Roadside Assistance Card 1st Printing
Page 1
....5 meters) of California, Inc., Thousand Oaks, CA. The services available are: • Warranty Towing • Fuel Delivery • Non-warranty Towing • Lock-out Assistance • Collision Towing • Flat Tire Change • Battery Jump-start • Winch Out Towing services are provided by and/or through Cross Country Motor Club of a paved or county maintained road. Roadside Assistance is honored throughout the 50 states, Puerto...
....5 meters) of California, Inc., Thousand Oaks, CA. The services available are: • Warranty Towing • Fuel Delivery • Non-warranty Towing • Lock-out Assistance • Collision Towing • Flat Tire Change • Battery Jump-start • Winch Out Towing services are provided by and/or through Cross Country Motor Club of a paved or county maintained road. Roadside Assistance is honored throughout the 50 states, Puerto...
Scheduled Maintenance Guide 2nd Printing
Page 8
... lap/shoulder belts and seat latches for all interior and exterior lights. washer spray, wiper operation, and clean all hinges, latches, door check straps (see your Owner's Guide). and clean sliding door contact switches, if equipped. safety warning lamps (brake, ABS, airbag, safety belt) for wear and proper air pressure, including spare. and lubricate all wiper blades (replace blades as necessary). battery connections and clean if necessary. Refer to the specified torque at 100 miles ❑...
... lap/shoulder belts and seat latches for all interior and exterior lights. washer spray, wiper operation, and clean all hinges, latches, door check straps (see your Owner's Guide). and clean sliding door contact switches, if equipped. safety warning lamps (brake, ABS, airbag, safety belt) for wear and proper air pressure, including spare. and lubricate all wiper blades (replace blades as necessary). battery connections and clean if necessary. Refer to the specified torque at 100 miles ❑...
Scheduled Maintenance Guide 2nd Printing
Page 16
... filter ❑ Inspect automatic transmission fluid level on vehicles if equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Replace cabin air filter (if equipped) Replace climate-controlled seat filter (if equipped) Replace engine air filter Replace fuel filter (except Escape, Mariner, F-Series [non Super Duty], Expedition/Navigator [short wheel base only], E-Series and Transit Connect) Inspect steering linkage, ball joints, suspension...
... filter ❑ Inspect automatic transmission fluid level on vehicles if equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Replace cabin air filter (if equipped) Replace climate-controlled seat filter (if equipped) Replace engine air filter Replace fuel filter (except Escape, Mariner, F-Series [non Super Duty], Expedition/Navigator [short wheel base only], E-Series and Transit Connect) Inspect steering linkage, ball joints, suspension...
Scheduled Maintenance Guide 2nd Printing
Page 19
... front axle U-joints Rotate tires, inspect tires for wear and measure tread depth Inspect the wheels and related components for your dealer for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) Normal Schedule Trucks, Fullsize Vans & SUVs DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: Scheduled Maintenance 19 2010 Scheduled Maintenance Guide (smg) Scheduled Maintenance Guide, 2nd Printing USA (fus) NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 52,500 miles ❑ Change engine oil and replace oil filter ❑ Inspect cabin air filter...
... front axle U-joints Rotate tires, inspect tires for wear and measure tread depth Inspect the wheels and related components for your dealer for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) Normal Schedule Trucks, Fullsize Vans & SUVs DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: Scheduled Maintenance 19 2010 Scheduled Maintenance Guide (smg) Scheduled Maintenance Guide, 2nd Printing USA (fus) NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 52,500 miles ❑ Change engine oil and replace oil filter ❑ Inspect cabin air filter...
Scheduled Maintenance Guide 2nd Printing
Page 22
... SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter ❑ Inspect automatic transmission fluid level on vehicles if equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Consult your dealer for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: DATE: DEALER VALIDATION: P&A CODE: MILEAGE: 22 Scheduled Maintenance 2010 Scheduled Maintenance Guide...
... SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter ❑ Inspect automatic transmission fluid level on vehicles if equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Consult your dealer for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: DATE: DEALER VALIDATION: P&A CODE: MILEAGE: 22 Scheduled Maintenance 2010 Scheduled Maintenance Guide...
Scheduled Maintenance Guide 2nd Printing
Page 24
... exhaust system and heat shields Inspect accessory drive belts Inspect automatic transmission fluid level (if equipped with Zerk fittings) Torque the rear U-bolts Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Replace wheel bearing grease and grease seals on all vehicles equipped with the TorqShift transmission. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Replace...
... exhaust system and heat shields Inspect accessory drive belts Inspect automatic transmission fluid level (if equipped with Zerk fittings) Torque the rear U-bolts Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system. Replace wheel bearing grease and grease seals on all vehicles equipped with the TorqShift transmission. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Replace...
Scheduled Maintenance Guide 2nd Printing
Page 27
... abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule Trucks, Fullsize Vans & SUVs RO#: DATE: P&A CODE: MILEAGE: Scheduled Maintenance 27 2010 Scheduled Maintenance Guide (smg) Scheduled Maintenance Guide, 2nd Printing USA (fus) Change manual transmission fluid Change rear axle lubricant on 6F35). (Except vehicles equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system...
... abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule Trucks, Fullsize Vans & SUVs RO#: DATE: P&A CODE: MILEAGE: Scheduled Maintenance 27 2010 Scheduled Maintenance Guide (smg) Scheduled Maintenance Guide, 2nd Printing USA (fus) Change manual transmission fluid Change rear axle lubricant on 6F35). (Except vehicles equipped with Zerk fittings) Torque the rear U-bolts (Transit Connect only) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system...
Warranty Guide 4th Printing
Page 15
..., engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; 10 If you go to a tire service center for a repair covered by the New Vehicle Limited Warranty, you may authorize another brand and/or model to substitute for certain vehicle parts and conditions. When making warranty repairs on a pro rata adjustment basis according to the following mileage-based Reimbursement Schedule: MILES...
..., engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; 10 If you go to a tire service center for a repair covered by the New Vehicle Limited Warranty, you may authorize another brand and/or model to substitute for certain vehicle parts and conditions. When making warranty repairs on a pro rata adjustment basis according to the following mileage-based Reimbursement Schedule: MILES...
Warranty Guide 4th Printing
Page 16
...Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic front locking (four-wheel drive), locking rings (four-wheel drive), seals and gaskets, universal and constant velocity joints; Rear-Wheel Drive: axle shafts, bearings (front and rear), center support bearing, drive axle housing (including all internal parts, intake and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil pan and pump, water pump, fuel system (excluding fuel lines, fuel tank and frame mounted fuel conditioning module...
...Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic front locking (four-wheel drive), locking rings (four-wheel drive), seals and gaskets, universal and constant velocity joints; Rear-Wheel Drive: axle shafts, bearings (front and rear), center support bearing, drive axle housing (including all internal parts, intake and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil pan and pump, water pump, fuel system (excluding fuel lines, fuel tank and frame mounted fuel conditioning module...
Warranty Guide 4th Printing
Page 17
... or leased a 2010-model Expedition EL (equipped with the 17L Builder's Package) converted into the engine • misuse of the Ford Limousine Limited Warranty. WHAT IS NOT COVERED UNDER THE NEW VEHICLE LIMITED WARRANTY? injection pressure sensor, fuel rail pressure sensor (6.4L), high pressure oil regulator, exhaust back pressure regulator and sensor, exhaust pressure sensor (6.4L), manifold pressure sensor (6.4L), intake air temperature sensor (6.4L), crankshaft position sensor (6.4L), camshaft position sensor, accelerator switch. This coverage begins on the Warranty Start Date...
... or leased a 2010-model Expedition EL (equipped with the 17L Builder's Package) converted into the engine • misuse of the Ford Limousine Limited Warranty. WHAT IS NOT COVERED UNDER THE NEW VEHICLE LIMITED WARRANTY? injection pressure sensor, fuel rail pressure sensor (6.4L), high pressure oil regulator, exhaust back pressure regulator and sensor, exhaust pressure sensor (6.4L), manifold pressure sensor (6.4L), intake air temperature sensor (6.4L), crankshaft position sensor (6.4L), camshaft position sensor, accelerator switch. This coverage begins on the Warranty Start Date...
Warranty Guide 4th Printing
Page 25
... Performance Warranty. • Air Flow Sensor • Fuel Injector Supply Manifold • Air/Fuel Feedback Control • Fuel Tank (non diesel only) System and Sensors • Fuel Tank Pressure Control • Air Induction System Valve (Flex Fuel Vehicle Only) • Catalytic Converter (including • Idle Air Bypass Valve Diesel Particulate Filter and • Ignition Coil and/or Control Diesel Oxidation Catalyst) Module • Cold Start Enrichment System • Intake Manifold • Controls for Deceleration • Electronic Ignition System • Exhaust Pipe (Manifold...
... Performance Warranty. • Air Flow Sensor • Fuel Injector Supply Manifold • Air/Fuel Feedback Control • Fuel Tank (non diesel only) System and Sensors • Fuel Tank Pressure Control • Air Induction System Valve (Flex Fuel Vehicle Only) • Catalytic Converter (including • Idle Air Bypass Valve Diesel Particulate Filter and • Ignition Coil and/or Control Diesel Oxidation Catalyst) Module • Cold Start Enrichment System • Intake Manifold • Controls for Deceleration • Electronic Ignition System • Exhaust Pipe (Manifold...
Warranty Guide 4th Printing
Page 31
... • Air Induction System • Catalytic Converter (including Diesel Particulate Filter and Diesel Oxidation Catalyst) • Cold Start Enrichment System • Controls for Deceleration • Electronic Ignition System • Exhaust Pipe (Manifold to Catalyst) • Electronic Engine Control Sensors and Switches • Electronic Engine Control Unit (ECU)* • Evaporative Emission Control System • Exhaust Gas Recirculation (EGR) System • Exhaust Heat Control Valve • Exhaust Manifold • Exhaust Pipe (Manifold to Catalyst) • Fuel Filler Cap and...
... • Air Induction System • Catalytic Converter (including Diesel Particulate Filter and Diesel Oxidation Catalyst) • Cold Start Enrichment System • Controls for Deceleration • Electronic Ignition System • Exhaust Pipe (Manifold to Catalyst) • Electronic Engine Control Sensors and Switches • Electronic Engine Control Unit (ECU)* • Evaporative Emission Control System • Exhaust Gas Recirculation (EGR) System • Exhaust Heat Control Valve • Exhaust Manifold • Exhaust Pipe (Manifold to Catalyst) • Fuel Filler Cap and...
Warranty Guide 4th Printing
Page 32
... Name ABS Module Catalytic Converter Catalyst Inlet Pipe Diesel Particulate Filter Supercharger Timing Chain Tensioner Arm Cam Timing Assembly Variable Camshaft Timing Kit Variable Camshaft Timing Housing (Right-Hand) Variable Camshaft Timing Housing (Left-Hand) Variable Camshaft Timing Solenoid Camshaft Drive Assembly (Left-Hand) Camshaft Drive Assembly (Right-Hand) Crankshaft Pulley Assembly Positive Crankcase Ventilation (PCV) Valve Turbocharger Turbocharger Control Valve Turbocharger Outlet Gasket Charge Air Cooler Transmission Valve/Control Assembly Transmission Turbine Shaft Speed Sensor...
... Name ABS Module Catalytic Converter Catalyst Inlet Pipe Diesel Particulate Filter Supercharger Timing Chain Tensioner Arm Cam Timing Assembly Variable Camshaft Timing Kit Variable Camshaft Timing Housing (Right-Hand) Variable Camshaft Timing Housing (Left-Hand) Variable Camshaft Timing Solenoid Camshaft Drive Assembly (Left-Hand) Camshaft Drive Assembly (Right-Hand) Crankshaft Pulley Assembly Positive Crankcase Ventilation (PCV) Valve Turbocharger Turbocharger Control Valve Turbocharger Outlet Gasket Charge Air Cooler Transmission Valve/Control Assembly Transmission Turbine Shaft Speed Sensor...
Owner Guide 4th Printing
Page 201
... stopped for a few seconds, release the parking brake, apply the brake, shift into gear and drive. Take precautions to 3 (on the floor until the vehicle starts. Driving Starting the engine 1. Turn the key to avoid its dangerous effects. After releasing the key from the 4 (start ), then release the key as soon as the engine begins cranking. ENGINE BLOCK HEATER (IF EQUIPPED) An engine block heater warms the engine coolant which allows 201 2010 Fusion (fsn) Owners Guide, 4th Printing USA (fus)
... stopped for a few seconds, release the parking brake, apply the brake, shift into gear and drive. Take precautions to 3 (on the floor until the vehicle starts. Driving Starting the engine 1. Turn the key to avoid its dangerous effects. After releasing the key from the 4 (start ), then release the key as soon as the engine begins cranking. ENGINE BLOCK HEATER (IF EQUIPPED) An engine block heater warms the engine coolant which allows 201 2010 Fusion (fsn) Owners Guide, 4th Printing USA (fus)
Owner Guide 4th Printing
Page 214
... extended or normal driving conditions and results in R (Reverse), the vehicle will move backward. Hold the brake pedal down , the torque converter clutch locks up and aggressively shuts off fuel flow to a complete stop before shifting into the desired gear To put your foot off and remove the key whenever you take your vehicle in this position. 214 2010 Fusion (fsn) Owners Guide, 4th Printing USA (fus) N (Neutral...
... extended or normal driving conditions and results in R (Reverse), the vehicle will move backward. Hold the brake pedal down , the torque converter clutch locks up and aggressively shuts off fuel flow to a complete stop before shifting into the desired gear To put your foot off and remove the key whenever you take your vehicle in this position. 214 2010 Fusion (fsn) Owners Guide, 4th Printing USA (fus) N (Neutral...
Owner Guide 4th Printing
Page 236
... will cover: • a flat tire change with a good spare (except vehicles that have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. Trailers shall be towed to an authorized dealer more than 35 miles (56 km) from the New Vehicle Limited Warranty. If the trailer is disabled, but the towing vehicle is the customer's responsibility) • fuel delivery - Canadian customers refer to your Owner Guide portfolio. Fuel delivery service...
... will cover: • a flat tire change with a good spare (except vehicles that have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. Trailers shall be towed to an authorized dealer more than 35 miles (56 km) from the New Vehicle Limited Warranty. If the trailer is disabled, but the towing vehicle is the customer's responsibility) • fuel delivery - Canadian customers refer to your Owner Guide portfolio. Fuel delivery service...
Owner Guide 4th Printing
Page 288
... P (Park) (automatic transmission) or the neutral position (manual transmission), turn off all accessories and start the engine. 3. Allow the engine to its idle and fuel trim strategy for at least one minute. 6. This operation is swallowed, call a physician immediately. If the battery has been disconnected or a new battery has been installed, the clock and the preset radio stations must relearn its optimum shift feel. Because your eyes when working...
... P (Park) (automatic transmission) or the neutral position (manual transmission), turn off all accessories and start the engine. 3. Allow the engine to its idle and fuel trim strategy for at least one minute. 6. This operation is swallowed, call a physician immediately. If the battery has been disconnected or a new battery has been installed, the clock and the preset radio stations must relearn its optimum shift feel. Because your eyes when working...
Owner Guide 4th Printing
Page 337
...57 replacing bulbs ...62 turning on and off ...55 Heating heating and air conditioning system ...47, 50 manual heating and air conditioning system ...45 Hood ...276 I Ignition ...198, 325 Illuminated visor mirror ...73 Infant seats (see Safety seats) ...154 Inspection/maintenance (I/M) testing ...308 Instrument panel ...77 cleaning ...271 cluster ...12 lighting up panel and interior ...57 J Jack ...246 positioning ...246 storage ...246 Jump-starting your vehicle ...253 K Keyless entry system autolock ...89 keypad ...100 locking and unlocking doors ..101 programming entry code ...100 Keys ...88...
...57 replacing bulbs ...62 turning on and off ...55 Heating heating and air conditioning system ...47, 50 manual heating and air conditioning system ...45 Hood ...276 I Ignition ...198, 325 Illuminated visor mirror ...73 Infant seats (see Safety seats) ...154 Inspection/maintenance (I/M) testing ...308 Instrument panel ...77 cleaning ...271 cluster ...12 lighting up panel and interior ...57 J Jack ...246 positioning ...246 storage ...246 Jump-starting your vehicle ...253 K Keyless entry system autolock ...89 keypad ...100 locking and unlocking doors ..101 programming entry code ...100 Keys ...88...
Quick Reference Guide 2nd Printing
Page 1
... Control/ T Transmission Illuminates when a powertrain or AWD fault is turned on parking, instrument panel, license plate and tail lamps. Press again to access SYNC® phone features, if equipped. Direct Press DIRECT and then, using any device or feature that may take your Owner's Guide for a longer wash cycle. For more information. 9 Passenger Airbag Off Illuminates when the passenger airbag has been turned off , depress the brake pedal...
... Control/ T Transmission Illuminates when a powertrain or AWD fault is turned on parking, instrument panel, license plate and tail lamps. Press again to access SYNC® phone features, if equipped. Direct Press DIRECT and then, using any device or feature that may take your Owner's Guide for a longer wash cycle. For more information. 9 Passenger Airbag Off Illuminates when the passenger airbag has been turned off , depress the brake pedal...
Quick Reference Guide 2nd Printing
Page 2
... the rear portion of the spare tire cover or included with an automatic one or more information, please refer to lock or unlock the doors as well as possible. Roadside Assistance Your new Ford Fusion comes with special phone and media features. A warning tone will chirp and the turn the ignition on or off . Distributes outside or recirculated air, to heat or cool the vehicle to...
... the rear portion of the spare tire cover or included with an automatic one or more information, please refer to lock or unlock the doors as well as possible. Roadside Assistance Your new Ford Fusion comes with special phone and media features. A warning tone will chirp and the turn the ignition on or off . Distributes outside or recirculated air, to heat or cool the vehicle to...