2007 Polaris 600 HO Switchback CFI Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2007 Polaris 600 HO Switchback CFI manuals!
Problems with 2007 Polaris 600 HO Switchback CFI?
Ask a Question
Other Models
Free 2007 Polaris 600 HO Switchback CFI manuals!
Problems with 2007 Polaris 600 HO Switchback CFI?
Ask a Question
Other Models
Popular 2007 Polaris 600 HO Switchback CFI Manual Pages
Owners Manual - Page 3
WARNING
Read, understand, and follow the safety precautions could result in this manual and on all product labels.
Failure to follow all of California to the State of the instructions and safety precautions in serious injury or death. WARNING
The engine exhaust from this product contains chemicals known to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 4
... is outlined in the Polaris Service Manual and should be sure to your door!
1
Have your accessories and clothing delivered right to follow the instructions and recommendations in this owner's manual. For safe and enjoyable operation of Polaris enthusiasts. Be sure to return to our worldwide family of your vehicle, be performed only by a Factory Certified...
Owners Manual - Page 6
...identification numbers that must be recorded in the owner's manual. Polaris Products...Troubleshooting ...Warranty ...Maintenance Log ...Index ...
130 131 138 147 150
3 Pre-Ride Inspections ...68
This section explains procedures that should be performed before riding. TABLE OF CONTENTS
Safety ...6
This section describes safe vehicle operation and identifies warning decals and their locations...
Owners Manual - Page 7
...specific mileage intervals. Protect and preserve your right to us. INTRODUCTION
Vehicle Identification Numbers
Record your snowmobile's identification numbers and key number in the snowmobile for Owners and Drivers
After reading this manual... key can be replaced.
9
Vehicle Model Number: _____ Tunnel VIN (9)(lower right side of the tunnel): _____ Engine Serial Number (on recoil housing):...
Owners Manual - Page 24
...found under the hood on the clutch cover:
WARNING Do not operate engine with drive belt removed. Never service clutches yourself -- see your snowmobile, always read and follow the instructions...removed. Do not operate engine with engine running. Test or replace when changing coolant.
Read and follow the instructions of the decals depicted in this manual differ from the decals on...
Owners Manual - Page 26
SAFETY
9
9
If electric reverse: • Machine stopped and engine at low speeds, can cause loss of control, always: • Look behind before... the console, either below the windshield or beside the steering post. NOTE: For more information, see Owner's Manual.
Operation Warning
The operation warning decal is located on the console, either below the windshield or beside the steering...
Owners Manual - Page 27
...obstacles, or to stop the engine. Check oil level when refueling.
24 If manual is capable of the throttle control assembly, to stop . • To maintain vehicle control on hard-packed snow... than five minutes. • Before starting engine, check throttle, brake, and steering for steering and stopping. Oil injection system: Use unmixed fuel only. Make sure hood is designed for...
Owners Manual - Page 37
... SET button to cycle through the odometer, Trip 1, Trip 2, Trip F (if equipped with electronic fuel gauge) and Clock settings.
34
FEATURES
Instrumentation
MFD Digital Display Programs
Press the MODE button to cycle through the three MFD programs: Performance, Engine and History. While in the display until another is opposite the analog display. Each...
Owners Manual - Page 72
... function smoothly, or if you discover excessive lever freeplay, DO NOT start the engine. Before Starting the Engine WARNING
PRE-RIDE INSPECTIONS
Worn, damaged, or malfunctioning components may cause serious injury or death. Read and Understand Your Owner's Manual
Read the Owner's Manual completely and refer to the idle position without binding or hesitation.
Owners Manual - Page 86
... when the throttle lever is released: 1. Test the throttle lever by compressing and releasing it 's necessary to an authorized Polaris dealer for service. If the engine doesn't start the engine. If the throttle lever operates properly, turn the ignition switch on and go through normal starting . DO NOT continue to an authorized Polaris...
Owners Manual - Page 89
... or transmission if shifting is attempted when the engine is operating above idle speed. • Shift to make sure the machine is at low speeds, may cause loss of control, resulting in forward.
86 Disengaging Reverse
1. Push the yellow reverse button for one second and release. Make sure the area behind the vehicle...
Owners Manual - Page 92
The specified maintenance for the fuel filter is performed, including the emission-related maintenance ... valves to perform any service that the specified maintenance is recommended additional emissionrelated maintenance. Emission Control Information
Owner's Responsibilities
MAINTENANCE
Please read the Snowmobile Engine Emissions Limited Warranty on your owner's manual. You must...
Owners Manual - Page 107
... High Temperature Indicator Light
The high temperature indicator light will illuminate when engine coolant temperature becomes too hot for service. Driving in deep snow will be reduced if you must be performed when the engine is on your skin.
Add coolant if the level is warm or hot. MAINTENANCE
Cooling System WARNING
Steam and...
Owners Manual - Page 134
...the track clips due to lack of spec Engine mount broken or loose • SEE YOUR DEALER. • Inspect and replace. Problem
Erratic engine operating RPM during acceleration or load variations ...; Replace the drive belt. SEE YOUR DEALER. Engine Troubleshooting
TROUBLESHOOTING
Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems arise.
Owners Manual - Page 141
Contact your snowmobile and its engine. Model number 3. Length of time and conditions of trouble experienced 6. Dealer name 4. When contacting us about parts, service, or warranty, always provide the following information: 1. Previous correspondence Use the page provided near the front of your Owner's Manual to assist you. Serial number 2. Your dealer is also familiar with...
Owners Manual - Page 144
...
1. Mixing oil brands or using non-recommended oil may use any Polaris Servicing Dealer to state. Damage resulting from state to perform warranty service.
Limitations of Polaris engine oil. 2. however, you must present your original selling dealer; This warranty gives you specific legal rights, and you must take it to a Polaris dealer authorized to and from the...
Owners Manual - Page 145
... the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up /delivery Loss of vacation/personal time
This warranty also excludes failures resulting from the use of aftermarket components resulting in competition or for commercial purposes. improper fuel; Should a failure occur during the warranty period resulting from improper...
Owners Manual - Page 146
... is automatic with the odometer shall void all warranties/service contracts. The free Second Year Engine Service Contract is automatic. Polaris Second Year Engine Service Contract
WARRANTY
Second Year Engine Service Contract is standard on Snow Check units is subject to a $50 deductible per visit. Consumer Exclusions
• Each repair visit after the original purchase date, free of...
Owners Manual - Page 147
... Customer Assistance (see page 138).
144 You should take your vehicle. You may not give authorization for warranty or service bulletin coverage of any kind. (Vehicles registered to Safety Recalls. WARRANTY
Exported Vehicles
EXCEPT WHERE SPECIFICALLY REQUIRED BY LAW, THERE IS NO WARRANTY OR SERVICE BULLETIN COVERAGE ON THIS VEHICLE IF IT IS SOLD OUTSIDE THE COUNTRY OF THE SELLING DEALER...
Owners Manual - Page 149
... the above limitation may result in the owner's manual. Owners are responsible for performing the scheduled maintenance identified in civil penalties.
146 It is not performed. Performance of other similar causes beyond the control of the vehicle's emission controls. Polaris can deny an emissions warranty claim if any engine that has been structurally altered, or any specified...
2007 Polaris 600 HO Switchback CFI Reviews
We have not received any reviews for the 2007 Polaris 600 HO Switchback CFI yet.