Poulan PP1053ES Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PP1053ES manuals!
Problems with Poulan PP1053ES?
Ask a Question
Free Poulan PP1053ES manuals!
Problems with Poulan PP1053ES?
Ask a Question
Popular Poulan PP1053ES Manual Pages
User Manual - Page 1
Always Wear Eye Protection During Operation
421918 09.25.08 SR
Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
PP1053ES
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in U.S.A.
User Manual - Page 2
...(g) Replace gasoline ...of trouble. ...specifically recommended by the manufacturer for hidden hazards or traffic.
(c) Fill fuel tank outdoors with a portable container, rather than from the truck or trailer and refuel it cannot contact plug in moving parts...instruction.
3. After striking a foreign object, stop the unit and disengage the controls quickly.
2.
Look for any damage, and repair...
User Manual - Page 3
... for an extended period.
4. The instructions will enable you cannot easily remedy, please contact your nearest authorized service center. TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 14-15
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 18
ASSEMBLY / PRE-OPERATION 5-7
TROUBLESHOOTING 19
OPERATION 8-13
REPAIR PARTS 20-38
MAINTENANCE...
User Manual - Page 12
...parts to proper height for current surface conditions. See Storage Instructions... for a few seconds, remove and read oil level.
Use a middle position if the surface to the edge of the housing, it run until "FULL" mark on your parts... providing additional service before storage...problems, the fuel system should be emptied before requiring replacement...filler neck. Replace a damaged ...
User Manual - Page 14
...manual should replace the spark plug and check belts for loose fasteners.
3. BEFORE EACH USE
1. Auger grease fittings
Engine oil
14 All adjustments in this unit. NOTE: Use only Original Equipment Manufacturer (OEM) parts... to service this manual. Check for wear.
Check engine oil level.
2. To receive full value from the warranty, operator must maintain snow thrower as instructed in...
User Manual - Page 15
...Service and Adjustments section of gasoline, oil, etc. Refill engine with API service classification SG-SL. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual...plug type and gap setting are of your ...replaced by original equipment manufacturer (OEM) belts available from your expected operating temperature. Be careful not to allow dirt to your local parts...
User Manual - Page 18
... condensation to form and will cause problems.
FUEL SYSTEM
• If possible, store your local parts dealer. KLIK PIN (INSTALL IN OUTER HOLE OF AXLE ONLY)...Service and Adjustments section of this manual).
3.
If your engine does not operate properly due to suspected carburetor problems, take your snow thrower to make any enclosure.
SNOW THROWER
When snow thrower is factory set...
User Manual - Page 19
... debris or foreign object from augers / impeller.
19 TROUBLESHOOTING
See appropriate section in manual unless directed to FAST position. 5. PROBLEM
CAUSE
CORRECTION
Does not start
1. Stale fuel. 11. Fill fuel tank. 4. Move throttle to a qualified service center. Connect wire to pull
1.
Throwing too much snow. 3. Clean or replace muffler. Carburetor is flooded. 8. Clean fuel line...
User Manual - Page 20
REPAIR PARTS
SNOW THROWER - Failure to do so could be hazardous, damage your snow thrower and void your warranty.
20 MODEL PP1053ES (96192001804)
AUGER HOUSING / IMPELLER ASSEMBLY
5
11 6
15 14 13
4
12
16
11
12 3 11
1 9
10 2
11 7...)
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
User Manual - Page 21
...only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL PP1053ES (96192001804)
AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
PART NO.
175321X479 196710 188909 ...U.S. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
21 REPAIR PARTS
SNOW THROWER -
User Manual - Page 24
....002-B
NOTE: 1. ITEMS 14 AND 15 ARE SERVICE PART NUMBERS TO ALLOW PURCHASE OF INDIVIDUAL ITEMS IF NECESSARY. REPAIR PARTS
SNOW THROWER - NOTE: All component dimensions given in U.S. ALL ITEMS INDICATED WITH AN * ARE PROVIDED IN THE BAG OF ITEMS SHIPPED LOOSE WITH PRODUCT. 2. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
User Manual - Page 25
...REPAIR PARTS
SNOW THROWER - ITEMS INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY.
2
1
KEY NO.
1 2
PART NO.
188303 74041024
01.15.005-A
DESCRIPTION STEER CABLE SCREW 10−24 X 1.50
NOTE: All component dimensions given in U.S. MODEL PP1053ES (96192001804)
CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *6
*6
KEY NO.
1 2 *3 *4 *5 *6
PART... (O.E.M.) replacement parts.
User Manual - Page 29
...
5 6
7
4
41
01.10.007-B
5 KEY PART NO. NO.
1
182906
2
178668
3
180927
4
184471
5
175262
6
178770
7
183784
DESCRIPTION
CONSOLE PANEL HEADLIGHT BEZEL FLOOD HEADLIGHT SHOULDER SCREW 10−24 X .625 SCREW 10−24 X 1.25 WIRE HARNESS BULB
NOTE: All component dimensions given in U.S. MODEL PP1053ES (96192001804)
KEY PART NO. REPAIR PARTS HANDLES
1
SNOW THROWER - NO.
User Manual - Page 38
... DECAL, POULAN DECAL, INSTRUCTION DECAL, SPEED CONTROL DECAL, REMOTE DEFLECTOR CONTROL DECAL, LH TRIGGER DECAL, RH TRIGGER OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL PP1053ES (96192001804)
1
2
4
9 12
6
1
3
5
10 11
KEY PART NO...
User Manual - Page 40
... within the meaning of that this Warranty, please contact:
Poulan Pro Customer Service Department 1030 Stevens Creek Road Augusta, GA 30907 USA
In Canada contact:
Poulan Pro, Customer Service Department 5855 Terry Fox Way Mississauga, Ontario L5V 3E4
giving the complete mfg. Transportation charges for parts or labor incurred in replacing parts, any product which have a claim under this...
Poulan PP1053ES Reviews
We have not received any reviews for Poulan yet.