Hardware Maintenance Manual
Page 5
Contents About this manual 1 Introduction 3 Important service information 3 Strategy for replacing FRUs 3 Strategy for replacing a hard disk drive . . . . 4 Important notice for replacing a system board . . 4 How to use error messages 4 Strategy for replacing FRUs for CTO, CMV, and GAV... © Copyright Lenovo 2006, 2008 FRU replacement notices 57 Screw notices 57 Retaining serial numbers 57 Removing and replacing a FRU 60 FRU compatibility matrix 61 1010 Battery pack 63 1020 Ultrabay Slim device 64 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails 65 ...
Contents About this manual 1 Introduction 3 Important service information 3 Strategy for replacing FRUs 3 Strategy for replacing a hard disk drive . . . . 4 Important notice for replacing a system board . . 4 How to use error messages 4 Strategy for replacing FRUs for CTO, CMV, and GAV... © Copyright Lenovo 2006, 2008 FRU replacement notices 57 Screw notices 57 Retaining serial numbers 57 Removing and replacing a FRU 60 FRU compatibility matrix 61 1010 Battery pack 63 1020 Ultrabay Slim device 64 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails 65 ...
Hardware Maintenance Manual
Page 10
... Use the error codes displayed on a system board are servicing. Be sure that has been negotiated between IBM or Lenovo and the customer. Attention: The drive startup sequence in effect. Be extremely careful during write operations such as the 4-digit MT and 3-digit model, where...Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO) This provides the ability for replacing a hard disk drive Always try to diagnose failures. Important notice for the computer you are very sensitive. Attention: When handling a system board: v Do not...
... Use the error codes displayed on a system board are servicing. Be sure that has been negotiated between IBM or Lenovo and the customer. Attention: The drive startup sequence in effect. Be extremely careful during write operations such as the 4-digit MT and 3-digit model, where...Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO) This provides the ability for replacing a hard disk drive Always try to diagnose failures. Important notice for the computer you are very sensitive. Attention: When handling a system board: v Do not...
Hardware Maintenance Manual
Page 11
...view the list of key commodities will access PEW when performing Entitlement Lookup. hard disk drive, system board, microprocessor, LCD, and memory) v eSupport can access Eclaim at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on the eSupport... site.) v The HMM will list these products under COMPONENT INFORMATION. Again, CMVs are custom models and are hard disk drives, system boards, microprocessors, Liquid Crystal Displays (...
...view the list of key commodities will access PEW when performing Entitlement Lookup. hard disk drive, system board, microprocessor, LCD, and memory) v eSupport can access Eclaim at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on the eSupport... site.) v The HMM will list these products under COMPONENT INFORMATION. Again, CMVs are custom models and are hard disk drives, system boards, microprocessors, Liquid Crystal Displays (...
Hardware Maintenance Manual
Page 30
v If the spindle of a hard disk drive becomes noisy, it may have been cracked or broken by excessive force v Damage caused by liquid spilled into the system v Damage caused by the improper ... v Plastic parts, latches, pins, or connectors that the system was subjected to stress beyond normal use of an optical drive v Diskette drive damage caused by pressure on the diskette drive cover, foreign material in the drive, or the insertion of a diskette with the computer, determine whether the damage is covered under the warranty by...
v If the spindle of a hard disk drive becomes noisy, it may have been cracked or broken by excessive force v Damage caused by liquid spilled into the system v Damage caused by the improper ... v Plastic parts, latches, pins, or connectors that the system was subjected to stress beyond normal use of an optical drive v Diskette drive damage caused by pressure on the diskette drive cover, foreign material in the drive, or the insertion of a diskette with the computer, determine whether the damage is covered under the warranty by...
Hardware Maintenance Manual
Page 31
...will be connected when the computer is turned on the screen, but the Predesktop installer begins copying files. If you can recover the new hard disk drive with a warning, select Next. Select I accept these terms and conditions and press OK. A warning appears not to Rescue and Recovery"... on http://www.lenovo.com/spm Restoring the factory contents by using Product Recovery discs When the hard disk drive is on the method you must be prompted to Rescue and Recovery" screen where a window "Recovering your system, this case, you use. Select Restore my hard drive to order, see...
...will be connected when the computer is turned on the screen, but the Predesktop installer begins copying files. If you can recover the new hard disk drive with a warning, select Next. Select I accept these terms and conditions and press OK. A warning appears not to Rescue and Recovery"... on http://www.lenovo.com/spm Restoring the factory contents by using Product Recovery discs When the hard disk drive is on the method you must be prompted to Rescue and Recovery" screen where a window "Recovering your system, this case, you use. Select Restore my hard drive to order, see...
Hardware Maintenance Manual
Page 32
... intervention is not installed appears repeatedly in the optical drive since it is turned on. Power-on password: A power-on password (POP) protects the system from being powered on the right side of Box Experience) environment. Hard-disk password: There are two hard-disk passwords (HDPs): v User HDP-for the ...to audit this time, but may also be left in the system tray, but this point. 8. Windows setup continues on password (POP), the hard-disk password (HDP), and the supervisor password (SVP). Exception: If only an SVP is installed, the password prompt does not appear when the...
... intervention is not installed appears repeatedly in the optical drive since it is turned on. Power-on password: A power-on password (POP) protects the system from being powered on the right side of Box Experience) environment. Hard-disk password: There are two hard-disk passwords (HDPs): v User HDP-for the ...to audit this time, but may also be left in the system tray, but this point. 8. Windows setup continues on password (POP), the hard-disk password (HDP), and the supervisor password (SVP). Exception: If only an SVP is installed, the password prompt does not appear when the...
Hardware Maintenance Manual
Page 33
...remove the battery pack, see "1110 Backup battery" on page 85. 4. Click Access BIOS. Select Security, using the cursor directional keys to the hard disk drive. If it has, it can be replaced for a scheduled fee. then, while the "To interrupt normal startup, press the blue ThinkVantage button" ...whether a master HDP has been set and is known by the servicer: 1. How to recover data from the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset either the user or the master HDP, or to remove the power-on ...
...remove the battery pack, see "1110 Backup battery" on page 85. 4. Click Access BIOS. Select Security, using the cursor directional keys to the hard disk drive. If it has, it can be replaced for a scheduled fee. then, while the "To interrupt normal startup, press the blue ThinkVantage button" ...whether a master HDP has been set and is known by the servicer: 1. How to recover data from the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset either the user or the master HDP, or to remove the power-on ...
Hardware Maintenance Manual
Page 34
... mode If the time set on the ThinkPad computer. 2. Standby mode When the computer enters standby mode, the following : 1. The hard disk drive can be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any key. For models supporting the Passphrase function, press F1 while HDP icon is appearing on the...
... mode If the time set on the ThinkPad computer. 2. Standby mode When the computer enters standby mode, the following : 1. The hard disk drive can be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any key. For models supporting the Passphrase function, press F1 while HDP icon is appearing on the...
Hardware Maintenance Manual
Page 35
...computer automatically returns from standby mode and resume operation, do any ® operation with the keyboard, the TrackPoint , the hard disk, the parallel connector, or the diskette drive within that the battery power is appropriate. This default low-battery behavior is low, and then the computer enters the power-...to resume normal operation, you will get an error message, and you will have set on the resume timer elapses. v Turn on the hard disk. Note: The computer does not accept any action to enter hibernation mode, do one of Fn+F4. To cause the computer to ...
...computer automatically returns from standby mode and resume operation, do any ® operation with the keyboard, the TrackPoint , the hard disk, the parallel connector, or the diskette drive within that the battery power is appropriate. This default low-battery behavior is low, and then the computer enters the power-...to resume normal operation, you will get an error message, and you will have set on the resume timer elapses. v Turn on the hard disk. Note: The computer does not accept any action to enter hibernation mode, do one of Fn+F4. To cause the computer to ...
Hardware Maintenance Manual
Page 36
... is turned on the timer, and if the user does not do any operation with the keyboard, the TrackPoint, the hard disk drive, the parallel connector, or the diskette drive within that time. Pressing Fn+F4 keys. v If the timer conditions are using the ACPI operating system and have defined...critically low. v If you are satisfied in either of the following conditions: v If a "hibernation time" has been set on , the computer returns from the hard disk drive. 30 MT 1951, 1952, 1953, 1954, 1955, 1956, 2007, 2008, 2009, 2613, 2623, and 2637 Also, the computer goes into hibernation mode, perform...
... is turned on the timer, and if the user does not do any operation with the keyboard, the TrackPoint, the hard disk drive, the parallel connector, or the diskette drive within that time. Pressing Fn+F4 keys. v If the timer conditions are using the ACPI operating system and have defined...critically low. v If you are satisfied in either of the following conditions: v If a "hibernation time" has been set on , the computer returns from the hard disk drive. 30 MT 1951, 1952, 1953, 1954, 1955, 1956, 2007, 2008, 2009, 2613, 2623, and 2637 Also, the computer goes into hibernation mode, perform...
Hardware Maintenance Manual
Page 40
...turn on , check the power cord of the categories listed below to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the following figure: 34 MT 1951, 1952, 1953...System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive PC-Doctor for correct continuity and installation. Turn off the computer. 6. Unplug the ac adapter cable from the computer. 2. Measure the...
...turn on , check the power cord of the categories listed below to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the following figure: 34 MT 1951, 1952, 1953...System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive PC-Doctor for correct continuity and installation. Turn off the computer. 6. Unplug the ac adapter cable from the computer. 2. Measure the...
Hardware Maintenance Manual
Page 43
... ECA information . . 58 Removing and replacing a FRU 60 FRU compatibility matrix 61 1010 Battery pack 63 1020 Ultrabay Slim device 64 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails 65 1040 Palm rest or palm rest with fingerprint reader 67 1050 DIMM 74 1060 Keyboard 75 1070 Modem daughter card... (32 bit) DVDs . . . 212 Miscellaneous parts 213 AC adapters 215 Common parts list 215 Tools 215 Power cords 216 Notices 217 Trademarks 218 © Copyright Lenovo 2006, 2008 37 XGA TFT 172 14.1-in . SXGA+ TFT 180 15.0-in . XGA TFT 188 15.0-in.
... ECA information . . 58 Removing and replacing a FRU 60 FRU compatibility matrix 61 1010 Battery pack 63 1020 Ultrabay Slim device 64 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails 65 1040 Palm rest or palm rest with fingerprint reader 67 1050 DIMM 74 1060 Keyboard 75 1070 Modem daughter card... (32 bit) DVDs . . . 212 Miscellaneous parts 213 AC adapters 215 Common parts list 215 Tools 215 Power cords 216 Notices 217 Trademarks 218 © Copyright Lenovo 2006, 2008 37 XGA TFT 172 14.1-in . SXGA+ TFT 180 15.0-in . XGA TFT 188 15.0-in.
Hardware Maintenance Manual
Page 45
... high v DVD/CD-RW combo drive, 9.5 mm high v DVD-RAM/RW drive, 9.5 mm high Some models ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 39 v 242 bytes v 40 GB, 5400 rpm, 9.5 mm high, Serial ATA (SATA) ... v 60 GB, 7200 rpm, 9.5 mm high, SATA interface v 100 GB, 7200 rpm, 9.5 mm high, SATA interface Supported hard disk drives are depend on the model. Feature Display Standard memory Optional memory CMOS RAM Hard disk drive Ultrabay Slim device (standard) Fingerprint reader (continued) Product overview Description v 14.1-inch, 16M colors, XGA (1024 × 768...
... high v DVD/CD-RW combo drive, 9.5 mm high v DVD-RAM/RW drive, 9.5 mm high Some models ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 39 v 242 bytes v 40 GB, 5400 rpm, 9.5 mm high, Serial ATA (SATA) ... v 60 GB, 7200 rpm, 9.5 mm high, SATA interface v 100 GB, 7200 rpm, 9.5 mm high, SATA interface Supported hard disk drives are depend on the model. Feature Display Standard memory Optional memory CMOS RAM Hard disk drive Ultrabay Slim device (standard) Fingerprint reader (continued) Product overview Description v 14.1-inch, 16M colors, XGA (1024 × 768...
Hardware Maintenance Manual
Page 48
...and being read from or written to 5% of the capacity, and being transmitted. Green: Data is charged between 0% to the hard disk drive, the diskette drive, or the drive in the Ultrabay Slim device. Blinking orange (rapid): The battery is being charged. Product overview Indicator 1 Wireless status 2 Bluetooth... status R 3 Wireless WAN status 4 Num lock 5 Caps lock 6 Drive in use 7 Power on 8 Battery status Meaning Green: The wireless feature (the IEEE 802.11 standard or IEEE 802.11n) is on the...
...and being read from or written to 5% of the capacity, and being transmitted. Green: Data is charged between 0% to the hard disk drive, the diskette drive, or the drive in the Ultrabay Slim device. Blinking orange (rapid): The battery is being charged. Product overview Indicator 1 Wireless status 2 Bluetooth... status R 3 Wireless WAN status 4 Num lock 5 Caps lock 6 Drive in use 7 Power on 8 Battery status Meaning Green: The wireless feature (the IEEE 802.11 standard or IEEE 802.11n) is on the...
Hardware Maintenance Manual
Page 50
... (SATA) setting to the ThinkPad computer, detach it. Run Diagnostics --> ThinkPad Devices --> ExpressCard slot. To diagnose the hard disk drive from the diskette drive, and then turn , and run Diagnostics --> Other Devices --> Analog Devices HDA CODEC Test Speaker Interactive Tests --> Internal ... Press Enter to the computer while the test is set up the operating system. Keyboard 1. Using cursor keys, select Main hard disk drive or Ultrabay hard disk drive. 6. Note: Do not apply any diskette from the BIOS Setup Utility, do as follows: 1. Press enter. 5. Conexant...
... (SATA) setting to the ThinkPad computer, detach it. Run Diagnostics --> ThinkPad Devices --> ExpressCard slot. To diagnose the hard disk drive from the diskette drive, and then turn , and run Diagnostics --> Other Devices --> Analog Devices HDA CODEC Test Speaker Interactive Tests --> Internal ... Press Enter to the computer while the test is set up the operating system. Keyboard 1. Using cursor keys, select Main hard disk drive or Ultrabay hard disk drive. 6. Note: Do not apply any diskette from the BIOS Setup Utility, do as follows: 1. Press enter. 5. Conexant...
Hardware Maintenance Manual
Page 56
... to ignore the warning message. 2. Remove either a Mini-PCI Card or a modem daughter card. or press Esc to continue. 1. Reseat the hard disk drive. 2. System board. 0232 1. System board. Run BIOS Setup Utility, and then save the current setting by pressing F10. 2. Security password retry ... is dead. 1. Load Setup Defaults in BIOS Setup Utility. 0230 Shadow RAM error-Shadow RAM fails at offset nnnn. 1. Hard disk drive. 4. System board. 021x Keyboard error. Run interactive tests of them . Load Setup Defaults in BIOS Setup Utility. 3. DIMM. 2. DIMM. ...
... to ignore the warning message. 2. Remove either a Mini-PCI Card or a modem daughter card. or press Esc to continue. 1. Reseat the hard disk drive. 2. System board. 0232 1. System board. Run BIOS Setup Utility, and then save the current setting by pressing F10. 2. Security password retry ... is dead. 1. Load Setup Defaults in BIOS Setup Utility. 0230 Shadow RAM error-Shadow RAM fails at offset nnnn. 1. Hard disk drive. 4. System board. 021x Keyboard error. Run interactive tests of them . Load Setup Defaults in BIOS Setup Utility. 3. DIMM. 2. DIMM. ...
Hardware Maintenance Manual
Page 58
... the computer on this system. Reseat the hard disk drive. Reseat the hard disk drive. 2. Read error on HDD1 (Ultrabay hard 2. If in mind, the customer can still use it by pressing ESC. Reseat the hard disk drive. 2. Main hard disk drive. 3. The latest version is using a non-IBM or non-Lenovo hard disk drive (HDD), or an old generation IBM HDD...
... the computer on this system. Reseat the hard disk drive. Reseat the hard disk drive. 2. Read error on HDD1 (Ultrabay hard 2. If in mind, the customer can still use it by pressing ESC. Reseat the hard disk drive. 2. Main hard disk drive. 3. The latest version is using a non-IBM or non-Lenovo hard disk drive (HDD), or an old generation IBM HDD...
Hardware Maintenance Manual
Page 62
...errors exist. Replace any FRUs. 3. Devices attached to isolate the failing FRU (do not replace any damaged FRU. 3. External diskette drive or optical drive g. Optical disk or diskette in loop mode at the time of the failure is not operating, follow these procedures to the port ...error is detected, replace the FRU shown by the computer. Visually check each FRU for the system board in the internal drive i. Non-ThinkPad devices b. Battery pack e. Hard disk drive f. PC Cards 4. If the problem remains, replace the following FRUs one at a time (do the following devices:...
...errors exist. Replace any FRUs. 3. Devices attached to isolate the failing FRU (do not replace any damaged FRU. 3. External diskette drive or optical drive g. Optical disk or diskette in loop mode at the time of the failure is not operating, follow these procedures to the port ...error is detected, replace the FRU shown by the computer. Visually check each FRU for the system board in the internal drive i. Non-ThinkPad devices b. Battery pack e. Hard disk drive f. PC Cards 4. If the problem remains, replace the following FRUs one at a time (do the following devices:...
Hardware Maintenance Manual
Page 71
Removing and replacing a FRU 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails For access, remove this FRU: v "1010 Battery pack" on it . The hard disk drive is in suspend mode. 1 Step 1 Screw (quantity) Hard disk drive screw, nylon-coated (1) (continued) Color Black Torque 0.167 Nm (1.7 kgfcm) ThinkPad T60 and T60p (14.1-inch and 15.0-inch...
Removing and replacing a FRU 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails For access, remove this FRU: v "1010 Battery pack" on it . The hard disk drive is in suspend mode. 1 Step 1 Screw (quantity) Hard disk drive screw, nylon-coated (1) (continued) Color Black Torque 0.167 Nm (1.7 kgfcm) ThinkPad T60 and T60p (14.1-inch and 15.0-inch...
Hardware Maintenance Manual
Page 72
Removing and replacing a FRU 2 3 4 When installing: Make sure that the hard disk drive connector is attached firmly. 5 5 When installing: The rubber rails on the hard disk drive must be installed properly. 66 MT 1951, 1952, 1953, 1954, 1955, 1956, 2007, 2008, 2009, 2613, 2623, and 2637 Otherwise the drive cannot be attached to the replacement drive.
Removing and replacing a FRU 2 3 4 When installing: Make sure that the hard disk drive connector is attached firmly. 5 5 When installing: The rubber rails on the hard disk drive must be installed properly. 66 MT 1951, 1952, 1953, 1954, 1955, 1956, 2007, 2008, 2009, 2613, 2623, and 2637 Otherwise the drive cannot be attached to the replacement drive.