Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by mstan on May 21st, 2014
Toro Guaranteed To Start 7.0 190cc Won't Stay Running
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on July 9th, 2014 3:09 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
Hi, if your mower starts but won't stay running, it's likely either a problem in the fuel tank/fuel line or carburetor. Try flushing the gas tank and carburetor, giving the carburetor a good cleaning to make sure no holes or venturis are clogged, and checking the fuel hose for burrs or blockages. Then fill the gas tank with new, fresh gas and give it a try.
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
Here is a link to a list of common maintenance parts for this model, including the carb rebuild kit: - Toro 20332 Common Maintenance Parts List
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
Here is a link to a list of common maintenance parts for this model, including the carb rebuild kit: - Toro 20332 Common Maintenance Parts List
Related Toro 20332 Manual Pages
Operation Manual - Page 1
...of special attention. It is not equipped with Canadian ICES-002.
© 2011-The Toro® Company 8111 Lyndale Avenue South Bloomington, MN 55420
Register at www.shoptoro.com.
...any forest-covered, brush-covered, or grass-covered land. Introduction
Model No.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up ...
Operation Manual - Page 2
... working.
• Never leave a running .
• Be sure the area is generally a warning of trouble.
• Always wear eye protection when operating machine.
• See manufacturer's instructions for proper operation and installation of bystanders before you to potential personal injury hazards. never up and down and behind rotary lawn mowers and the B71.1 specifications...
Operation Manual - Page 3
... up .
Service
Safe Handling of Gasoline
To avoid personal injury or property damage, use extra caution when servicing...add fuel with manufacturer's recommended parts, when necessary.
• Mower blades are explosive.
• Extinguish all nuts and bolts ...engine running . WARNING
Exhaust contains carbon monoxide, an odorless, deadly poison that may block your vehicle before starting ....
Operation Manual - Page 4
...a safe distance from moving parts.
5. Cutting/dismemberment hazard of hand or foot, mower blade-remove the ignition key and read the Operator's Manual.
2. and look behind...-read the Operator's Manual for information on slopes;
Cutting/dismemberment hazard of hand or foot, mower blade-stay away from the machine.
3. do not operate up .
4 Cutting/dismemberment hazard of potential ...
Operation Manual - Page 5
...service classification of oil into the oil fill tube, then remove the dipstick.
5. Before starting the engine, fill the engine with a clean cloth.
4. Note: When the crankcase is... with a bottle of oil in step 1 .
1.
Figure 3
2. Remove the handle knobs from the mower housing (Figure 3). Dipstick
Figure 4
3. Install and tighten the handle knobs that covers the engine.
1
Installing...
Operation Manual - Page 6
... models only)
6 Battery charger (electric-start handle
7.
Figure 5
1. Ignition key (electric-start models only Refer to Changing the Engine Oil. Oil fill/dipstick
12. Handle knob (2)
6. Important: Do not overfill the crankcase with oil and run the engine. Washout port (not shown) 13. Side discharge chute
3. Cutting height lever (4)
2. Spark plug
Figure 6
1. Install...
Operation Manual - Page 7
... service classification of 87 or higher) from igniting the gasoline, place the container and/or mower directly on the dipstick reads Full.
6. Remove the dipstick (Figure 8). Note: If the... type: SAE 30 detergent oil with oil and run the engine. Move the mower to the fuel all season, mixing it with gasoline.
Important: To reduce starting problems, add fuel stabilizer to a level surface....
Operation Manual - Page 8
... levers forward. Blade control bar
Figure 10
2. Note: When you pull the recoil start handle (Figure 12). Raise the mower
Figure 9 2. Lower the mower
Note: The cutting height settings are 1 inch (25 mm); 1-3/8 inches (35... key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it sharply (Figure 12). CAUTION
If the engine has been running, the muffler will be hot ...
Operation Manual - Page 9
... serious personal injury or death to Operating the Bag-on the upper handle and your elbows at your sides, and the mower will automatically keep pace with you release the blade control bar, both the engine and blade should stop the engine, release the blade control bar.
Recycling the Clippings
Your mower comes from the lawn...
Operation Manual - Page 10
...contacting the blade can result in bagging position)
1.
Bag-on-demand lever (in serious personal injury. Grass bag pin (2)
2.
Also, an open rear discharge area could allow ...on-demand feature allows you to either collect or recycle grass and leaf clippings while the grass bag is sharp; Stop the engine and wait for all moving parts to the mower. • For bagging the grass and leaf ...
Operation Manual - Page 12
...lawn for damage.
• For best performance, install a new blade before the cutting season begins.
• Replace the blade when necessary with each pass.
- This helps disperse the clippings over 6 inches (15 cm) tall, mow at a slower pace... Toro replacement blade. Cut the grass more than one pass over any object.
• If the mower strikes an object or starts to slow down your mower...
Operation Manual - Page 13
... wire from an Authorized Service Dealer (go to www.toro.com to your engine operator's manual for Maintenance
1. tip the mower prior to stop.
2. Refer to your engine operator's manual. • Refer to your engine operator's manual for all moving parts to running out of the machine from the normal operating position.
never...
Operation Manual - Page 14
...on the dipstick reads Full. 11. Move the mower to open the air filter cover
(Figure 19... 19). 3. Install the cover.
1. Return the mower to Preparing for the oil to warm it. Drain... with oil and run the engine. Figure 21
5. Tip the mower onto its side with...the Engine Oil
Service Interval: After the first 5 hours Yearly
Run the engine a few minutes before changing the oil to settle....
Operation Manual - Page 15
... longer holds a charge, recycle or dispose of California to...
Electric-start models only
If the battery does not charge or the engine does not run with a 40-amp plug-in type fuse.
1. Replacing the Fuse
Electric-start models ...70° or 22° C) whenever possible. 1. Connect the charger to the mower wire harness
located below the ignition key (Figure 22).
• A green light indicates...
Operation Manual - Page 16
...
16 While holding the blade with the screw that you removed in serious personal injury.
Wear gloves when servicing the blade.
1.
Tip the mower onto its side with a spare fuse in the fuse holder (Figure 24...to tighten the blade bolt to 60 ft-lb (82 N-m) is sharp; If you run out of the blade to hold the blade steady
(Figure 25).
Important: A bolt torqued to 60 ft-lb (82 ...
Operation Manual - Page 17
... Start the engine and run it from the housing to the grass bag. Start the engine and run it until
there is very difficult to the washout port on .
6.
Move the mower onto... running. • Do not allow bystanders in both the fully forward and fully rearward positions. 4. Attach a garden hose that come out from under the mower housing. • Wear eye protection. • Stay ...
Operation Manual - Page 18
... the wire to prevent cylinder corrosion during the off-season.
8. Run the mower until you can explode.
• Do not store gasoline more than 30 days.
• Do not...handle knobs until the engine stops from running out of any unused fuel properly. To unfold the handle, reverse the steps above. Recycle it according to the outside of hard starting. Disconnect the wire from Storage
1....
Operation Manual - Page 20
... due to accidents or lack of purchase:
Products
22 in Recycler and 20 in materials or workmanship. The Toro Total Coverage Guarantee
A 2-Year Full Warranty (45 Day Limited Warranty for Commercial Use)
The Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler® 20 in the Operator's Manual have been performed...
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA. All Rights Reserved
Similar Questions
My 1 Year Old Toro Personal Pace Lawn Mower Won't Start
(Posted by nasb 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
Toro 190cc Personal Pace Won't Start
(Posted by Soupokef 10 years ago)
2011 Toro Recycler Personal Pace Lawn Mower Wont Stay Running
(Posted by EssTss4 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)