Troy-Bilt TB625 Support Question
Troy-Bilt TB625 Support Question
Find answers below for this question about Troy-Bilt TB625.Need a Troy-Bilt TB625 manual? We have 1 online manual for this item!
Question posted by floresluisg68 on May 12th, 2021
Where Can I Find The Service Repair Manual For Tb625 Ec
I need to work in the engine and need engine specs thanks
Current Answers
Answer #1: Posted by Troubleshooter101 on May 12th, 2021 4:31 AM
Troubleshooter101
Member since:
September 30th, 2015 Points: 2,927,030
Member since:
September 30th, 2015 Points: 2,927,030
The only manual available for this product :-
https://www.manualslib.com/products/Troy-Bild-Tb625-Ec-4069729.html
https://www.manualslib.com/manual/591413/Troy-Bilt-Tb625.html
Thanks
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!
Troublshooter101
Related Troy-Bilt TB625 Manual Pages
Operation Manual - Page 1
... SOUTHWEST INC, All Rights Reserved.
01/13 Additional information about the unit can be performed by an authorized and approved service dealer. Operator's Manual
Electric Start Capable 4-Cycle Trimmer
TB625 EC
TABLE OF CONTENTS Service 1 Safety 2 Know Your Unit 5 Specifications 5 Assembly 6 Oil and Fuel 8 Starting and Stopping 10 Operation 12 Maintenance 13 Cleaning and Storage...
Operation Manual - Page 2
... prevention measures. Make sure all adjustments or repairs before starting the unit. Never use the ... this unit only in effective working order, or the engine be equipped with the unit...with your attention to the State of this manual. Take the following precautions:
• Store...symbols, and their explanations, deserve your LOCAL SERVICE DEALER to others . SYMBOL MEANING
DANGER:...
Operation Manual - Page 3
...engine is dusty.
• Wear heavy long pants, boots, gloves and a long sleeve shirt. Take extra care when working...8226; All service, other than the speed needed to do...plug for maintenance or repair.
• Use ...Keep the engine and muffler free from your authorized service dealer. ...engine to off .
• Do not operate the unit faster than the maintenance procedures described in this manual...
Operation Manual - Page 4
... likely damage this engine and void the warranty. May be propelled at least 50 feet (15 m) from the rotating rotor.
• KEEP BYSTANDERS AWAY
WARNING: Keep all warnings and safety instructions. Failure to operator's manual for complete safety, assembly, operating and maintenance and repair information. Use a full face shield when needed.
• UNLEADED FUEL...
Operation Manual - Page 5
...
Fuel Cap
Handle Shaft Housing
Air Filter Cover
Throttle Control
Choke Lever
Cutting Head
Coupler
Cutting Head Shield
Oil Fill Plug
Line Cutting Blade
SPECIFICATIONS*
Engine Type Air-Cooled, 4-Cycle Displacement 30 cc (1.83 cu. KNOW YOUR UNIT
APPLICATIONS
As a trimmer: • Cutting grass and light weeds. • Edging • Decorative...
Operation Manual - Page 7
... make installing or removing the attachment easier, place the unit on the ground or on a work bench.
Turn the knob counterclockwise to loosen (Fig. 4). 2.
Turn the knob counterclockwise to ...
Lower Shaft Housing
Fig. 6
7 WARNING: Before using any attachment, read and
understand the manual that came with the attachment. WARNING: To avoid serious personal injury and
damage to assembling the...
Operation Manual - Page 8
...Maintenance Schedule. NOTE: This unit was shipped without oil in place on a flat, level surface. 4.
cycle engine. NOTE: This unit comes with gasoline. 6. Remove the cap from the oil bottle. DO NOT
overfill.... 8
8 Use the bottle to measure the
correct amount of the correct type can cause premature engine wear and failure. OIL AND FUEL
USING THE RIGHT OIL
Use a high-quality SAE 30 weight ...
Operation Manual - Page 9
... fuel can make fuel and oil separate, forming acids when stored. Do not start the engine until fuel vapors dissipate.
1. Place the fuel container spout into the fill hole on the... problems. Use only fresh, clean unleaded gasoline. NEVER add fuel additives directly to cool before starting the engine.
9 Reinstall the fuel cap. 6. Do not smoke while filling the tank. Using Blended Fuels If using...
Operation Manual - Page 10
... primer bulb 10 times (Fig. 10).
4. Continue to Position 3 (Fig. 11) and continue warming the engine for 2-5 minutes, or as needed . the engine does not start the engine.
9. IF THE UNIT WAS RUN FOR 10-15 MINUTES AND THE ENGINE IS HOT... Run the unit for an additional 60 seconds. NOTE: There is in a confined...
Operation Manual - Page 11
... control. Squeeze and hold the throttle control, move the choke lever to Position 2, and run the unit for 2-5 minutes, or as needed .
Run the electric start accessory operator's manual. The engine should start port (Fig. 13). The unit may be used during this instruction.
Insert the electric start accessory into the electric start...
Operation Manual - Page 12
... it easily
contacts the grass without stopping the engine. This improves the unit's
cutting efficiency and throws clippings away from the cutting head without the need for bending over. NOTE: Do not rest...be released from the operator. • Do not trim wet grass or weeds. This may stall the engine.
For best results, tap the bump knob on the ground (Fig. 15) while operating the unit...
Operation Manual - Page 13
... unit to Maintaining the Air Filter.
• Change the oil. Refer to cool before servicing or repairing the unit.
Push
the line through the cutting head until the ends are unsure about 5... length. 5. NOTE: Maintenance, replacement, or repair of the emission control devices and system may be a part of trimming line may cause the engine to prevent the unit from each side of terms...
Operation Manual - Page 14
...NOT overfill the crankcase. 4. NOTE: Make sure the O-ring is approximately
halfway up any oil that the engine is too low, add oil. Firmly press in place on the cutting head (Fig. 19). 2. The... level (Fig. 20).
Check the oil level before each use a flashlight if necessary. Stop the engine and allow it to overfill. 3. Add oil to prevent debris
from the cutting head. 1. Refer...
Operation Manual - Page 15
... up any oil that may have spilled. 5. NOTE: Make sure the O-ring is still warm. Engine failure due to federal, state and local
regulations. 4.
Remove the air filter cover from the air ...Fig. 24). MAINTAINING THE AIR FILTER
WARNING: To avoid serious personal injury, always stop
the engine and allow it to the right. Unscrew the cover screw completely. Reinstall the oil fill plug...
Operation Manual - Page 16
.... Tighten the spark plug with a 5/8-inch socket, turning it with a 5/8-inch socket, turning counterclockwise.
Use a feeler gauge to a qualified service dealer: • the engine will not idle, adjust the idle speed screw as needed ) to Starting and Stopping. 2.
Idle Speed Screw Fig. 25
0.025 in . (0.635 mm) (Fig. 26).
5. Release the throttle control...
Operation Manual - Page 17
...regulations.
17 Long-term Storage
1. Thoroughly clean the unit and inspect it for any moisture with the engine at the top.
Store the unit in a dry, well-ventilated area. • Store the unit... AND STORAGE
CLEANING
WARNING: To avoid serious personal injury, always stop
the engine and allow it to cool. Repair or replace damaged parts and tighten loose screws, nuts or bolts. Household ...
Operation Manual - Page 18
...The fuel is old (over 30 days) The spark plug is fouled
The engine is required, contact an authorized service dealer.
18 PROBLEM THE ENGINE WILL NOT START The fuel tank is empty The primer bulb was not pressed... tank and add fresh fuel Clean or replace the air filter Replace the spark plug
Stop the engine and clean the cutting head Refill the cutting head with new line Rewind the line Clean the...
Operation Manual - Page 20
...in accordance with the Operator's Manual furnished with respect to misuse, abuse, commercial use the product. HOW TO OBTAIN SERVICE: Warranty service is repair or replacement of export distribution. ... any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related expenses, or for rental expenses to temporarily...
Similar Questions
Troy Bilt Horse Iii I Need A Repair And Overhaul Manual.
I need repair manual for a Troy Bilt Horse III with PTO lever and separate tiller attachment.
I need repair manual for a Troy Bilt Horse III with PTO lever and separate tiller attachment.
(Posted by krauscarl 2 years ago)
How Do I Replace The Primer Bulb On Tb625 Ec
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
(Posted by Myers8708 2 years ago)
Clutch Cable
Clutch cable was not hooked up, and there is no reference to it in the manual. I assume it was suppo...
Clutch cable was not hooked up, and there is no reference to it in the manual. I assume it was suppo...
(Posted by davejbolin 7 years ago)
Fuel Tank Replacement On A Tb625 Ec
How do I replace the fuel tank on this model
How do I replace the fuel tank on this model
(Posted by axisbuck8point 8 years ago)
How Do I Remove The Cutting Head Of The Tb625 Ec Trimmer
head removal instructions.
head removal instructions.
(Posted by Anonymous-150877 9 years ago)