Home » Honeywell » Power » Honeywell HW2000i

Honeywell HW2000i Support Question

Find answers below for this question about Honeywell HW2000i - Portable Inverter Generator.
Need a Honeywell HW2000i manual? We have 1 online manual for this item!

Honeywell Overview Questions Manuals Reviews Videos Research

Question posted by psi0880 on May 8th, 2013

Motor Stop After A Few Minutes

Hi, I started it up and it ran for a few minutes than shut down like someone turned it off. Wouldn't restart. Waited an hour. Started right up. Ran a couple of minutes than sfut off again. Each time it runs less time until it only run a couple of seconds. Still have to wait an hour or more in between starts. Which part could be defective? Thanks Real Dufresne

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related Honeywell HW2000i Manual Pages

Owners Manual - Page 2

... 105 Milwaukee, WI 53212-1082 USA TEL 1-888-HWHELP1 (494-3571) www.honeywellgenerators.com © 2009 Northshore Power Systems, LLC The Honeywell Trademark is used under license from Honeywell International Inc. WARNING This manual contains important instructions for operating this product. Failure to be found on owning a Honeywell inverter generator! Honeywell International Inc.

Owners Manual - Page 5

... Screen ...24 Spark Plug Service ...25 Transporting Generator ...26 Storing Generator ...26 TROUBLESHOOTING ...27 SPECIFICATIONS AND WIRING DIAGRAMS 29 WARRANTIES ...33 NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY 33 NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY 34 INDEX ...37 MAINTENANCE PARTS 39 HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com i

Owners Manual - Page 7

...equipment damage. Explosion Toxic fumes Fire Chemical burn Electrical shock Hot surface DANGER Using a generator indoors CAN KILL YOU IN MINUTES. NOTE: Since there are many variations in the circumstances surrounding the installation, operation, ...to specific types of this manual to bystanders. HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 1

Owners Manual - Page 8

... hot for a while after stopping the engine. • NEVER touch hot surfaces and avoid hot gases. • Let engine cool before starting the engine. • Avoid repeated or prolonged contact with skin or breathing of children, pets, and untrained people. plies correct rated frequency and voltage when running . Turn generator OFF and allow to live...

Owners Manual - Page 11

..., separate damaged materials and call 1-888-HWHELP1 (494-3571). Ambient Temp.: Serial Number: HW2000i 101440A 120V/12V 2.0kW 40oC Phase: 1 Frequency: 60Hz Engine RPM: 5000 Fuel: Gasoline Insulation Class: F FIGURE 3: Generator Nameplate Location HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 5 Verify that may have occurred during shipment. If loss...

Owners Manual - Page 12

...The transfer switch is a transfer switch? Grounding the Generator Grounding the Generator Grounding the Generator WARNING Generator must be observed. 6 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner's Manual The National Electric Code requires the generator to the intended use of generator. Please consult a qualified electrician, electrical inspector, or the...

Owners Manual - Page 14

.... Oil Alert Indicator Light Illuminates red when low oil conditions are present and the generator is running under normal operating conditions. 6. If there is a short circuit in circumstances leading to prevent generator damage. 8 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner's Manual Outlets 125VAC outlet(s) (NEMA 5-15R [HW1000i model] and NEMA 5-20R...

Owners Manual - Page 17

.... BEFORE STARTING GENERATOR, FILL WITH ENGINE OIL. See page 22. ‰ Check air filter-See "Air Filter Maintenance" on page 23. ‰ Be sure ground terminal is set on an uneven or flexible surface, generator could ignite. • Place generator on filling, checking, and changing oil. ‰ Check/add fuel-ADD FUEL. HW1000i / HW2000i Inverter Generator Owner...

Owners Manual - Page 19

...: Recoil Starter Handle 10. Starting Generator Starting Generator 12. FIGURE 11: Prime Engine NOTE: INITIAL START: Depress the primer bulb 30-50 times to snap back against the engine. 11. NOTICE If the engine stops and will not restart, check the engine oil level before troubleshooting in other areas. After the engine starts, let run to empty before connecting any...

Owners Manual - Page 20

... time. 1. FIGURE 15: Efficiency Mode Switch Stopping Generator In an emergency: Press the engine control switch to the STOP position. 4. HW1000i / HW2000i Inverter Generator Owner's Manual Press the engine control switch to the STOP position. The oil alert system will increase. High-altitude performance can be plugged into the generator. 2. NOTICE If engine jetted for 2-3 minutes...

Owners Manual - Page 21

... energy consumption) 1800-5000 60 / 100 65-175 55-250 750* 1200-1875 750-1500 HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 15 ance you will need to run appliances using the generator to power appliances, take time to appliance operating manuals, or contact appliance manufacturer. Check labels inside , or on the back of appliance...

Owners Manual - Page 22

...HW1000i / HW2000i Inverter Generator Owner's Manual Examples of the generator. NOTE: Appliances in grey require a higher wattage output than the inverter generator will produce. CAUTION Do not run power cords under carpet, rugs, or other materials where heat might build up to three times normal running watts for starting this appliance. NOTICE Starting appliances that of motorized...

Owners Manual - Page 23

...Using a generator indoors CAN KILL YOU IN MINUTES. This is a poison you cannot see Table 3). If engine must be run, be ...HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 17 Always follow inspection and maintenance recommendations and schedules in the Generator Maintenance Schedule (see or smell. NEVER use inside a home Only use . WARNING Accidental starting...

Owners Manual - Page 24

...HW2000i 0.48 / 450 18 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner's Manual Check the oil level is a major factor affecting engine performance and service life. Place the generator on a flat, level surface. 3. Stop the generator...in good running . Engine Oil Recommendations Use 4-stroke oil, or equivalent high detergent, premium quality motor oil ...

Owners Manual - Page 25

...on its side. Start the engine and run until fully tightened...ALWAYS stop engine before removing the oil fill cap. 5. HW1000i / HW2000i Inverter Generator Owner's...shut off the generator to prevent engine damage. 9. Reinstall the oil fill cap until warm. 4. FIGURE 21: Oil Fill Cap Installation FIGURE 22: Generator on a flat, level, slightly raised surface (HW2000i model illustrated). Stop...

Owners Manual - Page 27

...fuel is running. DANGER ...times of the fuel strainer. For skin contact, wash with clean water and seek medical attention. Use unleaded gasoline with alcohol or other additives to spill fuel when refueling. Some areas of 87 or higher. HW1000i / HW2000i Inverter Generator...motor oil according to a conventional unleaded gasoline. Turn generator OFF and allow to cool before starting...

Owners Manual - Page 28

... NOTICE Running the engine with a clean, dry cloth. 6. Stop the generator if the engine is running . Place the generator on ...starting or performance problems. Gasoline containing ethanol may damage metal, rubber and plastic parts of 87 or higher. 1. Stop the generator...cap. 22 www.honeywellgenerators.com HW1000i / HW2000i Inverter Generator Owner's Manual Clean the fuel strainer with...

Owners Manual - Page 29

... every 50 hours of household soap and warm water. WARNING Gasoline and flammable solvents can cause fire or explosion. Stop the generator if the...damage. FIGURE 36: Air Filter Oiling HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 23 Air Filter ...dry cloth ‰ Clean engine oil 1. If the generator is running. To clean air filter, you will restrict air ...

Owners Manual - Page 33

... start or starts and runs rough Engine suddenly stops Low power ...Turn engine switch or fuel valve on generator. Check electrical appliance/equipment for "tripped' position or overload indicator light on circuit, wait several minutes, and then push to closely follow all customer service inquiries, call 1-888-494-3571 or visit www.honeywellgenerators.com. HW1000i / HW2000i Inverter Generator...

Owners Manual - Page 35

...5000** OHV 4-cycle 125 1.5 / 5.7 0.48 / 450 0.024-0.028 / 0.6-0.7 HW1000i / HW2000i Inverter Generator Owner's Manual www.honeywellgenerators.com 29 SPECIFICATIONS AND WIRING DIAGRAMS Model HW1000i DIMENSIONS Length [in / mm]...383.5 Width [in / mm] 9.6 / 243.8 Dry Weight [lb / kg] 30 / 13.6 POWER OUTPUT Rated (AC) [watts] 900 Rated (DC) [watts] 60 Frequency* [hertz] 60 Voltage (AC...