Yamaha EF4500iSE Support Question
Yamaha EF4500iSE Support Question
Find answers below for this question about Yamaha EF4500iSE - Inverter Generator.Need a Yamaha EF4500iSE manual? We have 1 online manual for this item!
Question posted by herrinpd on August 19th, 2015
Wont Start
I have a 4500 ise inverter I changed oil and started it up run for awhile a few days later I start it and it run a few minutes and die would not restart it ha a little to much oil so I drain some out it tried to start one time can u help me thanks phillip herrin
Current Answers
Answer #1: Posted by techfreak on August 20th, 2015 10:01 AM
techfreak
Member since:
August 15th, 2014 Points: 111,640
Member since:
August 15th, 2014 Points: 111,640
Please click here for the solution
and here is video tutorial which tolds you about a list of problems by which inverter not start please click here
Thanks
Please Do Accept If found Helpful.
Related Yamaha EF4500iSE Manual Pages
Owners Manual - Page 1
OWNER'S MANUAL
Generator
EF4500iSE
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE MACHINE. LIT-19626-01-46 7XF-28199-10
Owners Manual - Page 5
... plug inspection 23 Carburetor adjustment 24 Engine oil replacement 24 Air filter 25 Muffler screen and spark arrester.......27 Fuel tank filter 29 Battery 30 Recommended battery 30 Fuse replacement 31 STORAGE 32 Drain the fuel 32 Engine 32 Battery 33 Engine won't start 34 TROUBLESHOOTING 35 Generator won't produce power .........35 SPECIFICATIONS 37...
Owners Manual - Page 7
a 1 m (3 ft)
741-7XFg
9 Avoid operating the engine with a dust cover.
741-7XFh
1
9 Be sure to carry the generator only by its carrying handle(s).
1 Carrying handle(s) (shaded)
794-7XFa
AE00083
ELECTRIC SHOCK PREVENTION 9 Never operate the engine in rain or snow.
741-7XFi
9 Never ...
Owners Manual - Page 8
... cords should be connected to the building. ing's electrical system, a licensed electrician must
install an isolation (transfer) switch in parallel with any
other generator.
2
1 Correct
2 Incorrect
AE00091
CONNECTION
w
1 Before the generator can be protected by a tough flexible rubber sheath (IEC 245) or the equivalent to withstand mechanical stresses.
-3-
This
will prevent the...
Owners Manual - Page 9
door, and vents.
-4- NOTE: Maintain or replace safety and instruction labels, as necessary.
2 1 64
3
5
1
DANGER
Using a generator indoors CAN KILL YOU IN MINUTES. Generator exhaust contains carbon monoxide. NEVER use inside a home Only use OUTSIDE and
or garage, EVEN IF doors far away from windows,
and windows are open. ...
Owners Manual - Page 10
.... 8 ELECTROCUTION CAN OCCUR IF GENERATOR IS USED IN RAIN,
SNOW, OR NEAR WATER.
This engine conforms to Phase 2 U.S.EPA regulations for small off-road engines. ENGINE OIL: SAE10W-30 TYPE: SE
No...GARDEZ LA
MACHINE AU SEC EN TOUTES CIRCONSTANCES. 7CF-24162-10
3
HOT EXHAUST
7WL-28176-10
5
OIL
4
q CAUTION
Use the specified spark plug only. Specified plug:BPR4ES(NGK)
zzzzzz
AC output Rated
...
Owners Manual - Page 13
...) The AC pilot light 1 comes on when the engine starts and produces power.
763-7XFc
-8- Press the switch to reset the AC protector.
2
1 I "Set"
793-7XFe
2 3 "Reset"
2 1
763-238a
Hour meter
1
The hour meter 1 shows the total number of hours
the generator has been run.
763-7XFf
Power meter
1
The power meter 1 shows...
Owners Manual - Page 14
... and stop running. Check for a few seconds at first when using electric devices that require a large starting current, such as follows: 1. NOTE:
The overload indicator light may come on for blockages in order to protect the generator and any blockages are found, remove. 4. After checking, restart the engine. However, this is detected, the inverter control...
Owners Manual - Page 15
... be earthed.
1 Ground (Earth) terminal
Caster lock lever The caster lock lever stops moving the generator.
1 "Release" 2 "Lock"
- 10 - OFF With the knob in this position. Always turn the knob to the carburetor. When the... knob The fuel cock supplies fuel from the fuel tank to this position when the engine is not running. ON With the knob in this position, fuel flows to the carburetor.
Owners Manual - Page 17
Do not start the engine before filling with the sufficient engine oil.
1. Remove the oil filler cap 3.
4. Place the generator on the
areas of the recommended
3
engine oil, and then install and tighten the oil filler
700-7XFa
cap.
4 Upper level
r
700-103c
700-006
0°C
25°C
å YAMALUBE 4 (10W-30 or 10W-40)
∂ SAE...
Owners Manual - Page 20
Fuel line 9 Check fuel hose for oil leakage.
Engine oil (See page 12) 9 Check oil level in engine. 9 If necessary, add recommended oil to deteriorate quickly and unexpectedly, even if the generator unused.
The point where abnormality was recognized by use.
9 Check operation. 9 If necessary, consult a Yamaha dealer.
- 15 - Vital components can start to specified level. 9 Check...
Owners Manual - Page 21
... engine till fill with the sufficient engine oil. q ON
OFF
AE00918
Starting the engine 1. AE00846
OPERATION
w
761-7XFb
9 Never operate the engine in a well ventilated area.
9 Before starting the engine, do not connect any electric devices. cC
The generator has been shipped without engine oil.
Turn the fuel cock knob to "ON". 1
1 7 "ON"
763-127h...
Owners Manual - Page 22
q
763-120a
3. Take your hand off the switch immediately after the engine starts.
1 6 "START"
cC
If the engine fails to preserve the battery. Do not crank the engine more than 5 seconds on any one attempt.
- 17 - Each attempt should be as short as possible to start, release the switch, wait a few seconds, then try again. Turn the engine switch to "START".
Owners Manual - Page 24
...are turned off before plugging it in good condition before connection to the generator.
9 Be sure the total load is within generator rated output.
9 Be sure the receptacle load current is within receptacle rated...Turn on .
4. Make sure the AC pilot light 1 is earthed, always the generator must be earthed.
1. NOTE: Make sure to the AC receptacle.
761-7XFa
1
3. Plug in to ground (earth) ...
Owners Manual - Page 25
... equipment is voltage sensitive and may occur. Examples include some medical equipment, personal computers, and some inverters that sense peak and RMS voltage values. AC Power factor EF4500iSE
1 - 4,000W
0.8 ~ 0.95 - 3,200W
0.4 ~ 0.75 (Efficiency 0.85)
- 1,360W
1
763-7XFd
NOTE:
9 "-" means below. 9 Application wattage indicates when each device is within rated output of a generator.
Owners Manual - Page 26
...chart
w
Stop the engine before starting maintenance work , have a Yamaha dealer do it for cracks or damage. 1
Replace if necessary.
• Check oil level in the safest and ...Fuel Fuel hose
Engine oil Air filter element Muffler screen Spark arrester Fuel filter Fuel strainer
Routine
Pre-
w
If you . AE00401
PERIODIC MAINTENANCE
Safety is an obligation of generator inspection, adjustment, ...
Owners Manual - Page 35
... Capacity: 12V/18A•h
- 30 - AE00842
Battery This generator is equipped with milk of water or milk. w
Battery electrolyte... discharged. Antidote:
EXTERNAL-Flush with water for 15 minutes and get
prompt medical attention. Call physician immediately....Drink large quantities of magnesia, beaten egg or veg-
etable oil. Eyes: Flush with water. Keep sparks, flame, cigarettes...
Owners Manual - Page 37
... leave it run until it . 5. from the carburetor by loosening the
drain screw 1 on the carburetor float chamber. 4. Remove the spark plug cap and spark plug, pour
about one tablespoon of SAE 10W30 or 20W40 motor oil into an approved gasoline container using a commercially available hand siphon. Clean exterior of the generator and apply...
Owners Manual - Page 40
... be sure to "Set".
C Cranks
D Does not crank
F Turn the engine switch to "START", and check if the oil warning light comes on
L Turn the engine switch to "START".
S Clogged T OK
U Clean or Replace; N Engine starts. V Consult a Yamaha dealer.
- 35 -
AE00515
Generator won't produce power
•Safety device (AC protector) to "Reset"···...
Owners Manual - Page 42
...Generator
Unit
AC Output
Rated voltage
V
Rated frequency
Hz
Rated current
A
Rated output
kVA
Safety Device: Type
EF4500iSE
120 60 33.3 4.0 Electronic + Mechanical (By metal)
Battery
Unit
Voltage
V
Capacity
Ah
EF4500iSE...EF4500iSE
Type
Cylinder Arrangement
Displacement
cm3
Bore × Stroke Operation Hours
mm (in) Hr
Fuel
Fuel Tank Capacity L (US gal, Imp gal)
Engine Oil ...
Similar Questions
Ef4500ise Will Not Start.
Camping off the grid. Ran gen this AM from key FOB. Used FOB to shut off. Abt 2-hrs later attempted ...
Camping off the grid. Ran gen this AM from key FOB. Used FOB to shut off. Abt 2-hrs later attempted ...
(Posted by rkinginmt 10 months ago)
Prior To Changing Oil, Filter And Plug It Started And Ran No Problem. But Now
it starts for 20 seconds then shuts off???
it starts for 20 seconds then shuts off???
(Posted by mabalos 6 years ago)
My Yamaha Ef4500ise Keeps Blowing 20amp Fuse After Reversed Polarity On Battery.
After I accidentally reversed the polarity when connecting the battery to my gen it keeps blowing th...
After I accidentally reversed the polarity when connecting the battery to my gen it keeps blowing th...
(Posted by jimmymac1976 8 years ago)
I Did The Same Thing To My Generator. Did You Get It Fixed? What Did You Have
to do?
to do?
(Posted by jimmymac1976 8 years ago)