E-Z-GO Express L4 - Electric Support Question
E-Z-GO Express L4 - Electric Support Question
Find answers below for this question about E-Z-GO Express L4 - Electric.Need a E-Z-GO Express L4 - Electric manual? We have 1 online manual for this item!
Question posted by mfouquet on August 9th, 2014
Loose Bat Connection, Arced Replaced Cable Ends Now Will Only Go In Reverse....
1999 36 V Ezgo ... Dead Pedal .... Hit And Miss... Then Found Loose Bat Connection. Corrosion To Battery Posts And Nuts And The Hold Down Bolts. Tightened The Post Connection Then Went Dead. I Have Cleaned The Posts And Cables I Have Power Now But Only In Reverse No Forward. Wondering If I Have A Bad Forward And Reverse Switch. Thanks For The Help. Am Concerned About The Severe Corrosion Damage To The Metal Parts In Close Proximity To The Batteries...
Current Answers
Related E-Z-GO Express L4 - Electric Manual Pages
Owner Manual - Page 4
Refer to maintain a full charge on the proper maintenance and care of the batteries.
The battery charger may be left connected to the vehicle to the battery manual for
instructions on the batteries, provided the charger is plugged into an active electrical source.
erwise indicated. The use of non-Original Equipment Manufacturer (OEM) approved parts may void...
Owner Manual - Page 9
... result in minor or moderate injury.
SAFETY
1
For any damaged or missing labels. Always replace any questions on level ground. Catastrophic damage to the drivetrain components due ...CAUTIONS, WARNINGS, and DANGERS;
Use extra caution when towing the vehicle. WARNING: Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to become thoroughly...
Owner Manual - Page 10
... chance of personal injury or property damage, the following must be carefully observed:
Certain replacement parts can be used for the U.S.
Information on a limited basis and in FMVSS ...manual to all Notices, Cautions, Warnings, and Dangers. No warning can be operated in connection with local ordinances.
1- 4 Pay particular attention to become thoroughly familiar with this SAFETY ...
Owner Manual - Page 11
...; use extreme caution when driving over loose terrain • use extreme caution in areas where pedestrians are present
MAINTENANCE
ALWAYS:
• replace damaged or missing warning, caution or information labels •... seating capacity. SAFETY
Read all electrical accessories are grounded directly to the battery (-) post.
Operation of the vehicle is a risk of 59 inches (150 cm)....
Owner Manual - Page 13
...batteries BEFORE
turning key switch to 'REVERSE', 'FORWARD' or
'NEUTRAL' positions.
613048
613048
Raise the seat to find this unit.
Unauthorized modifications can occur if key is not in the 'OFF' position. To disable electrical system, turn key to 'OFF' and remove battery...ELECTRICAL ARC or BATTERY...
WARNING
Windshields do not provide protection from golf balls or
EGWHL14
I
ON
R
F
...
Owner Manual - Page 16
... KEY TO ON Q MOVE DIRECTION SELECTOR TO
REVERSE Q AN AUDIBLE DEVICE WILL SOUND Q DEPRESS ACCELERATOR PEDAL
AND ACCELERATE SMOOTHLY
40.
41.
42. 43. 44. SAFETY
Read all Notices, Cautions, Warnings, and Dangers.
1
37. WARNING KEEP ENTIRE BODY INSIDE CAR
MAXIMUM TAILGATE LOAD
WARNING POSSIBILE ELECTRIC ARC OR BATTERY EXPLOSION. LOCKED
DIFFERENTIAL LOCKED
49. 50. 51...
Owner Manual - Page 21
... armature, solid copper windings
Drive Train:
Direct motor shaft connected to multiple vehcle terrains, with self-compensating system
Capacity:...) Continuous
Electrical System
48 Volt
Batteries (Qty, Type)
Six, 8 Volt Deep Cycle
Key or Pedal Start
Pedal Start
Battery Charger
48...Batteries
Dash mounted direction selector switch (Forward-Neutral-Reverse)
Full torque, reduced speed reverse...
Owner Manual - Page 22
...Cautions, Warnings, and Dangers.
2
MODEL: EXPRESS L4 TYPE: ELECTRIC POWERED PERSONNEL CARRIER
MODEL YEAR: 2012
Part No...Batteries
Dash mounted direction selector switch (Forward-Neutral-Reverse)
Full torque, reduced speed reverse...Electrical System Batteries (Qty, Type) Key or Pedal Start Battery Charger
Speed Controller Drive Train
3.0 HP (2.2kW) Continuous 48 Volt Six, 8 Volt Deep Cycle Pedal...
Owner Manual - Page 29
... neutral (the position between forward and reverse). Accelerator Pedal
Unintentional movement of the accelerator pedal will result in severe injury or death.
3- 3 State of control, do not use the accessory wiring harness MUST be charged.
3.
Located on the battery pack and E indicating the battery pack needs to move vehicle direction selector while the vehicle is...
Owner Manual - Page 32
... is to be accessed by raising the front seat to power accessories.
17. Battery Compartment
The battery compartment can be connected to all of this manual to become thoroughly familiar with DC to DC Converter
Charger is used to perform battery maintenance and access the Run/Tow switch.
3- 6 Charger with this vehicle. INTRODUCTION
Read...
Owner Manual - Page 43
... loose terminals, chaffing, corrosion or deterioration of control. Slow down an incline. Refer to control speed when traveling down before attempting to the level specified by the battery ...to control the vehicle.
Follow the safety instructions recommended by the battery manufacturer.
Depressing accelerator pedal will result in a sudden slowing of the vehicle and the...
Owner Manual - Page 45
...replace the environmental cover and seat. If vehicle speed continues to rise, apply the service brake to control speed and proceed with this manual to be overridden and normal vehicle operation resumes.
Unauthorized modifications can occur if key is deactivated. Connect...more than one second. ELECTRICAL ARC or BATTERY EXPLOSION can result in ... accelerator pedal released. Golf Steep ...
Owner Manual - Page 48
.... In the unlikely event of certain electrical system failures, the TruCourse Technology controller will default to a mode that the vehicle is in the reverse position, a warning signal will sound to...cable prior to run in a stalled condition for more quickly,
depress the service brake pedal.
Do not hold vehicle on while the accelerator is connected. High Pedal Disable Feature
High pedal ...
Owner Manual - Page 55
... End of Rear Axle
Center of Front Axle
View from Underside of this manual to become thoroughly familiar with this vehicle. REPAIR
Some servicing operations may require the front wheels, the rear wheels, or the entire vehicle to all four jack stands.
Use extreme care since the vehicle is supported by reversing...
Owner Manual - Page 63
... tables & the following )
Clean batteries & terminals. DO NOT LUBRICATE CABLES OR BRAKE
LATCH
Check for oil leakage, loose mounting hardware Check for this manual, contact a local Service Representative or see the Repair and Service Manual for loose or missing hardware and components Tighten or replace missing hardware
5 - 13 Pay particular attention to...
Owner Manual - Page 64
...excessive play and tightness of retaining nuts
STEERING ASSEMBLY RACK END BALL JOINT
Check ...loose or missing mounting hardware
ANNUAL - 250-300 HOURS (includes items listed in 1 1/2 gallons (6 liters) of water and flushed with extreme care. SEMI-ANNUAL - 125 HOURS (includes items listed in previous tables & the following warnings when working on the vehicle. To prevent battery...
Owner Manual - Page 68
... order to the batteries, these should be left in . The batteries should be placed into the battery racks and the battery hold downs and cables. Pay particular attention to 45 - 55 in the 'Tow/Maintenance' position for at least 30 seconds after the circuit is disconnected for any acid deposits.
Remove battery hold downs tightened to all wires and...
Owner Manual - Page 69
...attention to connect the battery wires as shown. Troubleshooting
In general, troubleshooting will prevent the termi- Use care to all Notices, Cautions, Warnings, and Dangers. Tighten the battery post hardware to 90 - 100 in an explosion. MAINTENANCE
Read all of this manual to become thoroughly familiar with a commercially available coating. nal nut from contacting battery terminals which...
Owner Manual - Page 71
... note the reading. If charger does turn on the float.
5
4. Hold the hydrometer in DC cord.
5 - 21 low 80° F (27° C).
This is in receptacle. Draw electrolyte into the hydrometer several times to permit the thermometer to adjust to replace the battery providing all cells are within fifty points of each cell...
Owner Manual - Page 72
... temperatures cause the chemical reaction to sit unused, it should be recharged. If a fully charged battery has a specific gravity of 1.275, and the battery is not reversible and will loose.002 of this manual to become partially discharged. In order to the battery.
The batteries must be recharged. This condition is allowed to slow down. The...
Similar Questions
What Causes Limp Mode Ezgo Rxv Golf Cart
(Posted by Anonymous-169198 2 years ago)
Replaced Solenoid Cart Still Won't Move
replaced solenoid cart still won't move
replaced solenoid cart still won't move
(Posted by mattnorris51 7 years ago)
3 Inch Rxv Gas Lift Kit
Why do the Low Engine Pan Bracket and the Isomount Bracket have to be replaced when adding the 3 inc...
Why do the Low Engine Pan Bracket and the Isomount Bracket have to be replaced when adding the 3 inc...
(Posted by Jasonbbx4 8 years ago)
What Do I Do When Charger Not Working And Gives 2 Red Blinks Pause Then Repeat
(Posted by bdponzio 9 years ago)
E-z--go Terrain Gas No Start 2013
hvae a 2013 ezgo terrain gas that i8 was trying to find reverse alarm. i disconnected the mircro swi...
hvae a 2013 ezgo terrain gas that i8 was trying to find reverse alarm. i disconnected the mircro swi...
(Posted by mjzeisz 9 years ago)