Hoveround MPV5 Support Question
Hoveround MPV5 Support Question
Find answers below for this question about Hoveround MPV5.Need a Hoveround MPV5 manual? We have 1 online manual for this item!
Question posted by zthegirl on June 5th, 2018
Front Left Wheel Removal.
Removed the bolt and the wheel will not come off. There's a wheel pin and it's stuck. The right wheel came off with out any problem.
Current Answers
Answer #1: Posted by BusterDoogen on June 6th, 2018 10:33 AM
BusterDoogen
Member since:
October 30th, 2011 Points: 28,565,407
Member since:
October 30th, 2011 Points: 28,565,407
Go here for the procedure!
I hope this is helpful to you!
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!
Related Hoveround MPV5 Manual Pages
User Manual - Page 3
...without notice. Notes usually contain information regarding troubleshooting the power wheelchair when an indicator or fault light appears. No part of...good judgment and/or common sense. HOVEROUND® and MPV5 are registered trademarks of the signal words. Indicates a ... injuries and/or damage resulting from any and all rights in those marks. D82008753M 10/13
3
Hoveround-MPV5ManualRevM...
User Manual - Page 6
... Seat and Adjustments 36
Chapter 5 Options and Accessories 40
Chapter 6 Routine Maintenance 44
Chapter 7 Disassembling and Reassembling Your MPV5 47 Removing and Replacing Your Controller 47 Removing and Replacing the Seat 48 Removing and Replacing Batteries 50
Chapter 8 Electromagnetic Interference (EMI 52
Chapter 9 Appendixes 55 Appendix A Programmable Parameters 55 Appendix B Fault...
User Manual - Page 8
... warnings and instructions to when needed. Keep your Hoveround® MPV5 power wheelchair. The operation of the power wheelchair requires you to drive your home are contained in the manual....
In confined spaces and while learning to exercise caution and consideration for your power wheelchair, we recommend that the power is a battery-operated motor vehicle. Your "Safety and...
User Manual - Page 10
... surfaces such as ice, oily, polished, and/or treated surfaces.
• Secure or remove any loose rugs or carpets and remove obstacles from the travel paths in your home.
• Drive slowly over , collision with...pavement, grass, gravel, sand, wet leaves or cut grass.
• Never attempt to drive a power wheelchair off or up or down.
• Do not attempt to drive on a ramp or slope; For ...
User Manual - Page 12
...;
Seat Belt •
• Battery Cable Connection (if equipped)
•
Seat
(Swivel Optional)
• •
•
Batteries
Brake Release Levers
Dual Motor Front Wheel Drive
•
• Anti Tip Wheels
•
Flip Up
Footplate
12 Hoveround® MPV5 - Diagram
D82008753M 10/13 Hoveround-MPV5ManualRevM 1/17/14 10:36 AM Page 12
Hoveround®...
User Manual - Page 15
...on joystick controller (page 18) to identify the type of the seat.
• Always fasten seat belt to drive the power wheelchair.
Entering Your MPV5
1. Footplate Down Footplate Up D82008753M 10/13
Chapter 1 15 Flip up the footplate. Be sure the power is OFF before ...Always make sure that the power is turned "OFF" before getting into or out of controller on your power wheelchair.
2.
User Manual - Page 16
....
• Always fasten seat belt to maintain proper positioning in the seat. Driving Your MPV5 Power Wheelchair
• Sudden change in the forward facing position and the seat swivel is OFF before ... place.
6.
Do not attempt to drive this power wheelchair with the seat-back reclined makes it difficult to drive the power wheelchair.
Be sure to secure footplate in upright position and ...
User Manual - Page 19
.... Joystick - The further you push, the faster you go off if left idle for error codes and troubleshooting information.
3. Pressing the button increases speed... may blink or the controller will cause the power wheelchair to stop quickly move the joystick from the forward position...remaining. Push the ON/OFF button twice to identify your MPV5 are located on and off . The controller has a ...
User Manual - Page 23
...is connected into a series configuration to a power source when not charging.
• Do not let your wheelchair battery. non -
The batteries supplied by Hoveround®.
• ALWAYS use a battery that require no ... have been frozen. The MPV5 uses two sealed 12-volt batteries of the UI size, with capacity of the same type and capacity for this power wheelchair.
• NEVER connect...
User Manual - Page 31
To adjust the arm angle on the seat arms, lift the arm and locate the adjustment bolt near the pivot point.
Hoveround-MPV5ManualRevM 1/17/14 10:36 AM Page 31
Arm Angle Adjustments
The seat...1/4 inch hex wrench to the controller. Figure 4D
Controller Position Adjustment
You can adjust the position of the removal key opening (see Figure 7B, page 43) in the bracket before tightening.
User Manual - Page 34
Remove the screw and nut and place the back in the outer hinge and inner hinge brackets line up for the desired angle.
3. ...Page 34
Figure 4H
Seat Back Angle Adjustment
The seat back has fixed positions to select from the back, push or pull on the left hinge and right hinge.
2. Locate the screw and nut on the arms or another solid surface.
34 Chapter 4
D82008753M 10/13 Re-install the screws...
User Manual - Page 35
...the arm and completely remove the seat from the ... turn the screws in the seat post (see Figure 4GK below ). Install the pin and collar in the down position. Figure 4J
Footplate Angle Adjustment
The footplate angle can raise... or lower the seat by turning the adjustment bolts clockwise to increase the angle and counterclockwise to make sure both of the ...
User Manual - Page 39
...open access to that hold the arm in place.
If arm angle adjustment is correct. Tighten bolts in the newly opened hole. Figure 4P
D82008753M 10/13
Chapter 4 39 The arms can be... up about 1 inch until you feel the depression for bolt location. A small screwdriver works well. Remove the arm bolts and reposition with the top bolt in place. Raise and lower arm to be raised from...
User Manual - Page 40
... using the chair's restraint. Optional Tie-Down Brackets
When transporting the MPV5 in a motor vehicle even if the chair is not intended to a fall from the seat, do not sit in your power wheelchair while riding in a motor vehicle, your wheelchair must be adequately secured within the motor vehicle. Please contact Hoveround®...
User Manual - Page 41
...Back Seat
Driving with seatback reclined. Do not attempt to recline approximately 45 degrees. The MPV5 will permit the seatback to drive this vehicle with the seatback reclined makes it difficult ... increases the chance of serious injury or death from collision and tip-over.
Your power wheelchair contains a lock-out feature that prevents driving when the seat is on.
The optional ...
User Manual - Page 45
...holds
(if equipped). • Clean power wheelchair. (See page 42 for loose connections,
damaged cables or signs of electrical damage. • Check that caster wheels rotate freely. • Check manual brake ... that all seat swivel screws are tight (if equipped). • Check that the armrest bolts are tight. • Check charger cords and connectors for instructions.)
A worn or improperly...
User Manual - Page 46
...brush off dirt, then wipe with a cotton swab, using a mild detergent. Food-type contaminants can be removed from around the joystick boot by carefully cleaning with a damp cloth or towel, using a mild detergent. ...mild detergent. Top Cover - Hoveround-MPV5ManualRevM 1/17/14 10:37 AM Page 46
Cleaning your MPV5
The MPV5 is off loose material with a dry bristle brush and wipe with liquid.
User Manual - Page 47
...your chair (See Figure 7A, below ).
Position key hole portion of bracket over screw and slide into place.
3.
Remove bracket from seat. (See Figures 7C, Page 44). Cap Screw
Keyhole
Figure 7A
Figure 7B
Replacement
1. D82008753M 10... 10:37 AM Page 47
Chapter 7
Disassembling and Reassembling Your MPV5
Controller Removal/Replacement
Removal
1. Check that vehicle power is OFF.
2.
User Manual - Page 48
..., page 44). 4. Grasp the seat at the top-front corner of seat you have.
Hoveround-MPV5ManualRevM 1/17/14 10:37 AM Page 48
Seat Removal/Replacement
Removal 1. The power wheelchair and its components are heavy. To avoid injury, do not attempt to lift beyond your other hand. (See Figures 7C, 7D and 7E...
User Manual - Page 51
...the holder to disconnect battery terminals. Replacement 1.) Reverse the steps to remove the batteries.
Remove the fuse from battery cover.
3.) Carefully remove post screw and remove cover.
Remove batteries. D82008753M 10/13
Chapter 7 51 Hoveround-MPV5ManualRevM 1/17/14 10:37 AM Page 51
Battery Removal/Replacement MPV5 S/N 5800000+
Turn the joystick off before attempting to reduce...
Similar Questions
What Are The Positive And Negative Wires Coming From The Wheel Motors What Color
(Posted by Erjackson76 1 year ago)
What Is The Size Wrench To Remove Tire On The Mpv5
Need to remove tire because it is flat
Need to remove tire because it is flat
(Posted by mbilbrey49 8 years ago)
Mpv5 Wiring
Replaced control panel and want to make sure the wire hookups are correct
Replaced control panel and want to make sure the wire hookups are correct
(Posted by slestep59 8 years ago)
Hoveround Mpv5 Stopped Moving
Hoveround MPV5 stopped moving. Lights on control panel, flashing. How to fix it?
Hoveround MPV5 stopped moving. Lights on control panel, flashing. How to fix it?
(Posted by wjcannonjr 9 years ago)
I Have A Hoveround Mpv5 Need A Wiring Diagram Loose Connection To Left Motor
The left wheel stopped working & the lights are 2 red blinking indicating a loose connection of ...
The left wheel stopped working & the lights are 2 red blinking indicating a loose connection of ...
(Posted by punkee75 9 years ago)