2012 Ford F550 Cab Support Question
2012 Ford F550 Cab Support Question
Find answers below for this question about 2012 Ford F550 Cab.Need a 2012 Ford F550 Cab manual? We have 2 online manuals for this item!
Question posted by Anonymous-100822 on February 27th, 2013
How Come Gages Don't Work?
I have a 2002 F550 diesel. None of the gages work & the check engine light does not work. I have checked the fuses and they are all good. What else should I look for?
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 19
... material. Never work around the diesel oxidation catalytic converter and/or the diesel particulate filter (DPF). Failure to follow these instructions may result in personal injury.
19
2012 Diesel (67l) Supplement...clear of mud/debris or foreign material to a high temperature after the engine is very high. The diesel oxidation catalytic converter and/or the DPF heats up to maintain proper ...
Diesel Supplement 3rd Printing - Page 31
...DEF tank can cause engine damage not covered by ... is important to the diesel fuel fill inlet. You can purchase DEF at the following web address that can contact roadside assistance for repair work, etc., the same... location to purchase DEF: http://www.afdc.energy.gov/afdc/ locator/def. Look for more information. Maintenance and Specifications
Filling the DEF tank Your vehicle is equipped...
Diesel Supplement 3rd Printing - Page 32
... coughing and watery eyes. When opening the cap on the container until it is tight.
32
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The vapors can cause burning to the instructions on the...the DEF tank or bottle containing DEF, ammonia vapors may escape. Ensure that DEF does not come into the bottle. Remove the spout from the DEF container. Should DEF contact your authorized ...
Diesel Supplement 3rd Printing - Page 38
... to exceed this level, the water may be drained from the module assembly whenever the warning light comes on and the message center directs you to the engine and may cause fuel injection equipment damage. 38
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
Pick-up (4.30 axle ratio) Trailer towing...
Diesel Supplement 3rd Printing - Page 40
... during the cold start , monitor the message center. Maintenance and Specifications
LOW FUEL PRESSURE MESSAGE The engine is at or very near empty, refuel the vehicle and operate the vehicle. the tank level is..., take the vehicle to your authorized dealer.
40
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If the message does not come back, the low fuel pressure condition was due to 10...
Diesel Supplement 3rd Printing - Page 48
...service location. These can cause engine damage from corrosion, overheating or freezing. steam and hot liquid can cause engine damage from orange to pink or light red. Note: Do not use... case of emergency, a large amount of water without engine coolant) can be harmful and compromise the corrosion protection of the engine coolant.
48
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The...
Diesel Supplement 3rd Printing - Page 53
...reading Check the air filter restriction gauge whenever the hood is raised to be changed.
53
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) A filter which appears to perform general engine ...maintenance at least every 500 miles (800 km), or two weeks, whichever comes first....
Diesel Supplement 3rd Printing - Page 63
Do not modify or remove the tail-pipe section. Use special care when working around or attempt to repair any vehicle modification without determining applicable law. Provide adequate insulation. WARNING: The normal operating temperature of the service engine soon light
63
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Failure to follow these instructions may...
Diesel Supplement 3rd Printing - Page 65
...change), the engine will make restarting difficult. this is a clicking or stuttering sound coming from the engine compartment when you fuel your diesel vehicle out...key to START, this will allow air to START the lights become dim or go on at a truck stop after ...fuel system which will self-purge the trapped air once it checked and corrected. • The gearshift lever must be required...
Diesel Supplement 3rd Printing - Page 71
...vehicle when you should perform the oil change .
71
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Scheduled Maintenance ... is equipped with the vehicle and confirmation of the work performed is prematurely reset or becomes inoperative, you sell...it is an investment that the materials used meet Ford engineering specifications as identified in the message center display, it...
Diesel Supplement 3rd Printing - Page 74
...whichever comes first) Special operating Refer to Special operating conditions later in the Maintenance and Specifications chapter Refer to make sure they are functional and clear of debris
74
2012 Diesel (67l...to Special operating conditions later in this chapter Engine Coolant Change Interval Six years or 100,000 miles (160,000 km) (whichever comes first), or as indicated from the coolant ...
Diesel Supplement 3rd Printing - Page 82
... additive, if required Every 60,000 miles Flush and refill engine coolant; do not add (96,000 km) or 2,400 engine coolant additive engine hours 82
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Example #1: The OIL CHANGE REQUIRED message comes on but the odometer reads 22,500 miles (36,000 km); and frame-mounted...
Diesel Supplement 3rd Printing - Page 91
...comes first. For trucks operated at approximately 250,000 miles (400,000 km) depending upon engine/vehicle operating conditions) and replaced with the oxidation catalyst/DPF system a service light ( or ) will set by the engine...light ( inform you to bring the vehicle into a dealership for long periods above 70°F (21°C) and at wide-open throttle for service.
91
2012 Diesel... check ...
Diesel Supplement 3rd Printing - Page 92
Scheduled Maintenance Guide
ENGINE COOLANT CHANGE RECORD Initial change 6 years or 105,000 miles (168,000 km) (whichever comes first), or as indicated from the coolant tests for concentration (freeze-point) or additive strength (corrosion inhibitor) Every 3 years or 45,000 miles (72,000 ...
Owner Guide 4th Printing - Page 101
...cigarette lighter socket (if equipped). To prevent the fuse from the plug. Refer to Fuses and relays in the power outlet for information on checking and replacing fuses. 101
2012 F-250/350/450/550 (f23) ...cups in fire or serious injury. If the power point or cigar lighter socket is not working, a fuse may have blown. Hard objects can be found in a collision. Improper use of the ...
Owner Guide 4th Printing - Page 311
... coming up to the point that assistance may be required from your tires, the Tire Pressure Monitoring System (TPMS) indicator light... case or front axle are submerged in slick mud. You should be checked and changed, if necessary. 311
2012 F-250/350/450/550 (f23... illuminate (if equipped). Driving
can be improved by moving can work against you and cause the vehicle to back out the way ...
Owner Guide 4th Printing - Page 321
...fuse with a diesel engine, see the Diesel supplement for additional Fuel Pump Shut-off reset instructions. Blown fuses are not working, a fuse may have blown. Should your vehicle by doing the following: 1. FUSES AND RELAYS Fuses... the off feature that stops the flow of fuel to the engine. Check the appropriate fuses before replacing any collision. Roadside Emergencies
FUEL PUMP SHUT-OFF In...
Owner Guide 4th Printing - Page 378
...accessories or components added to come near the battery. Lift the battery with a battery carrier or with water for an extended period of time. When working near the battery, always shield... battery, excessive pressure on opposite corners. Therefore, do not allow flames, sparks or lighted substances to the vehicle by the dealer or the owner may adversely affect battery performance and...
Owner Guide 4th Printing - Page 383
... protection. Vehicles driven year-round in the Adding engine coolant section. Always dispose of recycled engine coolant since a Ford-approved recycling process is equipped with a diesel engine, refer to the Maintenance product specifications and capacities section of the engine coolant and may cause engine damage. Fill your engine coolant reservoir as outlined previously in non-extreme...
Owner Guide 4th Printing - Page 409
...fus) Removing vehicle from storage When your vehicle is ready to come out of storage, do the following: • Wash your authorized dealer if... you have any dirt or grease film build-up . • Check fluid levels (including coolant, oil and gas) to make sure there...at least 25 feet (8 m) every 15 days to lubricate working parts and prevent corrosion. Drive the vehicle 15 ft (4.5 meters) back and ...
