Hayward HCF7030C Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward HCF7030C manuals!
Problems with Hayward HCF7030C?
Ask a Question
Free Hayward HCF7030C manuals!
Problems with Hayward HCF7030C?
Ask a Question
Popular Hayward HCF7030C Manual Pages
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 1
ISC7031HCF
HCF CARTRIDGE FILTER
MODEL
HCF7030C
EFFECTIVE FILTRATION RATE
DESIGN FLOW RATE Commercial
FT2
M2
GPM
LPM
700
63.2
150
568
MAXIMUM WORKING PRESSURE 50 PSI (3.45 BAR)
ATTENTION INSTALLER: THIS MANUAL CONTAINS IMPORTANT INFORMATION ON THE OPERATION, AND SAFE USE OF THIS EQUIPMENT.
Model: HCF7030C
THIS MANUAL IS INTENDED FOR THE END USER OF THIS PRODUCT.
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 2
...and Repairs
10. Characteristics and Dimensions
3.1 Before Starting the Pump
4. Table of the Manual Air Relief Valve
8. Important Safety Instructions
2. Vacuuming Pool
7. Replacement Part Drawings and Numbers
11. Warranty Card Registration
5 3
6 a b c d e
8 7 9 25
10 a b
14
15 a b c d e
18
19
20
21
4 1 2
11 12
13 a b c d e
16
17
22 23 24
25 26
HCF Cartridge Filter
Model: HCF7030C...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 3
... filter to close manual air relief valve only when a steady stream of the upper filter body if safety and operation instructions are set in filter upper body. • Before starting the system pump, verify that are important but not related to the filter until all times. Important Safety Instructions
This is assembled improperly, damaged, missing, or
not a genuine Hayward...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 4
...replaced within specified life.
4 A limb inserted into an opening of two functioning suction outlets per pump must be installed a minimum of three feet (3') [1 meter] apart, as the ICC International Residential Code Part IX, Appendix G, Section AG106 specifies
the installation...codes for
bonding requirements. • Verify water discharge from the filter manual... if any service or maintenance ...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 5
... of water clarity and long filter cycles with ease of the filter (filter INLET).
7. HCF7030C
A
IN
CM
52.5 133
REQUIRED CLEARANCE
"F" SIDE
"B" ABOVE
IN CM IN CM
18 46 28 71
2.1 Installation WARNING
Manual Air
B
Relief Valve
(MAR)
26 " 66 CM
This product should be installed and serviced only by gravity.
Position filter so the filter will drain by a qualified...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 6
... the Pump
1. Use ONLY Hayward clamp system components; Using a ¾" socket on page 7 in the LOCK position, and no filter components are properly secured with the filter body clamp.
STARTING THE PUMP AND FILTER SYSTEM
3. Place the manual air relief valve in use and cause explosive component separation. Verify that the filter manual air relief body is...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 7
... will decrease.
Set all
electric power on the equipment pad.
2. The manual air relief valve must be replaced rather than 6 PSI above the starting pressure is steady through the filter. Do not..., because the clamp
could be installed and
serviced only by
lifting over the upper filter body. OPERATION
4. Operation
4.1 Filtering
WARNING
Filtration starts as soon as they can be...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 8
.... Remove the top Manifold, which may not have been removed with a garden hose. CLAMP NUT
Figure 5
CLAMP BOLT
Figure 6
4.3 Removing Cartridges
1. Remove the filter cartridge elements by washing inside and outside with hosing. Do not pressure wash as it can be cleaned by using slight rocking motion and lifting ...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 9
...3. WARNING
WARNING: This product should be installed and serviced only by a qualified pool professional.
9 Carefully replace the cartridges over the hubs on top of cartridges, aligning the return pipe with the port in the manifold.
5.2 Clean Seal Ring and Seal Surface
Figure 7
1.
Filter Re-Assembly Instructions
5.1 Re-Installing Cartridges
WARNING
1. Flush any dirt or...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 11
... season to UNLOCK
4.
Set all
electric power on top of the Manual Air Relief Valve
This product should be installed and serviced only by a qualified pool professional. Winterizing Filter
WARNING
This product should be serviced, follow REMOVING CARTRIDGES per FILTER RE-ASSEMBLY INSTRUCTIONS. 5. Check the o-ring seals, replace as needed. 2. Manual Air Relief Valve / WINTERIZING...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 12
...) 1.0 to 3.0 ppm CHLORINE STABILIZER 60 to 80 ppm
(Cyanuric Acid)
PROBLEM SOLVING LIST
LOW WATER FLOW 1. Head Loss (FT water)
Head Loss HCF7030C Top Manifold
14
12
10
8
6
4
2
0
0
20
40
60
80
100
120
140
160
Flow (GPM)
12 SHORT FILTER CYCLES 1. SERVICE AND REPAIRS
REMEDY
9. Check for air leak in pool and
super-chlorinate...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 13
...DRAWING AND NUMBERS
10. Replacement Part Drawing and Numbers
Model HCF7303C
# Description
Hayward Part #
1 Pressure Gauge
ECX2712B1
2 O-Ring Kit (Set of 2)
DEX2420Z8A
3 Air Relief Valve Nut
CCX1000N
4 Manual Air Relief w/O-Ring
CCX1000V
5 Manual Air Relief Assembly
DE2420MAR2
6 Upper Filter Body HCF7030C DEX7220B3C
7 Clamp Bolt & Nut
DEX2421J2
Clamp System-including: Clamp, Clamp...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 14
... freezing, negligence, improper installation, improper use or care or any Acts of Hayward Commercial Pool Products with respect to you may not apply to its filters to components manufactured by the respective manufacturer will be repaired or replaced, at www.haywardcommercialpool.com. Some states do not allow a limitation on your nearest Hayward Authorized Service Center please visit...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 15
...) ___ Please include me on all e-mail communications regarding Hayward® equipment or promotions. Product Registration
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER
* Retain this Warranty Certificate in service: 15 ___ Purchased from Builder ___ Retailer ___ Pool Service ___ Internet/Catalog ___ Company Name Address City State___________ Zip...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 16
... in:
1-800-657-2287
Our toll-free line will put you . Hayward Commercial
10101 Molecular Dr. I Suite 200 I Rockville, MD 20850 Visit us at: www.haywardcommercialpool.com Total System: Pumps I Filters I Heating I Cleaners I Sanitization I Automation I Lighting I Safety I White Goods I Flow Control
Hayward is ready to serve you in direct contact with an experienced...
Hayward HCF7030C Reviews
We have not received any reviews for Hayward yet.