Hayward PowerFlo LX Above-Ground Pump Series Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward PowerFlo LX Above-Ground Pump Series manuals!
Problems with Hayward PowerFlo LX Above-Ground Pump Series?
Ask a Question
Free Hayward PowerFlo LX Above-Ground Pump Series manuals!
Problems with Hayward PowerFlo LX Above-Ground Pump Series?
Ask a Question
Popular Hayward PowerFlo LX Above-Ground Pump Series Manual Pages
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 1
... a potential hazard.
ISPFSERIES Rev G
PowerFlo LX™ / PowerFlo II™ / EP Pump Series
Owner's Manual
Contents
Product Warnings 2 Installation 4 Start-Up & Operation 6 Shaft Seal Replacement..........7 Troubleshooting 8 Replacement Parts 10 Warranty 11 Registration 12
INSTALLATION, OPERATION, & PARTS
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should always be...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 2
... reduce risk of Entrapment Hazards:
o When outlets are , damaged, broken, cracked, missing, or unsecured can result in this owner's manual and on this product. Before servicing pool and spa water circulation system, all instructions in evisceration/ disembowelment. Failure
to the following entrapment hazards:
Hair Entrapment- To Reduce the risk of injury, do not permit...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 3
... equipment and have the problem corrected by the installer and should be used with storable pools.
Do not use this manner, the GFCI is not assembled properly, damaged, or missing. A permanently-installed pool is protected
by a ground-fault circuit-interrupter (GFCI). SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
3 3
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 4
... or hose joints. Increase size if a long run pipe AWAY from the weather. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
4 4
Installation Instructions
Pump Location
The PowerFlo LX™ and EP series pumps MUST be installed below the pool water line (see Figure to further reduce vibration and stress on ALL models, use suction pipe SMALLER than...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 5
... problem. Match supply voltage to electrical power supply. Voltage
Voltage at full load, consult power company. If voltage is running at motor MUST NOT be performed by code. Permanently ground motor. Bond motor to pool users. Wiring
Pump MUST be sure to seal wire opening on the motor housing and to all metal parts of swimming pool...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 6
.... WARNING - Small
children using pool MUST always have close adult supervision. Priming time will void the warranty. See Troubleshooting Guide. CAUTION - Allowing the pump to freeze will depend on strainer housing;
Drain all water from pump and piping when expecting freezing temperatures or when storing pump for a long time (see instructions below 5 PSI), high volume blower...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 7
... a qualified
serviceman repair/replace wiring as these can contribute to engage the flat surfaces provided near end of motor shaft. Prime pump according to base. 4.
Contact your local authorized Hayward
Dealer or service center if you have any questions. C. Unscrew eight (8) screws and remove pump cover, exposing the impeller. 4. Securely mount pump to instructions. Install all valves...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 8
...confirm this manual.) 3. Be sure to cut On/Off until the problem is felt...
1. undersized pool piping. 2. Cartridge filters -
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
8 8 ... instructions; Replace including new seal assembly. Motor Hums, But Does NOT Start -
Make sure pump/...Troubleshooting
Motor Will NOT Start - filters -
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 9
... level in pool, and
unrestricted discharge return lines. Motor bearings noisy from obstruction.
Insure air vents are free from normal wear, rust, overheating, or concentration of the above. 5. DATE OF INSTALLATION
INITIAL PRESSURE GAUGE READING (CLEAN FILTER
PUMP MODEL
HORSEPOWER
FILTER MODEL
SERIAL NUMBER
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 10
...C-Clip
SPX1515C
SPX1515C
18 6' Cord Set (14/3)
SPX1250WA
SPX1250WA
19 3' Cord Set (12/3) Twist Lock
SPX1550WA1
SPX1550WA1
* To order 2-speed motor, change "1" in suffix of part number (i.e. Motor (for SW1585X20) - 2 HP
---- on
Refer to a "2" (i.e. Replacement Parts
Parts Diagram
PARTS LISTING
Model No. SP1580, SP1580X15,
Ref. Model No.
on Original Equipment
SPX1705AA SPX1500Y2...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 11
HAYWARD® Pool Products Limited Warranty
To original purchasers of defective product, barring unforeseen delays, without charge. Parts that fail or become defective during the warranty period shall be repaired or replaced, at www.haywardpool.com.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
11 11 Proof of the purchase date. In the event proof...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 12
... the product packaging.
USE UOSNELYOHNALYWY AHRADYGWEANURIDNEGREENPLUAICNEEMRENETPPLAARCTES MENT PARTS
1122 Instead, complete warranty registration only for those individual components. PowerFlo LX™ / PowerFlo II™ / EP Pump Series Warranty Card Registration
Register online at www.hayward.com
Please Print Clearly:
Years Pool has been in service
First Name Last Name 1 year...
Hayward PowerFlo LX Above-Ground Pump Series Reviews
We have not received any reviews for Hayward yet.