Poulan PO165H42C Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PO165H42C manuals!
Problems with Poulan PO165H42C?
Ask a Question
Free Poulan PO165H42C manuals!
Problems with Poulan PO165H42C?
Ask a Question
Popular Poulan PO165H42C Manual Pages
User Manual - Page 1
OWNER'S MANUAL
MODEL NO. PO165H42C 16.5 HP 42 Inch Lawn Tractor
For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886
178379 3.19.01 JH PRINTED IN U.S.A.
User Manual - Page 2
...Never make adjustments or repairs with safety devices. DO... check components and replace with the engine ...parts or allow children to cool before removing grass catcher or unclogging chute. • Mow only in severe injury or death. injured or interfere with the instructions...service as a water heater.
Never refuel the machine indoors. -
operate the riding mower...
User Manual - Page 3
... CONTENTS
SAFETY RULES 2-3
SERVICE AND ADJUSTMENTS 19-23
PRODUCT SPECIFICATIONS 4
STORAGE 24
CUSTOMER RESPONSIBILITIES 4, 15-18
TROUBLESHOOTING 25-26
ASSEMBLY 6-8
REPAIR PARTS - Always look behind before... CAUTION!!! They may lose control of your tractor. Use common sense when towing. SAFETY RULES
Safe Operation Practices for Ride-On Mowers
• Be sure the area is dangerous...
User Manual - Page 4
... 27-35 FT. Please read and retain this owner's manual. WARNING: This tractor is available through your nearest authorized service center/department (See REPAIR PARTS section of a new tractor. LBS. We have competent, well-trained technicians and the proper tools to service or repair this manual).
4 The instructions will enable you experience any unimproved forest-covered, brush-covered...
User Manual - Page 6
... for charging instructions). LBS TORQUE.
• Place tabs of steering boot over tab slots in extension and lower shafts and install 5/16 hex bolt and locknut. ASSEMBLY
Your new tractor has been assembled at 6-10 amps. (See "BATTERY" in this manual for minimum of one hour at the factory with exception of those parts left...
User Manual - Page 8
See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. CHECK FOR PROPER POSITION OF ALL BELTS
See the figures that all connections are still secure and wires are properly clamped.
! See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual).
8 No remaining loose parts in the Service and Adjustments section of...
User Manual - Page 13
... problems,... Instructions ...SERVICE OR REPLACEMENT, IT SHOULD BE PURGED AFTER REINSTALLATION BEFORE OPERATING THE TRACTOR.
• Place tractor...tractor. WARM WEATHER STARTING (50° F and above) • When engine starts, move fuel from the tank to separation and formation of acids during shipping of manual).
13 ADD GASOLINE
• Fill fuel tank.
Wipe off and parking brake set...
User Manual - Page 16
...instructions supplied with trailing edge up towards deck as described, repair the problem immediately. • The engine should not start unless the brake pedal is
fully depressed and attachement clutch control is in the Service and Adjustments section of this manual...heavy end until the blade is balanced. If your local parts dealer.
If blade is balanced. TIRES
• Maintain proper ...
User Manual - Page 18
...SPECIFICATIONS" section of each season. SPARK PLUGS
ENGINE COOLING FINS
SPARK PLUG
Replace spark plugs at the beginning of this manual. Spark plug type and gap setting...can result in a shortened engine life.
TO SERVICE PRE-CLEANER
• Be sure there are...tractor unless the electrical system, muffler, air filter and
KEROSENE, ARE NOT TO BE USED TO CLEAN THE CARTRIDGE. SCREWS
BLOWER...
User Manual - Page 19
... SPECIFICATIONS" section of tractor.
• Place attachment clutch in contact
with deflector shield to right
side of tractor. • Lower lift lever to its highest position.
• At the midpoint of both sides of mower should be easier to ground.
Distance "A" on both sides of mower, measure height from the right side of this manual). moving parts...
User Manual - Page 20
... all belt
guides. • Install mower in this section of this manual). • Work belt off both mandrel pulleys and idler pulleys. • Pull belt away from trunnion on both front links.
• To raise front of removal instructions. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE
MOWER" in reverse order of mower, loosen nut "F" from mower.
SERVICE AND ADJUSTMENTS...
User Manual - Page 23
... of tractor. SERVICE AND ADJUSTMENTS
KEPS NUT
HEX BOLT
POSITIVE (RED) CABLE
FIG. 29
NEGATIVE (BLACK) CABLE
TO REPLACE HEADLIGHT BULB
• Raise hood. • Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely
back into the hole in the Repair
Parts...
User Manual - Page 24
... the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- Always follow the mix ratio found on concrete or damp surfaces.
IMPORTANT: NEVER COVER TRACTOR WHILE ENGINE AND EXHAUST AREAS ARE STILL WARM.
24
placement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in fuel...
User Manual - Page 25
...of adjustment.
8. Stale or dirty fuel. 9. Dirty engine air screen/fins. 12. Engine valves out of mower housing. 4. Clean underside of adjustment.
1. Clean and regap or change oil. 6. Worn, bent or loose blade. 2. Replace blade mandrel. 3. TROUBLESHOOTING POINTS
PROBLEM
Will not start
1. Engine flooded. 4. Dirty fuel filter. 7. Engine valves out of power
1. Fill fuel...
User Manual - Page 26
...Mower drive belt worn. 9. Level mower deck. 5. Switch is "OFF". 2.
Battery will not rotate
1.
Engine throttle control not set at "SLOW" position for 30 seconds before mowing. 4. TROUBLESHOOTING POINTS
PROBLEM... servicing.
1. Check wiring and connections. 5. Replace fuse. Check/replace light switch. 4. Mower blades will not charge
1. Wet grass. 4. Replace ...
Poulan PO165H42C Reviews
We have not received any reviews for Poulan yet.