Hayward HCP 3000 Series Pump 2.0 HP Three-Phase Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward HCP 3000 Series Pump 2.0 HP Three-Phase manuals!
Problems with Hayward HCP 3000 Series Pump 2.0 HP Three-Phase?
Ask a Question
Free Hayward HCP 3000 Series Pump 2.0 HP Three-Phase manuals!
Problems with Hayward HCP 3000 Series Pump 2.0 HP Three-Phase?
Ask a Question
Popular Hayward HCP 3000 Series Pump 2.0 HP Three-Phase Manual Pages
HCP3000 Series Pump Owners Manual - Page 1
...unpredictable and unsafe.
ISHCP3000 Rev-D
HCP3000 SERIES Pump
Owner's Manual
Contents
Full Table of Contents 2 General Product Warnings..........3 Installation and Wiring 6 Start up and Operation 8 Shaft Seal Replacement............10 Replacement Parts 12 Warrantee 15 Registration 16
IMPORTANT SAFETY INSTRUCTIONS
The Hayward HCP3000 Series pump is a series of high technology self-priming...
HCP3000 Series Pump Owners Manual - Page 2
... Change Instructions ...10
7.1. Removing the Impeller
10
7.3. Replacement Parts...12
8.1. Parts Listing
12
9. General Problems
13
10. Pump Location
6
3.2. Removing the Ceramic Seat
10
7.4. Warranty...15
Hayward® Pool Products Limited Warranty ...15
11. Grounding and Bonding
7
3.9. Starting/Priming the Pump
9
5. Maintenance ...9
6. Seal Installation...
HCP3000 Series Pump Owners Manual - Page 3
... means of access to the following entrapment hazards:
Hair Entrapment-
CAUTION -
Before starting the circulation system. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
3 THIS MANUAL CONTAINS IMPORTANT INFORMATION ABOUT THE INSTALLATION, OPERATION, AND SAFE USE OF THIS PUMP THAT MUST BE FURNISHED TO THE END USER OF THIS PRODUCT.
Mechanical Entrapment- To Reduce the risk of injury...
HCP3000 Series Pump Owners Manual - Page 4
... exceed 104°F [40°C]. HAYWARD® pumps are recommended
by a qualified service representative before connecting to reinforcing rod or mesh. Do not use , it rains. Prolonged immersion in severe personal injury or death.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
4 Do not operate pool and spa circulation system unless filter manual air relief valve body is defective...
HCP3000 Series Pump Owners Manual - Page 5
... PARTS
5 Unconsciousness resulting in pregnant women. 6. Failure to install according to defined instructions will void warranty.
2.2 Primary Features
Advanced hydraulics for the proper installation and operation of heart disease, circulatory problems, diabetes or blood pressure problems should check the water temperature with a medical history of the Hayward HCP3000 Series pump...
HCP3000 Series Pump Owners Manual - Page 6
... servicing pump ...20" [508]
6" [152]
30" [762]
* Note: It is advised to place pump and filter in the shade to shield them from the suction outlet system, the maximum water velocity in the pump suction hydraulic system must comply with the latest ASME/ANSI Specification for cooling.
3.2 Pump Mounting
Install pump...HAYWARD GENUINE REPLACEMENT PARTS
6 It is completely blocked. Secure pump...
HCP3000 Series Pump Owners Manual - Page 7
... 7.2
PUMP MODEL HCP30201 HCP30203 HCP30301 HCP30303 HCP30503 HCP30703
RATED HP 2 2 3 3 5 7
50 Hz Electrical Data
TOTAL HP PHASE
VOLTAGE
...codes, regulations, and the National Electric Code
(NEC).
Install, ground, bond, and wire pump...HAYWARD GENUINE REPLACEMENT PARTS
7 For indoor & outdoor use size and type wire required by code. Permanently ground pump. Bond pump to electrical service...
HCP3000 Series Pump Owners Manual - Page 8
...install the motor end cover and all Hayward pump and system components are two terminals labeled L1 and L2.
Pump MUST be permanently connected to ensure plumbing system is functioning properly, then the following criteria should be sure to local codes, regulations and the National Electric Code... sizes.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
8 Remove the motor...
HCP3000 Series Pump Owners Manual - Page 9
... open when pump is running. See "Shaft Seal Change Instructions" in severe personal injury.
4.2 Starting/Priming the Pump
Rotate strainer...manual air relief valve only when a steady stream of pump suction. WARNING - Running pump dry may damage pump and voids warranty. See Troubleshooting Guide.
5. Replace with water before starting the pump. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
HCP3000 Series Pump Owners Manual - Page 10
...Shaft Seal Change Instructions
IMPORTANT SAFETY INSTRUCTIONS PLEASE READ AND FOLLOW ALL INSTRUCTIONS When servicing electrical equipment, basic safety precautions should attempt rotary seal replacement. Contact your local authorized Hayward Dealer or
service center if you have any questions. See "8.1 Parts Diagram" Figure 0-1 for pump component locations.) 3.
Disconnect pump from the...
HCP3000 Series Pump Owners Manual - Page 11
...), Torque screws to pump housing (item #9) using the two (2) hex shaped screws. Clean and lightly lubricate the motor shaft and seal recess in a clockwise direction. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
11 Gently wipe the black, polished surface of the spring seal assembly with a dilute solution of the ceramic seat. Replace if damaged). Fig 7.3.1
7.4 Seal Installation
7.
HCP3000 Series Pump Owners Manual - Page 13
... undersized wiring). Troubleshooting
No. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
13
open switches or relays; Check for the available field supply voltage. 3. Make sure the terminal board connections agree with O-Ring
23 HCXP3000F
Pump Housing Base
24 HCXP3000G
Motor Support Base
25 SPX1600Z5SSPAK7 Base Screws (7 Pack)
26 HCXP3000N250
Right and Left Side Plate Set, Platinum Color...
HCP3000 Series Pump Owners Manual - Page 14
... Sand filters - Inspect other plumbing connections, and tighten as per manufacturer's instructions; Plugged, restricted, or damaged impeller. Clean the pump housing. 4. Place pump closer to improper mounting, etc. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
14 Tighten the pipe/union connections. a. If the pump develops a vacuum, check for debris. Check voltage to the equipment pad...
HCP3000 Series Pump Owners Manual - Page 15
...replacements or repair.
This warranty gives you specific legal rights, and you .
10. In the event proof of purchase is not available, the manufacturing date of Hayward Pool Products with respect to its pumps... warranty service, please contact the place of God. Hayward Pool Products 620 Division Street Elizabeth, NJ 07207
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
15 Parts that fail...
HCP3000 Series Pump Owners Manual - Page 16
... Zip Phone Number Purchase Date E-Mail Address
Builder Retailer Pool Service Internet/Catalog Company Name Address City State_____ Zip__________
Serial Number
(10-17 digit number)
Model Number
Pool Capacity U.S. Gallons)
Phone
Type of purchase/installation or register online at WWW.HAYWARD.COM
HCP3000 SERIES Pump
Please Print Clearly: First Name Last Name
Street Address...
Hayward HCP 3000 Series Pump 2.0 HP Three-Phase Reviews
We have not received any reviews for Hayward yet.