Xerox 6250DT Support Question
Xerox 6250DT Support Question
Find answers below for this question about Xerox 6250DT - Phaser Color Laser Printer.Need a Xerox 6250DT manual? We have 1 online manual for this item!
Question posted by KatelynPope on January 21st, 2013
How Do I Access The V Rack? Imaging Unit Not Recognized
I replaced the imaging unit because it was near 'enf of life'. Now the printer will not recognize the new imaging unit. From the research Ive done, it sounds like all I need to do is reset the V Rack??? Can you tell me how to access this, and what the proper steps are?
Thanks!
Kate
Current Answers
Related Xerox 6250DT Manual Pages
Service Manual - Page 33
... Kit*
* No life tracking for this item
Print Life
8,000 4,000
30,000 100,000 15,000 up to display the near end-of-life and end-of-use messages. Consumable Life Counter Behavior
Internal counters track Consumables and Routine Maintenance Items life usage and store the values in order to 100,000
1-10
Phaser 6250 Color Laser Printer Service Manual
Service Manual - Page 41
... on the drum as it rotates. The negatively charged toner image on the drum. Overview of the Phaser 6250 Color Laser Printer Theory of Operation
Summary of the Printing Process
The Phaser 6250 Color Laser Printer is a 'full-color laser printer', that between the magnet roller and the toner particles. Exposure: The laser unit emits laser beams in contact with the drum surface to provide...
Service Manual - Page 45
... correction and control over the entire printing process is executed during continuous printing.
2-6
Phaser 6250 Color Laser Printer Service Manual Bias Control
To attain stable image density, toner density is transmitted to the monitored results for each color. Image data is monitored for each color and the drum charging voltage and biasing DC voltages are adjusted according to the...
Service Manual - Page 55
... Feeder ■ Retard Housing Assembly ■ Chute Assembly, Out (MPT position) ■ Chute Assembly, Registration ■ Imaging Unit (IDT 1, IDT 2, Drum) ■ Transfer Roller
2-16
Phaser 6250 Color Laser Printer Service Manual Frame and Drive Assemblies
1
2
6250-064
1.
Developer Drive Assembly: Supplies the drive to the following section details all major components of the...
Service Manual - Page 57
... the location of the various components specified in the Transmission Route Block Diagram on the preceding page.
6
7
5
4
3
2 1
FRONT
16 15 14
13
8 9
10
11 12
6250-052
1. Turn Clutch
2-18
Phaser 6250 Color Laser Printer Service Manual Gear Layout - Retard Housing 2. Imaging Unit 8. Gear Feed 1 12. Gear Idler 15.
Service Manual - Page 75
IDT1 Refresher/Cleaner 7. IDT2 Refresher/Cleaner 5. Drum Ground Contacts
6250-072
2-36
Phaser 6250 Color Laser Printer Service Manual Drum Refresher/Cleaner 8. IDT1 Voltage 6. IDT2 Voltage 4. Developer Voltage 3. Imaging Unit Charge Voltage Contacts
1 2 3
4 5 6
78
1. Charge Voltage 2.
Service Manual - Page 77
... the Engine Control Board.
2-38
Phaser 6250 Color Laser Printer Service Manual Sub-High Voltage Power Supply Board: Supplies high-voltage to the Transfer Roller and the Detack Saw for each auger tube.
6. Low Toner Sensor [Y] [M] [C] [K]: Detects level of the printing process.
2. Circuit Board, EEPROM: Consumable use (Fuser and Imaging Unit NVRAM Data) information is stored and...
Service Manual - Page 79
Toner Motor Drive Assembly - Transmission Route
Toner Motor Gear Auger
Auger
Gear
Film TONER CARTRIDGE HOLDER ASSY
Agitator
TONER CARTRIDGE
6250-051
Developer Assembly Transmission Route
DEVELOPER DRIVE ASSY
Developer (Y)
Developer (M)
Developer (C)
Developer (K)
IMAGING UNIT
6250-048
2-40
Phaser 6250 Color Laser Printer Service Manual
Service Manual - Page 83
...the bottom of three ways:
Accessing Fault History
1. Print (if possible) the Printer Status Page from the printer's front panel Troubleshooting Menu --> Service Tools.
3-2
Phaser 6250 Color Laser Printer Service Manual If the printer is operating correctly. Enter the printer's IP address as start up and power on, media, paper path, printquality or image problems, and electrical failures...
Service Manual - Page 89
... the following values:
PostScript NVRAM Reset MCU NVRAM Store/ Restore Toner Install Dates Toner CRUM Check CRU Life Reset CRU Life Read
IP Controller Diagnostics Tests the...3-8
Phaser 6250 Color Laser Printer Service Manual
Clean Imaging Unit IDT Rollers
NVRAM Access This menu lets you read, set, or reset the following print engine status. Diagnostic Menu Map
Phaser® 6250 Service ...
Service Manual - Page 97
... RR/154
Jam History Code
1 2 3 4 5 6 7
Phaser 6250 Color Laser Printer Service Manual
RAM Read/ Write Test
Executing.....
The second field indicates the page count when the jam occurred. IP Controller Diagnostics - CRU Life Restore
Restore Engine NAVRAM
Used after Engine Control Board replacement to restore the previously saved life values to the printer after executing this test...
Service Manual - Page 99
...
Laser Failure Density Sensor Failure or Low Density Failure Fuser Failure
Fuser Fan Failure Rear Fan Failure Generic Fan Failure Engine Firmware Failure
Imaging Unit Firmware Failure Fuser Firmware Failure Controller to Engine Communications Failure Engine NVRAM Failure [Y] [M] [C] [K] Toner Cartridge Failure Replace [Y] [M] [C] [K] Toner Cartridge
Non-Phaser 6250 Fuser Non-Xerox Imaging Unit...
Service Manual - Page 117
... the Top Imaging
Unit Cover Acutator I /R on page 10-18
Troubleshooting Procedure Table
Steps Actions and Questions
Yes
No
1
Check the following for evidence of obstructions and fully closed. ■ Verify that the interlock switch tab actuator is 0 Control Board,
Driver Board,
VDC. Close the Front Cover during the check.
3-36
Phaser 6250 Color Laser Printer Service...
Service Manual - Page 119
... Unit is Near End of Life
■ Print the Supplies Usage page and verify life remaining and date Imaging Unit was installed.
■ Cycle printer power. ■ If the problem persists, follow the procedure below
Note The "Imaging Unit is Near End of Replace the parts Go to Step. 5. Does the error recur? Replace EEPROM Harness Assembly, PL 13.1.10.
3-38
Phaser 6250 Color Laser Printer...
Service Manual - Page 153
... imaging unit from exposure to Step 3.
Go to Step 7. Check the Gear Slide and the Rack V for continuity. proper position. With Door C open,
push the Rack V up
as far as it can occur Go to Step 9. Harness for if the Gear and
damage or misalignment. Complete
3-72
Phaser 6250 Color Laser Printer Service Manual
Replace the parts concerned. replaced?
Gear and Rack...
Service Manual - Page 163
...
4-2
Phaser 6250 Color Laser Printer Service Manual...Image Processor board allows selection of various power-up , Power On Self Test (POST), and power supply operations of ground pins (G) 1 or 6. The first page includes general information about the printer including firmware versions, page count, feature set, and consumables installation dates and remaining life. This page also provides color...
Service Manual - Page 169
...
Realign Rack V, see page 5-9. 3. Front Panel Continually Displays "Warming Up..."
1. Replace the Front Panel wiring harness page 8-6. 6. Remove and reseat the Image Processor Board page 8-110. 2. See "Install or Reseat Imaging Unit" on page 4-9.
Run the Print Engine Test Print, see "Toner Cartridge Holder Unit Assembly (PL 10.1)" on
page 8-77
4-8
Phaser 6250 Color Laser Printer...
Service Manual - Page 183
... page 9-51 for media that has been tested and approved for use in the Phaser 6250 printer. The Phaser 6250 printer uses an Imaging Unit that contains all the imaging drums and developers for all four colors in one color are usually attributable to the Imaging Unit. Defects occurring in only one Routine Maintenance Item. To successfully troubleshoot print-quality problems, as many...
Service Manual - Page 191
... Troubleshooting
Light Prints
Initial Actions:
■ Verify the printer is not in Draft mode.
■ Verify the media used is replaced, PL 8.1.1
No
Go to Step 7.
Does the image quality improve if the Complete. Go to using this printer. Replace the Engine Control Board, page 8-107.
5-10
Phaser 6250 Color Laser Printer Service Manual lists correct media types, sizes, and...
Service Manual - Page 193
... the Housing Assembly Bias page 8-69.
Replace the Engine Control Board, page 8-107.
5-12
Phaser 6250 Color Laser Printer Service Manual
Does the image quality improve if the Laser Unit is replaced? J 601DEVE Y contact J 602DEVE M contact J 603DEVE C contact J 604DEVE K contact
Go to Step 6. Troubleshooting Procedure
Step 5
6
Check
Yes
Check the following pins between the Engine...
Similar Questions
How To Clean Phaser 6130 Imaging Unit
(Posted by mikeROwe 9 years ago)
Can You Manually Set Ip Address On Xerox Phaser 3250 Dn Printer
(Posted by juaryan 9 years ago)
How To Install Imaging Unit Xerox Phaser 6360 Printer
(Posted by miflo 9 years ago)
How To Install Imaging Unit In Phaser 6360
(Posted by RondaHurr 10 years ago)
Xerox Phaser 6250
It turns on fine with no errors. When I try to print or even do a self test it just puts out a blank...
It turns on fine with no errors. When I try to print or even do a self test it just puts out a blank...
(Posted by allennegrini 11 years ago)