Owners Manual
Page 2
... machine will fulfill the requirements. WARNING! When this product is also applicable to the operator or other persons. Use only original parts for recycling. Take care of the states, (California emission rules etc.). Do not modify or install non-standard equipment to the... or other reproductive harm. CONFORMITY CERTIFICATES USA requirements Labels are valuable documents. Modifications to cause cancer and birth defects or other parts voids the warranty. The use of sound mind and body and must allow only trained persons who understand these instructions. WARNING!...
... machine will fulfill the requirements. WARNING! When this product is also applicable to the operator or other persons. Use only original parts for recycling. Take care of the states, (California emission rules etc.). Do not modify or install non-standard equipment to the... or other reproductive harm. CONFORMITY CERTIFICATES USA requirements Labels are valuable documents. Modifications to cause cancer and birth defects or other parts voids the warranty. The use of sound mind and body and must allow only trained persons who understand these instructions. WARNING!...
Owners Manual
Page 4
...cause loss of traction and loss of the machine and increase its resale value. Follow the manufacturer's recommendation for weight limits for purchasing a Husqvarna ride-on the towed equipment. Safety requires good judgement, careful use extreme caution when towing. The machine must be potentially dangerous if used for...not tow near ditches, canals, and other tasks when equipped with a tow hitch, use in or on mower. Use only approved repair parts to improve our products require that specifications and design are documented. Unauthorized modifications to avoid jack-knifing.
...cause loss of traction and loss of the machine and increase its resale value. Follow the manufacturer's recommendation for weight limits for purchasing a Husqvarna ride-on the towed equipment. Safety requires good judgement, careful use extreme caution when towing. The machine must be potentially dangerous if used for...not tow near ditches, canals, and other tasks when equipped with a tow hitch, use in or on mower. Use only approved repair parts to improve our products require that specifications and design are documented. Unauthorized modifications to avoid jack-knifing.
Owners Manual
Page 5
... printed plate affixed to the engine compartment. The wheel motors and hydrostatic pumps have the type designation and serial number available when ordering spare parts. INTRODUCTION Good Service Husqvarna's products are : • The machine's type designation (I.D.). • The manufacturer's type number (Model). • The machine's serial number (Serial no.) Please have a barcode...
... printed plate affixed to the engine compartment. The wheel motors and hydrostatic pumps have the type designation and serial number available when ordering spare parts. INTRODUCTION Good Service Husqvarna's products are : • The machine's type designation (I.D.). • The manufacturer's type number (Model). • The machine's serial number (Serial no.) Please have a barcode...
Owners Manual
Page 6
... a potential for other people Used in the operator manual. xx xxxxxxxx xxxx xxxxxx. Used also when there is corrosive, explosive and flammable Do not touch parts Warning! Cold Weather Fuel Warning!
... a potential for other people Used in the operator manual. xx xxxxxxxx xxxx xxxxxx. Used also when there is corrosive, explosive and flammable Do not touch parts Warning! Cold Weather Fuel Warning!
Owners Manual
Page 7
... the safety instruction that you last saw them carefully. Local laws may block your safety. The owner is responsible for traffic when operating near rotating parts or under the influence of injury or accident. • Anyone who operates, maintains, and/or services this machine must first read and follow .... adults, who have been given rides in the past may suddenly appear in the mowing area for another ride and be aware that follow all parts to come to a complete stop the engine before starting. • It is not alert to the presence of the user. Stop machine if ...
... the safety instruction that you last saw them carefully. Local laws may block your safety. The owner is responsible for traffic when operating near rotating parts or under the influence of injury or accident. • Anyone who operates, maintains, and/or services this machine must first read and follow .... adults, who have been given rides in the past may suddenly appear in the mowing area for another ride and be aware that follow all parts to come to a complete stop the engine before starting. • It is not alert to the presence of the user. Stop machine if ...
Owners Manual
Page 8
... gas cap and tighten securely. 8 Do not allow the mower deck to plow leaves or other attachments; they can touch hot exhaust or engine parts and burn. If you cannot back up the slope or if you feel uneasy on it, do not mow it will not have to cool...; Follow the manufacturer's recommendation for burns if touched. Allow engine and exhaust system to loss of riding mower-related injuries. Do not mow in moving parts. • Use ear protectors to avoid damage to roll over accidents, which can hide obstacles. When using the machine. • Never use extreme care...
... gas cap and tighten securely. 8 Do not allow the mower deck to plow leaves or other attachments; they can touch hot exhaust or engine parts and burn. If you cannot back up the slope or if you feel uneasy on it, do not mow it will not have to cool...; Follow the manufacturer's recommendation for burns if touched. Allow engine and exhaust system to loss of riding mower-related injuries. Do not mow in moving parts. • Use ear protectors to avoid damage to roll over accidents, which can hide obstacles. When using the machine. • Never use extreme care...
Owners Manual
Page 9
... the battery. • The machine is removed. • Check grass catcher components and the discharge guard frequently and replace with manufacturer's recommended parts when necessary. • Do not change clothing immediately. • Do not start the engine near open vessel. • Sparking can cause ...drive belt is tested and approved only with water. 9 This can explode and cause serious injury or damage. Only use approved repair parts for the machine. • The mulch blades should only be started until fueling is mounted tightly and no flammable substances are considered...
... the battery. • The machine is removed. • Check grass catcher components and the discharge guard frequently and replace with manufacturer's recommended parts when necessary. • Do not change clothing immediately. • Do not start the engine near open vessel. • Sparking can cause ...drive belt is tested and approved only with water. 9 This can explode and cause serious injury or damage. Only use approved repair parts for the machine. • The mulch blades should only be started until fueling is mounted tightly and no flammable substances are considered...
Owners Manual
Page 19
... S/S button will flash one slow green blink if the code is blinking blue. Ignition System Faults The SmartSwitch Ignition is programmed to warn when any part of two actions will not allow the unit to a rapid green blink. IMPORTANT INFORMATION Either of the safety system is blinking blue. 7. Press and hold...
... S/S button will flash one slow green blink if the code is blinking blue. Ignition System Faults The SmartSwitch Ignition is programmed to warn when any part of two actions will not allow the unit to a rapid green blink. IMPORTANT INFORMATION Either of the safety system is blinking blue. 7. Press and hold...
Owners Manual
Page 25
... At least once each year Maintenance interval in the disengaged position. • Turn the ignition switch OFF. • Make sure the blades and all moving parts have sufficient force to penetrate the skin, causing serious injury. MAINTENANCE MAINTENANCE Check/adjust throttle cable Check the condition of belts, belt pulleys Change the...
... At least once each year Maintenance interval in the disengaged position. • Turn the ignition switch OFF. • Make sure the blades and all moving parts have sufficient force to penetrate the skin, causing serious injury. MAINTENANCE MAINTENANCE Check/adjust throttle cable Check the condition of belts, belt pulleys Change the...
Owners Manual
Page 33
...be in use the mixing ratios specified by the manufacturer of the mower deck to avoid corrosion. 2. Run the engine for worn or damaged parts and tighten any nuts or screws that your machine performs its best the following season. 33 It is evenly distributed and then refit the ...properly. 4. Start the engine and allow it from open flames, sparks, or a pilot light such as in the storage container. Never use genuine Husqvarna spare parts. Use a degreaser and warm water. Touch up at least ten minutes after adding the stabilizer so that the oil is very flammable and can come...
...be in use the mixing ratios specified by the manufacturer of the mower deck to avoid corrosion. 2. Run the engine for worn or damaged parts and tighten any nuts or screws that your machine performs its best the following season. 33 It is evenly distributed and then refit the ...properly. 4. Start the engine and allow it from open flames, sparks, or a pilot light such as in the storage container. Never use genuine Husqvarna spare parts. Use a degreaser and warm water. Touch up at least ten minutes after adding the stabilizer so that the oil is very flammable and can come...
Parts Manual
Page 1
Parts Manual Zero Turn Mower / Z 254i 967324201-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine.
Parts Manual Zero Turn Mower / Z 254i 967324201-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine.
Parts Manual
Page 2
Orangeburg SC. When you need spare parts or support in U.S.A. Stated on the printed plate affixed to the machine with the manufacturing number: Engine Transmission Manufacturing Number The machine's manufacturing number ... • The manufacturer's type number (Model). • The machine's serial number (Serial no.) Please have the type designation and serial number available when ordering spare parts. ©2015 All rights reserved. Printed in service questions, warranty issues, etc., please consult the following professional: This manual belongs to the engine compartment.
Orangeburg SC. When you need spare parts or support in U.S.A. Stated on the printed plate affixed to the machine with the manufacturing number: Engine Transmission Manufacturing Number The machine's manufacturing number ... • The manufacturer's type number (Model). • The machine's serial number (Serial no.) Please have the type designation and serial number available when ordering spare parts. ©2015 All rights reserved. Printed in service questions, warranty issues, etc., please consult the following professional: This manual belongs to the engine compartment.
Parts Manual
Page 5
... 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 Z 254i, 967324201-00 Part No. 585 03 98-02 510 17 75-03 510 17 74-03 584 99 10-02 522 84 29-02 585 52 24-01...
... 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 Z 254i, 967324201-00 Part No. 585 03 98-02 510 17 75-03 510 17 74-03 584 99 10-02 522 84 29-02 585 52 24-01...
Parts Manual
Page 7
.... 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 Z 254i, 967324201-00 Part No. Qty Description 587 48 07-02 1 Plate, Engine Blk 587 24 16-01 1 Clutch 581 88 11-01 1 Tube, Exhaust Right 581 88 10... 819 12 14-14 2 Washer 5/16 Std Flat 539 11 26-70 1 Washer, Heavy NOT SHOWN 1 Engine, Briggs & Stratton 44S877 24 Hp For Engine Replacement Parts, See a B&S Dealer 7
.... 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 Z 254i, 967324201-00 Part No. Qty Description 587 48 07-02 1 Plate, Engine Blk 587 24 16-01 1 Clutch 581 88 11-01 1 Tube, Exhaust Right 581 88 10... 819 12 14-14 2 Washer 5/16 Std Flat 539 11 26-70 1 Washer, Heavy NOT SHOWN 1 Engine, Briggs & Stratton 44S877 24 Hp For Engine Replacement Parts, See a B&S Dealer 7
Parts Manual
Page 9
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 Part No. 581 82 67-01 525 39 29-01 585 12 47-05 539 13 15-18 576 14 03-01 587 60 17-02 ...
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 Part No. 581 82 67-01 525 39 29-01 585 12 47-05 539 13 15-18 576 14 03-01 587 60 17-02 ...
Parts Manual
Page 11
... 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 Z 254i, 967324201-00 Part No. Qty Description 585 52 28-01 1 Assembly, Fender, Right Gry 586 62 12 01 1 Assembly, Fender, Left Gry 578 18 06-02 1 Assembly, Fuel...
... 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 Z 254i, 967324201-00 Part No. Qty Description 585 52 28-01 1 Assembly, Fender, Right Gry 586 62 12 01 1 Assembly, Fender, Left Gry 578 18 06-02 1 Assembly, Fuel...
Parts Manual
Page 17
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Part No. 579 75 34-01 576 58 86-02 576 58 88-01 539 11 56-38 539 10 33-00 539 11 26-60 ...
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Part No. 579 75 34-01 576 58 86-02 576 58 88-01 539 11 56-38 539 10 33-00 539 11 26-60 ...
Parts Manual
Page 19
... 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 Part No. 583 90 93-01 539 11 45-57 532 18 72-56 532 18 72-97 532 18 81-87 587 12 54-01...
... 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 Part No. 583 90 93-01 539 11 45-57 532 18 72-56 532 18 72-97 532 18 81-87 587 12 54-01...
Parts Manual
Page 21
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Part No. 532 43 98-22 532 19 69-77 586 22 08-02 586 22 12-02 577 26 05-03 580 30 82-02 ...
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Part No. 532 43 98-22 532 19 69-77 586 22 08-02 586 22 12-02 577 26 05-03 580 30 82-02 ...
Parts Manual
Page 23
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part No. 587 59 56-01 587 59 55-01 587 86 54-01 539 10 57-45 532 42 86-77 539 10 83-85 ... 1 Decal, Do Not Tow 1 Decal, Exit Mower 1 Decal, Service 1 Decal, Safety Warnings 1 Decal, Responsibility 1 Decal, Start 1 Decal, Deflector 1 Decal, Blade Danger 1 Decal, Belt Routing 2 Decal, Husqvarna 1 Pad, Abrasive Z 254i, 967324201-00 23
Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part No. 587 59 56-01 587 59 55-01 587 86 54-01 539 10 57-45 532 42 86-77 539 10 83-85 ... 1 Decal, Do Not Tow 1 Decal, Exit Mower 1 Decal, Service 1 Decal, Safety Warnings 1 Decal, Responsibility 1 Decal, Start 1 Decal, Deflector 1 Decal, Blade Danger 1 Decal, Belt Routing 2 Decal, Husqvarna 1 Pad, Abrasive Z 254i, 967324201-00 23