Troy-Bilt TB320 Support Question
Troy-Bilt TB320 Support Question
Find answers below for this question about Troy-Bilt TB320.Need a Troy-Bilt TB320 manual? We have 1 online manual for this item!
Question posted by Msoops on August 12th, 2022
What Is The Gap For The Tb320?
what is the spark plug gap for tb330
Current Answers
Related Troy-Bilt TB320 Manual Pages
Operation Manual - Page 1
... In USA
TROY-BILT LLC, P.O. Safe Operation Practices • Set-Up • Operation • Maintenance • Service • Troubleshooting • Warranty
Operator's Manual
Self Propelled Mower -
Operation Manual - Page 2
... first contacting the Customer Support Department. Please read this Operator's Manual may not be applicable to establish the power rating of product specifications for purchasing a Lawn Mower manufactured by standing at the operator's position and looking down at all references to right and left side of printing.
All information in this manual...
Operation Manual - Page 3
... the controls and the proper use it is capable of this 9. HEED ITS WARNING!
General Operation
6.
1.
Therefore, exercise extreme caution at least 75 feet from mower
to operate this machine before
attempting to cause cancer and reproductive harm. Do not use of amputating fingers, hands, toes and feet and throwing objects...
Operation Manual - Page 4
... can result in severe injury.
Repeat these steps:
a. The blade control must back the mower away from mower to slip or trip. If you feel uneasy on slopes requires extra caution. Mow only ...
Always be trained and supervised by slipping or tripping.
Children are often attracted to the mower if you feel you are losing your footing or balance.
2. Use extreme care when ...
Operation Manual - Page 5
...!"
10. Never store the machine or fuel container near an open device.
6.
Disconnect the spark plug wire and ground against the engine. Also, visually inspect blade for damage (e.g., bent, cracked,...securely.
11. Clean up . Allow machine to provide for any way. General Service:
1. Mower blades are subject to wear and damage which do not modify engine in contact with original ...
Operation Manual - Page 6
... may include the following emission control systems: Engine Modification (EM), Oxidizing Catalyst (OC), Secondary Air Injection (SAI) and Three Way Catalyst (TWC) if so equipped. A spark arrestor for SORE (Small Off Road Equipment) are certified to comply with California and federal EPA emission regulations for the muffler is available through your...
Operation Manual - Page 8
Locate a vertical object on slopes in severe injury or death. Align either side of slopes, never up or down slopes. If there is a gap below the gauge, the slope is too steep for safe operation (See Figure 2 above). To check the slope, proceed as follows: 1. a pole, building, fence, tree, ...
Operation Manual - Page 9
Assembly & Set-Up
3
Contents of Carton
• One Lawn Mower
•
• One Lawn Mower Operator's Manual •
One Grass Catcher One Engine Operator's Manual... This unit is shipped without gasoline or oil in the accompanying engine manual BEFORE operating your mower. While stabilizing mower so it doesn't move, pivot upper handle up with gasoline and oil as instructed in the...
Operation Manual - Page 11
... attach grass catcher:
a. Follow steps below to close rear opening of mower. b. Figure 3-9
2. Do not remove side mulching plug at the bottom. a. Slip plastic channel of discharge door so that...black plastic side is turned right side out before assembling (warning label will be on the mower.
Side Mulching Plug
1
2
Figure 3-7
2. Grass Catcher
1. Place bag over hooks on the frame. To...
Operation Manual - Page 12
... ignition.
Loosen
Figure 3-12
Set-Up
Gas and Oil Fill-Up
Refer to adjust the drive control if the mower does not propel itself with the drive control engaged or if the mower's wheels hesitate with the drive control engaged. Gasoline is hot or running. You will need to the separate engine...
Operation Manual - Page 13
...Release it against the upper handle to engage the drive;
Your mower's deck is equipped with a water port on top of the mower.
WARNING: Keep hands and feet away from the chute area ...is used to engage the drive. Depress and squeeze it to stop mower from the deck's underside. Drive Control
Side Discharge Chute
Your mower is a safety device. To discharge the grass clippings to the ...
Operation Manual - Page 14
... engine. Using Your Lawn Mower
Be sure lawn is clear of four inches, mulching is standing near the lawn mower while starting engine or operating mower. For effective mulching, do not cut wet grass. Keeping a firm grip on engine and lawn mower.
Keep hands, feet, hair and loose clothing away from the spark plug, thoroughly inspect mower for the blade to...
Operation Manual - Page 15
...the factory and does not require lubrication.
3.
Lubrication
1. This control must maintain the lawn mower as instructed here.
• Changing of plastic under the gas cap earlier, make... operator abuse or negligence. Tip mower so that have been subjected to prevent build-up . Disconnect spark plug wire. WARNING: Always stop engine, disconnect spark plug, and ground against engine before ...
Operation Manual - Page 16
...instructed in fuel system or on your lawn, near enough for a minimum of two minutes, allowing the underside of your deck, restart the mower. Keep the top of the cutting deck...mower is given below. Engine Care
A list of key engine maintenance jobs required for a minimum of two minutes, allowing the underside of the engine clean to the engine manual.
• Clean spark plug and reset the gap...
Operation Manual - Page 17
... are facing up.
2. Remove metal from spark plug. Place the blade on a round shaft screwdriver to the engine crankshaft.
Replace when necessary. Replace hex bolt and tighten hex bolt to mower and could break
Figure 7-2
causing personal injury.
• Store mower in the lubrication instructions.
• Coat mower's cutting blade with chassis grease to prevent...
Operation Manual - Page 18
... loose. 2. Dirty air cleaner. 6. Air flow restricted. 1. Wait a few minutes to engine manual. 1. Clean fuel line; Spark plug fouled, faulty, or gap too wide. 2. See an authorized service dealer. Continued on top of engine. 1. Spark plug boot disconnected. 3. Engine flooded.
8. See engine manual. 9. fill tank with primer).
5. Clean area around and on next page 18...
Operation Manual - Page 19
... and replace belt.
4. Dull blade. 1.
Do not mow when grass is wet; Stop engine, disconnect spark plug boot, and clean out debris.
3. Troubleshooting
19 Wheels not positioned correctly.
2. Drive control out of adjustment. wait until later to cut Mower will not mulch grass
Cause
1. Sharpen or replace blade.
1. Section 8 - Belt not installed properly...
Operation Manual - Page 20
Parts Manual downloads are also available free of charge at www.troybilt.com
20 Replacement Parts
Component
9
Part Number and Description
BS-591868
Spark Plug
BS-491588S BS-493537S
Air Filter Cartridge Pre-Cleaner
BS-799585 BS-796577
Fuel Tank Cap Fuel Tank Cap
634-04660 634-05042
Wheel (Front) ...
Operation Manual - Page 21
...sharpening blade and cleaning underside of deck. Simple installation. Keeps mower stable for separate blower. Fits ¾" or 13⁄16" hex plug.
490-850-0008 Oil Siphon - Attaches in place for ... than two minutes with no tools.
490-241-0034
Garage Floor Mat - SPW-134
Spark Plug Wrench - Easy installation with no tools.
490-850-0015
Cargo Carrier - Attachments & ...
Operation Manual - Page 22
... mowing deck.
22
Section 10 - Component
Model Number and Description
22216
STA-BIL® fuel Stabilizer, 32 oz - Prevents gum and varnish.
490-290-0012
Mower Cover - Long-Lasting anti-stick graphite spray. Treats 80 gallons of fuel. U.V. Attachments & Accessories Keeps stored fuel fresh for maximum water resistance and repellency. Coated...
Similar Questions
Oil & Spark Plug
How much oil needed for tb554 edger?What type spark plug does it take?
How much oil needed for tb554 edger?What type spark plug does it take?
(Posted by Ggramkow 1 year ago)
Need New Motor Engine For Troy Bitl Riding Lawn Mower 15.5
(Posted by janicesutton60 2 years ago)
Why Would A Troy Built Mower Pop And Emit Black Smoke?
(Posted by Lbaily7755 3 years ago)
I've Replaced The Spark Plug With New One Of The Same Specs. Gapped It At .030'
cleared out slightly dirty air filter and new tank of gas, yet it still will not start! Oil is clear...
cleared out slightly dirty air filter and new tank of gas, yet it still will not start! Oil is clear...
(Posted by gooman810 6 years ago)
Spark Plug Oil/fuel Ratio?
What is the spark plug gap for my TB22ec weed eater?Also the oil/fuel ratio?
What is the spark plug gap for my TB22ec weed eater?Also the oil/fuel ratio?
(Posted by rondaniels609 6 years ago)