2003 Yamaha Motorsports Vmax 600 ER Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2003 Yamaha Motorsports Vmax 600 ER manuals!
Problems with 2003 Yamaha Motorsports Vmax 600 ER?
Ask a Question
Other Models
Free 2003 Yamaha Motorsports Vmax 600 ER manuals!
Problems with 2003 Yamaha Motorsports Vmax 600 ER?
Ask a Question
Other Models
Popular 2003 Yamaha Motorsports Vmax 600 ER Manual Pages
Owners Manual - Page 1
SNOWMOBILE
OWNER'S MANUAL
SX600H VT600H VX600ERH
LIT-12628-02-25
8DG-28199-14
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
... for satisfactory service. is necessary; The most advanced production equipment and technology have the techniques, tools, and parts to ensure your Yamaha snowmobile. Any reprinting or unauthorized use without the written permission of the best snowmobile manufacturers. Should major repairs ever be required, you are confident that the information within this manual will...
Owners Manual - Page 5
... by the following notations. BECOME ALERT! NOTE:
@
A NOTE provides key information to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile. WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually seeks advancements in severe injury or death to make procedures easier or clearer. This...
Owners Manual - Page 6
...WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Oil level warning light...5-3 Coolant temperature warning light ...5-4 Engine...CHECKS ...6-1 Fuel ...6-1 Engine oil...6-2 ...
Owners Manual - Page 7
... MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-5 Throttle cable adjustment ...8-6 Oil pump cable adjustment ...8-6 Carburetor adjustment...8-7 High altitude......8-31 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-1 Electric...11-2 WIRING DIAGRAM ...12-1
Owners Manual - Page 14
... on pages 6-1-6-9 before starting the engine. Passengers are designed to the home position when it returns to carry the OPERATOR ONLY. For safety and proper care of the snowmobile, always perform the pre-operation checks on public streets, roads, or highways. Never drive the snowmobile with another vehicle. 3. Apply the parking brake before...
Owners Manual - Page 15
A broken track, track fittings, or debris thrown by the track could cause an accident and injury.
3-2 Handle fuel with extreme care. G Never add fuel when the engine is HIGHLY FLAMMABLE. G Use an approved fuel container. Never remove the fuel cap indoors. G Never refuel while smoking or in or out of an open flame. Wipe up any...
Owners Manual - Page 16
...damage or result in the fuel tank inside a building where ...the removal of control and may leak out from the fuel breather hose. 2. Do not leave the snowmobile on ... cause loss of original equipment may render your snowmobile. 6. Fuel may damage the snowmobile. 4. Modifications made to release the ... may need help if you run out of fuel, have an accident, or damage your snowmobile unsafe for...
Owners Manual - Page 21
...has been corrected and that the engine can be operated without a problem before restarting the engine. will operate
CA-01E
B
Mode A Idle or Switch starting Throttle switch Off Carburetor switch On Engine È É Ê... light
If the oil level falls below the lower level, this light comes on , add engine oil to use the specified spark plug and spark plug cap. Be sure to the oil tank...
Owners Manual - Page 22
... flash pattern, and then have a Yamaha dealer inspect the electrical circuit. Then, check that the wire harness couplers are no problems. (See page 5-5 for warning light flash pattern numbers 1-7.) Stop the engine and allow it to check the bulb, and then goes off . The coolant temperature warning light warns the rider of...
Owners Manual - Page 39
..., then pull it is applied. Pull slowly on position.
@
1. Make sure that the engine stop switch is warm. Turn the main switch to check the "SAFETY INFORMATION" section carefully ...when the starter lever (choke) is returned to the closed position.
@
Manual starting model For SX600 2. ESU00112
7- OPERATION
ESU00281
Starting the engine
WARNING
@
G G
@
Be sure to the "ON" position. 1...
Owners Manual - Page 40
..."
CAUTION:
@
G G
Release the switch immediately after the engine starts. Proceed with the "Starting the engine" section items 1 and 2 for the "Manual starting model For VT600 / VX600ER 2. Electric starting model".
2. After the engine starts, put the starter lever (choke) in the tool kit at the factory.
@
1. If the engine fails to the "START" position.
Warm up the...
Owners Manual - Page 41
... contact with the edge of the primary sheave assembly. 1 Rope stopper 2 Primary sheave assembly edge
4.
Install the drive guard and shroud. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model For VT600 / VX600ER Follow the procedures in the half-open position. Warm up the...
Owners Manual - Page 43
...Owner's Manual completely ...With the engine idling, ...performance until you have become thoroughly familiar with the snowmobile's handling and performance characteristics. Take the time to learn the basic techniques well before attempting more reliable...vehicle, and your riding position and your balance are the two basic factors of maneuvering your snowmobile
Before you ride, always perform...
Owners Manual - Page 54
...service operation requiring one, take the snowmobile to properly tighten nuts and bolts. 1Tool kit B È SX600 / VX600ER É VT600
CAUTION:
@
Before starting the engine, make sure that is secured with the engine... track air leak or carburetion problem for most periodic maintenance and minor repair. A
ESU00143
Tool kit
The owner's tool kit has the tools which are sufficient...
Owners Manual - Page 59
... available at high altitude reduces the performance of a gasoline engine to prevent fuel flowing. 3. WARNING
@
Make sure that the throttle outer cable is less air as altitude increases. This is because there is firmly seated in high altitude riding. Pinch the fuel hose to about 3% for combustion.
Common problems are the most of elevation. Carburetor...
Owners Manual - Page 65
...
A
B
3. It is used to remove any part of your body or clothing during inspection or repair.
@
1. G Wipe off with a clean rag.
CAUTION:
@
There is between the upper and...2. When removing the dipstick be very hot after the engine has been run. Avoid touching the engine and muffler while they are still hot with reverse transmissions (VT600 / VX600ER)
CAUTION:
@
Make sure that...
Owners Manual - Page 83
... twists 1. Engine does not turn the engine over with the ignition off to expel excess fuel. "Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been ...Problem with the correct V-belt. 2. system ...See A.2. Air in the drive track, or slide runners have melted to the slide metal due to inspect. 2. I. Engine power is caused by poor lubrication, inadequate fuel...
Owners Manual - Page 87
SPECIFICATIONS
SX600 / VT600 / ...Engine oil type Carburetor type Fuel
SX600 / VT600 / VX600ER Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SX600 Electric and manual with recoil starter: VT600 / VX600ER Pump...
2003 Yamaha Motorsports Vmax 600 ER Reviews
We have not received any reviews for the 2003 Yamaha Motorsports Vmax 600 ER yet.