2012 Ford F250 Super Duty Support Question
2012 Ford F250 Super Duty Support Question
Find answers below for this question about 2012 Ford F250 Super Duty.Need a 2012 Ford F250 Super Duty manual? We have 2 online manuals for this item!
Question posted by whioe1d on July 27th, 2014
Where To Drain Fuel Filter On A 2012 Ford Super Duty Diesel
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by waelsaidani1 on July 28th, 2014 1:04 PM
waelsaidani1
Member since:
May 12th, 2013 Points: 19,501,797
Member since:
May 12th, 2013 Points: 19,501,797
Related Manual Pages
Diesel Supplement 3rd Printing - Page 3
... system and consists of: • a frame-mounted diesel fuel conditioner module (DFCM) / primary filter with an electric fuel pump and water drain, • an engine-mounted secondary fuel filter, • a fuel injector for each cylinder (8 total), • a high-pressure fuel pump, • a high-pressure fuel rail for more information. 3
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Diesel Supplement 3rd Printing - Page 4
... Fuel filter/water separator in the event of : • eight glow plugs (one per cylinder) • the glow plug control module (GPCM) • engine coolant temperature (ECT) sensor • barometric pressure (BARO) sensor • environmental temperature sensor
4
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Lubrication system It is illuminated, seek service from the fuel...
Diesel Supplement 3rd Printing - Page 7
... on position, this supplement for the drain procedure. See Diesel exhaust fluid in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Note: Air will illuminate when the DFCM has a significant quantity of this light will not operate properly if air enters the system. The water in fuel light will enter into your tank...
Diesel Supplement 3rd Printing - Page 11
... care must be clogged. Remove the air cleaner cover and the pleated paper filter, leaving the foam filter in the Maintenance and Specifications chapter. When filling the vehicle's DEF tank in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Diesel fuel is operated in the Maintenance and Specifications chapter. If you may slowly increase to...
Diesel Supplement 3rd Printing - Page 20
... fluid reservoir
8. Windshield washer fluid reservoir
20
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Secondary cooling system coolant reservoir 11. Air filter assembly 12. Engine oil fill 9. Brake fluid reservoir 4. Batteries 6. Maintenance and Specifications
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT F-Super Duty
13
5
1
2
3
4
12
11
10
9
8
7
6
5
1. Engine oil...
Diesel Supplement 3rd Printing - Page 23
... cold weather, if you have problems operating on biodiesel, you do not see a label on biodiesel. Damage to diesel fuel. Concentrations greater than 20% can also cause fuel filter restrictions that has been converted from renewable fuel sources, including vegetable oil, animal fat and cooking oil. Raw or refined vegetable oil, animal fat, cooking oil...
Diesel Supplement 3rd Printing - Page 25
...
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Diesel fuel should be using substandard fuel ...fuel system (during fuel filter change or if you run rough and produce white smoke while air is stored. Diesel fuel must not be stored in premature nozzle shut-off feature. The fuel will be taken whenever diesel fuel is in the fuel injectors causing expensive-to-repair damage. Diesel fuel...
Diesel Supplement 3rd Printing - Page 38
... (12553 km) - 9300 miles (14967 km)
FUEL FILTER/WATER SEPARATOR Diesel Fuel Conditioner Module (DFCM) The vehicle is allowed to drain the water separator. Maintenance and Specifications
Pick-up (4....drained from the module assembly whenever the warning light comes on and the message center directs you to exceed this level, the water may cause fuel injection equipment damage. 38
2012 Diesel...
Diesel Supplement 3rd Printing - Page 40
... has fully warmed up, consider different fuel sources. • Low fuel operation: If the message appears when the vehicle is not low, the fuel filters must be void from using additives that...meet or exceed Ford specifications. the tank level is equipped with a low fuel pressure detection system. Do not use alcohol based additives to your authorized dealer.
40
2012 Diesel (67l) Supplement...
Diesel Supplement 3rd Printing - Page 41
...; This part number includes filters and seals for the fuel filter kit part number.
41
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) DFCM filter later in this section. 2. Refer to improve assembly. 3. Removal - To install the new DFCM filter, see Installation - See Fuel filter/water separator earlier in this chapter. Regular fuel filter changes are an important...
Diesel Supplement 3rd Printing - Page 42
... rag below the filter connectors to completely bleed off. Note: Although the fuel system is not fully pressurized when the vehicle is not tightened to soak into the fuel filter element. Tighten the lower housing until it clockwise onto DFCM housing, allowing fuel to the mechanical stop . Note: The engine will drain.
42
2012 Diesel (67l) Supplement, 3rd...
Diesel Supplement 3rd Printing - Page 43
... more frequently than average impurities may indicate that air is tight and the filter bowl has been tightened to the mechanical stop.
43
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Purging air from the fuel system after DFCM and engine mounted fuel filter replacement Turn the ignition key to on for 30 seconds, then turn...
Diesel Supplement 3rd Printing - Page 46
... will be determined by washing with soap and water. WARNING: Do not handle a hot oil filter with new oil. Unscrew the oil filter and oil pan drain plug and wait for vehicle operation) • use of high-sulfur diesel fuel 46
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Protect your skin by the Intelligent Oil Life...
Diesel Supplement 3rd Printing - Page 65
.... If air enters the fuel system (either through running the fuel tank(s) empty or during a fuel filter change), the engine will make restarting difficult. The engine may be in P (Park) or N (Neutral) in order for the starter to operate. 65
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Turn on for larger heavy duty trucks. If the...
Diesel Supplement 3rd Printing - Page 67
... damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If this fuse immediately burns out and you cannot locate the cause, return your vehicle to the Owner's Guide for more information. MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre-filter FA-1907 * Air filter FA-1902 Fuel filter kit (2 included...
Diesel Supplement 3rd Printing - Page 68
... Orange Engine Coolant
Maintenance and Specifications
Engine oil (includes filter change) 13.0 quarts (12.4L)
•Motorcraft Motor Oil 10W30 Super Duty •Motorcraft Motor Oil 15W40 Super Duty •Motorcraft Motor Oil 5W40 Super Duty •Motorcraft Motor Oil 0W30 Super Duty Motorcraft Diesel Exhaust Fluid
VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS...
Diesel Supplement 3rd Printing - Page 74
drain if necessary (or if indicated by the message center (whichever comes first) Special operating Refer...filter restriction gauge Fuel filter/water separator; Scheduled Maintenance Guide
Maximum Oil Change Interval As indicated by the message center (do not exceed one year or 10,000 miles [16,000 km]) Special operating Refer to make sure they are functional and clear of debris
74
2012 Diesel...
Owner Guide 4th Printing - Page 53
... void from using additives that do not meet or exceed Ford specifications. the tank level is required. FUEL FILTER CHANGE REQUIRED (diesel engine only) - If the message does not come back, the low fuel pressure condition was due to your diesel supplement for more information. 53
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA...
Owner Guide 4th Printing - Page 315
...the wheel rims (for cars) or the bottom of the final application, is responsible for trucks). Ford Super Duty Vehicles are approved for construction or tire service, and pumping fluids. When driving through water, traction or... a wheel-lift for tow trucks, cranes, tools for use as dry brakes.
315
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) In this condition, there is...
Owner Guide 4th Printing - Page 440
...units with synthetic fluid and light-duty trucks equipped with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number ...fuel filter replacement: If the vehicle is 5,000 miles (8,000 km). Police/Taxi/Livery vehicle axle maintenance: Change rear axle fluid every 100,000 miles (160,000 km). The axle fluid should be waived if the axle is 3,000 mile (4,800 km). 440
2012...
Similar Questions
How To Set 2012 Super Duty Memory To Transmitter
(Posted by Scotttoma 10 years ago)
Instructions On How To Rset Air Filter On 2012 Super Duty
(Posted by mispshaw 10 years ago)
How To Drain Coolant From 2012 Ford F250 Diesel
(Posted by Exilowhaz 10 years ago)
How To Install Fog Lights In 2012 Super Duty
(Posted by PIEzbigni 10 years ago)
What Is System Reset On 2012 Ford F250 Super Duty Diesel
(Posted by nucstajau 10 years ago)