Hayward AquaTrol Research

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 1
Aqua Trol® Above Ground Pool Chlorine Generator Operation and Installation Manual AQ-TROL-RJ AQ-TROL-RJ-TL AQ-TROL-HP AQ-TROL-HP-TL www.haywardnet.com

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 2
... electric shock, connect the local common bonding grid in size to the circuit conductors supplying the equipment. • One bonding lug for US models (two for Canadian models) is located inside the wiring compartment. To reduce the risk of electric shock, this terminal must be bonded ...the external surface. IMPORTANT SAFETY INSTRUCTIONS When using this product unless they are closely supervised at all AC power during installation. • Warning - To reduce the risk of the pool, spa or hot tub shall be connected to the grounding means provided in the electric supply service panel ...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 3
Table of Contents OPERATION The Aqua Trol 1 Water Chemistry 1 Controls 6 Maintenance 8 . INSTALLATION Mounting 9 Plumbing 10 Wiring 11 TROUBLESHOOTING Troubleshooting 13 WARRANTY Warranty 15

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 4
... reactions will not be mounted directly to your chlorinator cell. 1 The Aqua Trol incorporates a built in your pool by converting the salt into free chlorine which kills bacteria and algae in filter pump timer designed specifically for return jet mounting AQ-Trol-RJ-TL "Twist lock" 120V/20A linecord/receptacle; The Aqua Trol is available with 1½" - 1¼" flexible hose or to 18,000 gallons...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 5
... dissolved into the water. Test your measurements. If the Si is below to maintain these levels in the water and is corrosive and plaster pool walls will occur. If the Si is important that you are recommended by the National Spa and Pool Institute (NSPI). If... from your water periodically. Insert values of the pool. The only special requirement for the Aqua Trol is 0 ±.2. Use the chart above to use: Measure pool pH, temperature, calcium hardness, and total alkalinity. The table on page 2 summarizes the levels that are using an Aqua Trol chlorine generator. If...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 6
... the salt to evaporation. Type of Salt to Use It is important to use rock salt, salt with more than 1% yellow prussiate of the pool. This is unknown. The salt in low chlorine production. A low salt level will begin to give a salty taste to your pool is also acceptable to use the pool vacuum if there is between 2700-3400 ppm (parts per million) with more than 1% of the Aqua...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 7
POUNDS and (Kg) OF SALT NEEDED FOR 3200 PPM Gallons and (Liters) of Pool/Spa water Current salt level 6,000 8,000 10,000 12,000 14,000 16,000 18,000 ppm (22,500)(30,000)(37,500) (45000) (52,500) (60,000) (67,...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 8
...check stabilizer (cyanuric acid), when checking salt. Use the chart below to determine how much stabilizer must be added to raise the level to 80 ppm. POUNDS and (Kg) OF STABILIZER (CYANURIC ACID) NEEDED FOR 80 PPM Gallons and (Liters) of Pool/Spa water Current Stabilizer Level... 4.0 (1.1) (1.4) (1.6) (1.8) 4.5 (2.0) 60 ppm 1.0 (.5) 1.3 (.6) 1.7 (.8) 2.0 2.4 2.7 3.0 (.91) (1.1) (1.2) (1.4) 70 ppm 0.5 0.7 0.8 1.0 1.2 1.4 1.5 (.2) (.3) (.4) (.45) (.54) (.64) (.68) 80 ppm 0.0 0.0 0.0 0.0 0.0 0.0 0.0 5 These levels will most likely decline together.

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 9
... the pool equipment or the Aqua Trol, turn the power off at the circuit breaker. This will vary depending on during Super Chlorination. pump ON " " (center) - Raise this position there is a switch on or off , whichever comes first. Consult a local pool store to the "Desired Level %" adjustment setting for 24 hours (filter pump must be on pump size, pool plumbing and pool size. In this setting to increase chlorine level and lower it to operate. Controls Timer The pool filter pump should...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 10
... a few days of the pool water. HIGH SALT When illuminated, the salt level is higher than normal bather load or when your salt level professionally checked. INSPECT CELL A flashing indicator signifies that either case, inspect the cell and clean if necessary. Pressing the "diagnostic" button next to have your chlorinator cell ages. With the temperature displayed, move the main switch from AUTO to SUPER CHLORINATE to splashing, backwashing, rain, etc. Once determined...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 11
... way to coil the wiring before removing the electrolytic cell. It may be helpful to avoid this by freezing water just as your filter. Winterizing The Aqua Trol electrolytic cell and flow detection switch will be damaged by flashing the "Inspect Cell" LED after approximately 500 hours of operation. The Aqua Trol electrolytic cell has a self cleaning feature incorporated into the electronic control's logic. In most cases this...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 12
... the pool, per manufacturers instructions. The control is important not to page 2 for outdoor mounting. Installation Installation must be balanced BEFORE activating the Aqua Trol. Preparing Pool Water Refer to block the four sides of the control. The pool's chemistry must be mounted a minimum of non-copper based algaecide to the Aqua Trol system. Because the enclosure also acts as a heat sink (disperses heat...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 13
... the hose/pipe installation (HP) is downstream from the pipe union tailpiece and install them in the Aqua Trol provides the necessary plumbing components for a watertight seal. Tighten all the pool equipment (filter, heater, solar, etc.). Always make sure that the cell be mounted vertically directly below for a watertight seal. Note that this installation does NOT require a flow switch--however it is very important that the flow switch...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 14
...-XX-TL) BONDING LOOP PUMP 11 For Canadian installations: Connect to follow Local and NEC/CEC electrical codes. The Aqua Trol has been designed to a GFCI circuit breaker. Input Power Models with the standard 120 VAC line cord should be plugged into a twist lock receptacle wired to easily wire into a GFCI receptacle. Twist lock models should be plugged into typical above ground pool systems. To provide safe operation, the Aqua Trol must be...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 15
... pool bonding system using minimum 8AWG copper wire if required by code. The 120 VAC standard or twist lock pump receptacle is located outside, on the pump motor. Check the electrical rating marked on the bottom of the Aqua Trol enclosure. Note that return jet units (-RJ option) will NOT have a flow switch. Electrolytic Cell and Flow Switch The cell and flow switch plug into connectors on the Aqua Trol electronics unit. Pump Output The Aqua...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 16
..." LED flashing The temperature of the pool water is input power, the fuse may have blown. Troubleshooting Diagnostic Displays Sequential pushes of the small "diagnostic" button next to the LCD display will revert back to the standard salt display. If there is too high or low to operate. "Generating" LED not on the bottom of the 13 Product name sent to SUPER CHLORINATE. "Power" LED not on " (top) position. "No Flow" LED illuminated...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 17
... 8. "-Pcb-" displayed and all 4 red/yellow LEDs are pointing in OFF position. - A possible Printed Circuit Board fault has been detected. 14 If there is adequate flow and the LED is still on, check that the wire is still illuminated, the cell may be worn and need replacement. 10. Aqua Trol switch in the direction of flow. 6. Filter pump switched off or filter pump time too short (8 hours for average size pools, more for scale. Cold water (below...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 18
... in the owners manual(s). 5. Problems resulting from failure to install, operate or maintain the product(s) in accordance with the recommendations in the owners manual(s). 4. Problems resulting from the initial date of installation on pools larger than the product rating. 3. Hayward/Goldline warrants all accessories and replacement parts for the above -identified pool automation and chlorination products installed on commercial swimming pools and on authorized service centers please contact the Hayward/Goldline Technical Service Support Center (61...

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Page 20
... to decrease -OR- WEEKLY MONTHLY ELECTROLYTIC CHLORINE GENERATOR BASIC POOL MAINTENANCE REQUIREMENTS TEST IDEAL RANGE ADJUSTMENT REQUIRED Free Chlorine pH 1.0 - 3.0 ppm 7.2 - 7.8 Raise desired output % to increase, lower desired output % to www.goldlinecontrols.com for latest manual revisions, additional information and helpful service. add soda ash. Drain and add water to increase. Questions? Too high - Stabilizer 60 - 80 ppm Add cyanuric...

Hayward AquaTrol Research

Related Manual Pages

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Models: AQ-TROL-HP AQ-TROL-HP-TL AQ-TROL-RJ and AQ-TROL-RJ-TL

Related Videos

Similar Questions

Related Terms

Ask a New Question

Manuals / Documents

Related Items

Points & Prizes

Hayward Manuals

Hayward Reviews

Contact Information

Scoreboard Ratings

Hayward Recalls