 10 Latch on Pump Cylinder 11...
Instruction Manual - Page 19
.... Specifications
Hydraulic Data
Spray pressure, max.:
3 bar (43.50 PSI)
Flow volume, max.: 1.0 l/min (61.02 cu.in Spray Gun. Piston Rod. Guides the piston rod in
container: Seals the pump cylinder.
15. Contains the spray solution.
17. For carrying the sprayer.... manometer shows the pressure in the container. Helps prevent impurities entering and blocking the nozzle.
7. Hose.
Instruction Manual - Page 20
...
O-ring on the unit. pressure in the nozzle Clean nozzle / spinner insert and/or filter
Clean or replace valve disk Replace the unit
18
SG 31 After servicing, carry out test run with clean water. Condition
Cause
Pumping action produces no pressure Pump not tightened down the pump Install new O-ring Install new piston cup seal Fit spinner insert...
Instruction Manual - Page 21
... air emissions systems warranty in some cases, by authorized STIHL servicing dealers using genuine STIHL replacement parts.
Maintenance and Repairs
Disposal
Trademarks
English
Users of this unit's air emissions control system, please refer to an approved disposal site for the latest information on small parts. and #3,400,476)
SG 31
AutoCut® FARM BOSS® iCademy®...
Instruction Manual - Page 22
...; Master Control Lever ™ Micro ™ Pro Mark ™ Quiet Line ™ STIHL M-Tronic ™
20
SG 31 Addresses
STIHL Inc. 536 Viking Drive P.O. KG, Waiblingen is subject to change. English
ROCK BOSS® STIHL Cutquik® STIHL DUROMATIC® STIHL Quickstop® STIHL ROLLOMATIC® STIHL WOOD BOSS® TIMBERSPORTS® WOOD BOSS® YARD BOSS®
Some...
Stihl SG 31 Reviews
We have not received any reviews for Stihl yet.