Pentair WaterFall Specialty Pumps Support and Manuals
Get Help and Manuals for this Pentair item
View All Support Options Below
Free Pentair WaterFall Specialty Pumps manuals!
Problems with Pentair WaterFall Specialty Pumps?
Ask a Question
Free Pentair WaterFall Specialty Pumps manuals!
Problems with Pentair WaterFall Specialty Pumps?
Ask a Question
Popular Pentair WaterFall Specialty Pumps Manual Pages
WaterFall Owners Manual English Spanish French - Page 1
ENGLISH
ESPAÑOL FRANÇAIS
WATERFALL™
SPECIALTY PUMP
INSTALLATION AND USER'S GUIDE
IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS
SAVE THESE INSTRUCTIONS
WaterFall Owners Manual English Spanish French - Page 2
... be followed, include the following signal words and be used with the National Electrical Code and all safety instructions in this manual and on your system or in accordance with hot tubs and spas if so marked.
WATERFALL™ Specialty Pump Installation and User's Guide
General Warnings
• Never open pool (particularly a child wading pool) or spa outlet...
WaterFall Owners Manual English Spanish French - Page 3
... all national, state, and local codes.
• Install to a specific model. Be sure that meet ASME/ANSI A112.19.8a Suction Fittings for all equipment and start -up pump. Stand clear of the filter and pump during service.
Commercial pools or spas constructed on or starting the system, fully open the manual air relief valve and place all...
WaterFall Owners Manual English Spanish French - Page 4
...-Up
5
Maintenance 6
Cleaning the Strainer Basket
6
Winterizing
7
Motor Care
7
Servicing 8
Pump Disassembly
8
Shaft Seal Replacement
9
Pump Reassembly
10
Restart Instructions 11
Priming the Pump
11
Troubleshooting 12
Replacement Parts 13
WATERFALL™ Specialty Pump Installation and User's Guide to 4:30 P.M. to 4:30 P.M. to 7:30 P.M. - Sanford, North Carolina...
WaterFall Owners Manual English Spanish French - Page 6
... Flow
Under 2'
Negligible reduction in flow if plumbed according to 50% or less of Pump and Piping
Many installations require that the motor can be removed easily for maintenance and repair. Above 15'
Not recommended. WATERFALL™ Specialty Pump Installation and User's Guide Canadian installations require a minimum of 9.8 feet (3 meters) from the inside wall of "high flow plumbing...
WaterFall Owners Manual English Spanish French - Page 7
... be smaller than five (5) times the suction line pipe diameter. Maximum operating pressure of the pump. 5. WATERFALL™ Specialty Pump Installation and User's Guide DO NOT USE PETROLEUM BASED PRODUCTS.
2. DO
NOT OVERTIGHTEN. 4. Note: DO NOT install 90° elbows directly into the pump inlet and outlet. 7. ENGLISH
ESPAÑOL FRANÇAIS
3
Piping, Fitting and Valve...
WaterFall Owners Manual English Spanish French - Page 8
...) and all other applicable national or local codes and ordinances. E 10/23/19
WATERFALL™ Specialty Pump Installation and User's Guide
Run a wire from the external bonding screw or lug to the bonding structure.
2. Use the correct wire size and type specified by a licensed or certified electrician or a qualified service professional in death or serious injury to...
WaterFall Owners Manual English Spanish French - Page 9
...'s manual.
2. Ensure that all air bleeders on entire hydraulic system prior to "Troubleshooting" on the suction lift and the distance and size of suction piping. On flooded suction pumps with...be replaced. If the pump is now ready to lubricate the lid o-ring with water up skimmer opening , the pump will depend
on page 12. WATERFALL™ Specialty Pump Installation and User's Guide
WaterFall Owners Manual English Spanish French - Page 10
... property damage. Turn the strainer lid in these instructions. Replace the basket.
7. When any part of the circulating system (e.g., Lock Ring, Pump, Filter, Valves, etc.) is cracked.
6. ... pump has been operating without water in the pump should be kept clean and well lubricated.
9. Close the manual air relief valve.
WATERFALL™ Specialty Pump Installation and User's Guide Pumps ...
WaterFall Owners Manual English Spanish French - Page 11
.... WATERFALL™ Specialty Pump Installation and User's Guide If freezing conditions are responsible for the pump at...installed. Store
the plugs in the pump basket. 3. The motor may void the motor warranty. Any enclosure must be covered during a storm, winter storage, etc., but never when operating, or expecting operation. • When replacing the motor, be certain that the motor support...
WaterFall Owners Manual English Spanish French - Page 12
...National Electrical Code and all servicing instructions before servicing the pump.
Pumps operated in a clockwise direction. 8. seal will leak if faces are needed. 3. Turn off the pump circuit breaker ...assembly of the motor.
WATERFALL™ Specialty Pump Installation and User's Guide DO NOT open -end wrench • Rubber mallet
To remove and repair the motor sub-assembly ...
WaterFall Owners Manual English Spanish French - Page 13
... Seal
Figure 4
WATERFALL™ Specialty Pump Installation and User's Guide
Note: When placing the rotating seal to the motor via the four (4) bolts that contacts the white ceramic seal must be changed without disconnecting piping by twisting the impeller counter-clockwise. 10. See Figure 4. The Waterfall™ Specialty Pump requires little or no service other than reasonable...
WaterFall Owners Manual English Spanish French - Page 16
.... Replace o-ring. Adjust pool water level.
Clean basket. Find and open all necessary valves. Pump is locked by electrician. Motor terminal connections are incorrect.
2. Wiring to air flow. Notify Power Company.
b. Read the entire Installation & User's Guide before attempting service or repair. Remedy
Add water to resolve possible Waterfall™ Specialty Pump problems...
WaterFall Owners Manual English Spanish French - Page 17
...
(Item #10) (Item #16)
355301 355301 355300
-
355468 355468 355468 355302 355302
WATERFALL™ Specialty Pump Installation and User's Guide 13
REPLACEMENT PARTS
ENGLISH
ESPAÑOL FRANÇAIS
10
2
1
4
65
8
12
17
18
13...355329 See Strainer Table 354629 175025 355305 192115 357161 355330 355300 354265
Motor Table
Model
AFP-75, AF-75
AFP-120, AF-120 AFP-150
Motor (Item #1)...
WaterFall Specialty Pump - Page 1
..., strainer pot AFP-180
Bushing, impeller nose AF-180, AFP-150 & 180
Wrench, 8-1/2 in . Replacement baskets on page 635. WATERFALL SPECIALTY PUMP REPLACEMENT PARTS
AFP-180 Only
Item
1
1 2 3 3 4 5 5 5 6 6 6 7 8 9 10 11 11B
12
12 13 14 15 16 17 20
Part No. hd., 4 req.
Replacement parts pricing on page 136. dia. Product on pages 178-179. drain
175025
Knob (fits...
Pentair WaterFall Specialty Pumps Reviews
We have not received any reviews for Pentair yet.