Yamaha EF3000iSE Support Question
Yamaha EF3000iSE Support Question
Find answers below for this question about Yamaha EF3000iSE - Inverter Generator - 3000 Maximum AC Output.Need a Yamaha EF3000iSE manual? We have 1 online manual for this item!
Question posted by fyrfytr52022 on April 29th, 2013
Battery Connect
Each time I replace the battery in my EF3000iSEB, I experience a spark. I connect according to the manual.
Thanks
Current Answers
Related Yamaha EF3000iSE Manual Pages
Owners Manual - Page 1
OWNER'S MANUAL
Generator
EF3000iSE EF3000iSEB
LIT-19626-01-20
7CH-28199-10
Owners Manual - Page 5
... 15 STARTING THE ENGINE 15 APPLICATION RANGE 17 CONNECTION 18 STOPPING THE ENGINE 22
PERIODIC MAINTENANCE 23 MAINTENANCE CHART 23 SPARK PLUG INSPECTION 25 CARBURETOR ADJUSTMENT.........25 ENGINE OIL REPLACEMENT ..........26 MUFFLER SCREEN AND SPARK ARRESTER 27 AIR FILTER 28 FUEL TANK FILTER 29 BATTERY 30 FUSE REPLACEMENT 31
TROUBLESHOOTING 32 STORAGE 34
DRAIN THE FUEL...
Owners Manual - Page 9
...UNIT DRY AT ALL TIMES.
8 LISEZ LE MODE... REFUELING. 8 DO NOT OPERATE NEAR FLAMMABLE MATERIALS. 8 ELECTROCUTION CAN OCCUR IF GENERATOR IS USED IN RAIN,
SNOW, OR NEAR WATER.
YAMAHA MOTOR CO. EMISSIONS ...
q AVERTISSEMENT
8 READ THE OWNER'S MANUAL AND ALL LABELS BEFORE OPERATING. 8 ...
HOT EXHAUST
***-28176-**
2
OIL
zzzzzz
AC output Rated
Phase DC output Fuel
zzHz zzzKVA zzzV Single zzV zzA...
Owners Manual - Page 12
... repair. nance personnel. Ground (earth) Lead Diameter:
0.12 mm (0.005 in)/ampere EX;
10 Ampere → 1.2 mm (0.05 in)
AE00088
1
CONNECTION NOTES
9 Avoid connecting the generator to commercial
power outlet.
9 Avoid connecting the generator in the build- AE00086
EXTENSION CORD NOTES 9 When using an extension cord, its total length should not exceed 60...
Owners Manual - Page 13
...-107c
AE00102
DESCRIPTION 1 Recoil starter 2 Oil filler cap 3 Oil drain plug 4 Battery box/Battery 5 Carrying handles (shaded) 6 Muffler 7 Fuel tank cap
ty
u
t
793-108c
AE00103
CONTROL PANEL 1 Engine switch 2 Economy control switch 3 DC receptacle 4 AC receptacle 5 Ground (Earth) terminal 6 Overload indicator light 7 AC pilot light 8 DC protector 9 Oil warning light 0 Choke knob q Fuel cock...
Owners Manual - Page 15
...min (3,800 r/min) regardless of whether there is a load connected or not. If it turns off .
NOTE:
The economy ...generator rated output if the DC protector turns off again, consult a Yamaha dealer. NOTE: Press to reset the DC protector.
763-238a
1 I "ON"
When the economy control switch is turned "ON", the
economy control unit controls the engine speed
w
according to the connected...
Owners Manual - Page 18
....
6.
Turn the engine switch to the "STOP" position to remove the battery 6. 4.
Connect the positive lead 1 to the positive battery
terminal 2, then the negative lead 3 to the same negative terminal.
- 13 - Do not reverse these positions.
9 For EF3000iSEB, tighten the two positive battery leads (one from the starter relay and one from the DC-DC...
Owners Manual - Page 20
... to start .
1 Upper level
AE01073
STARTING THE ENGINE
NOTE: 9 Before starting the engine, do not connect any electric devices. 9 Turn the economy control switch to the "ON" position.
q
700-006a
761-080
AE00955
OPERATION
NOTE: The generator has been shipped without engine oil. ON
1 "ON"
OFF
705-073
2. Turn the engine switch...
Owners Manual - Page 22
...uniform voltage supply than portable generators provide. EX:
Generator rated output
Frequency
Power factor
1.0 AC
0.8
DC
-
2,800VA
-2,650W -2,100W
144W (12V/12A)
9 The overload indicator light 1 comes on any portable generator to provide power to such equipment.
- 17 - AE01000
APPLICATION RANGE
AC
DC
Power factor
EF3000iSE EF3000iSEB
1
0.8-0.95
0.4-0.75 (Efficiency 0.85)
-2,800W...
Owners Manual - Page 23
... sure the total load is within generator rated
output.
761-081
9 Be sure the receptacle load current is on any electric devices are turned off
before connection to the generator.
9 Be sure any electric devices. Make sure the AC pilot light is within
receptacle rated current.
1. AE01023
CONNECTION
Alternating Current (AC)
cC
9 Be sure all electric devices...
Owners Manual - Page 24
... go off any blockages are found, remove. 4. Reduce the total wattage of a connected electrical device is flashing, electric devices that require a large starting current, such as follows: 1. NOTE:
9 The generator AC output automatically resets when the engine is not a malfunction.
9 For EF3000iSEB, the overload indicator light may come on , but the engine will then activate...
Owners Manual - Page 25
...or obstructed.
9 Reduce the load to the negative (-) terminal of the
battery. Start the engine. 3. Wind the battery charging lead (furnished as an accessory) 2 or 3 turns around the...Press in the DC protector and install the battery. 2
1
AE00825
Battery Charging
NOTE: The generator DC rated voltage is 12V.
1. NOTE:
9 Make connections to the battery after starting the
engine.
761-081a
9...
Owners Manual - Page 26
..., beaten egg or vegetable oil. EYES: Flush with water. Always cover eyes when working near batteries. Follow with skin, eyes or clothing. Sparks may ignite the battery gas. Batteries produce explosive gases. w
Never smoke or make and break connections at the battery while charging. KEEP OUT OF REACH OF CHILDREN.
762-012
- 21 - Antidote: EXTERNAL-Flush...
Owners Manual - Page 35
... milk of water or milk.
AE01085
BATTERY This generator is required. Using a conventional battery charger will damage the battery. Always cover eyes when working near batteries. Follow with water for 15 minutes and get prompt medical attention. Batteries produce explosive gases. To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it seems...
Owners Manual - Page 36
...
Be sure the engine switch is turned to "STOP" to use specified fuse. "BATTERY".)
2. Replace the blown fuse with one of proper amperage.
A wrong fuse will cause electrical system damage and A FIRE HAZARD. Remove the side cover 1 and the battery box 2. (See page 30; Specified fuse: 10 A
NOTE: If the fuse immediately blows...
Owners Manual - Page 37
... Damaged gasket .... Replace gasket. AE00785
Generator won 't start
1. Clean fuel line. 2 Clogged carburetor .... Poor spark 2 Spark plug dirty with ...AC) to "ON". Fuel cock knob to combustion chamber.
707-100
2 No fuel in tank ....
Supply fuel.
2 Fuel in tank .... Clean carburetor.
705-073b
2.
Compression Insufficient
2 Worn out piston and cylinder .... bon or wipe spark...
Owners Manual - Page 40
... positive lead from the battery.
9 Connect the positive lead first, then the negative lead to the negative (-) terminal of the battery. Remove the battery. 2.
cC
9 Do not disconnect the battery during engine operation.
9 Avoid operating the generator with the battery removed.
Do not reverse these positions. 9 Be sure the battery is installed on the battery box.
- 35 - AE01057
RECOMMENDED...
Owners Manual - Page 42
AE00707
GENERATOR
Unit
AC Output
Rated Voltage
V
Rated frequency
Hz
Rated current
A
Rated Output
kVA
Safty Device: Type
DC Output
Rated voltage
V
Rated current
A
Safety Device: Type
EF3000iSE
EF3000iSEB
120 60 23.3 2.8 Electronic
12 12 DC protector
- 37 -
AE00701
AE00702
DIMENSIONS
Overall Length Overall Width Overall Height Dry Weight
SPECIFICATIONS
Unit mm (in) mm (...
Owners Manual - Page 43
unit i Spark plug o T.C.I . magneto
p Stepping motor a Rectifier s Battery d Starter relay f Starter motor
- 38 - AE00751
WIRING DIAGRAM EF3000iSE
q
w LO OL
e
LO OL
@0
GG
YY
R
R
L
L
O
O
!7
!8
r
O O
Y
Y
Y
Y
Y
Y
G
R... 2 Sub coil 3 DC coil 4 DC rectifier 5 Control unit 6 AC pilot light 7 AC receptacle 8 Ground (Earth) terminal 9 Economy control switch 0 Overload indicator light...
Owners Manual - Page 44
AE00751
WIRING DIAGRAM EF3000iSEB
q
w e
L
G
L
R
Br R
LO OL LO OL
r
O O
Y Y Y
GR
Br R
G
R
Y
R
O
L
OY
G
L
BW
t
... unit 6 AC pilot light 7 AC receptacle 8 Ground...Battery f Starter relay g Starter motor
Color code
B Black
Br Brown
G Green
Gy Gray
L
Blue
O Orange
R Red
W White
Y Yellow
B/W Black/White
R/W Red/White
G/Y Green/Yellow
W/L White/Blue
- 39 - unit i Spark...
Similar Questions
The 2 Capacitors Came Out, Now No 240 Volt Output Can I Replace Caps What Size A
(Posted by Natlec 2 years ago)
Location Of Battery Like To Charge It. Yamaha 3000
(Posted by Gerritdegeit 3 years ago)
120/240 Volt Ac Output
1)Does Yamaha produce and sell a device that will cause these two generators in parallel to output 1...
1)Does Yamaha produce and sell a device that will cause these two generators in parallel to output 1...
(Posted by laynerd 10 years ago)
Low Oil Shutdown
I bought a used Generator, It tested fine, Powering my AC Unit on my camper. Went camping and I "Pre...
I bought a used Generator, It tested fine, Powering my AC Unit on my camper. Went camping and I "Pre...
(Posted by tonygreenfield 11 years ago)