2005 Polaris Magnum 330 2x4 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2005 Polaris Magnum 330 2x4 manuals!
Problems with 2005 Polaris Magnum 330 2x4?
Ask a Question
Other Models
Free 2005 Polaris Magnum 330 2x4 manuals!
Problems with 2005 Polaris Magnum 330 2x4?
Ask a Question
Other Models
Popular 2005 Polaris Magnum 330 2x4 Manual Pages
Owners Manual - Page 3
If you cannot locate this product contains chemicals known to the owner's manual on the next page.
A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm. WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800-342-3764 for assistance.
Owners Manual - Page 6
... we've ever produced. Many years of experience have gone into the engineering, design, and development of your vehicle best and is outlined in the Polaris Service Manual and should be sure to your dealership for minor maintenance, but information about major repairs is interested in the world today. We proudly produce an exciting line...
Owners Manual - Page 11
... a party other vehicles, such as motorcycles and cars. If you purchased your new ATV, your owner's manual, which includes valuable information about all warnings before operating a Polaris ATV. This vehicle handles differently than other than a Polaris dealer, you are thoroughly inspected at specific intervals.
8 Age Restrictions
This vehicle is an off-road vehicle. You were also...
Owners Manual - Page 15
...accessories, including (but not limited to) mowers, blades, tires, sprayers, or large racks, may have been made to the vehicle, that may increase the speed or power of the vehicle...warranty on the vehicle.
12 When it's safe to prevent unauthorized use the size and type of tires...proceed in this manual for carrying cargo or towing. Use only Polaris-approved accessories, and familiarize ...
Owners Manual - Page 26
... around and remount, following the procedure described in the owner's manual. When fully stopped, apply the auxiliary rear brake as well, then lock the parking brake. Never apply engine power. Never apply the auxiliary rear brake while rolling backwards. WHAT CAN HAPPEN The vehicle could overturn. If the ATV begins rolling backwards: Keep...
Owners Manual - Page 46
... a level surface, place the transmission in wet areas.
43 NOTE: If the engine is fully seated on the right side of compression during starting. Make sure the handle is cold, use of the recoil starter (1) will allow vehicle operation until repairs can be a "compression stroke" and will be made. NOTE: Every other stroke will...
Owners Manual - Page 49
... operation if the machine is at idle and high electrical load (lights, cooling fan, accessories) is this warning appears or serious engine damage could result. 3. NOTE: If the instrument cluster no longer illuminates, it's possible that the transmission switch needs repair. 2. It can, however, also indicate that a battery over voltage occurred and the instrument...
Owners Manual - Page 65
... of control or overturn and result in the owner's manual. Restart the engine with the brake, until it down the hill! OPERATION
Driving Safely
Turning Around on a Hill
WARNING
Improper hill climbing procedures could cause loss of the vehicle, or on the left . 5. Leave transmission in forward. 8. Use extreme caution when operating on hills...
Owners Manual - Page 66
... starting the engine.
Perform the services outlined in water. Do not make sudden turns or stops, and do not make sudden throttle changes. If your dealer at the first opportunity.
63 See page 68. If your vehicle becomes immersed or is operated in the maintenance chart. The following areas need special attention: engine oil, transmission oil...
Owners Manual - Page 72
...gearcase oil
(if equipped)
" Transmission oil " Engine breather
E filter (if equipped)
"
Perform these services.
69 replace as needed Drain...Remarks
Perform all services at whichever maintenance interval is reached first.
(whichever comes first) Hours Calendar Miles ...Service (California) J Have an authorized Polaris dealer perform these procedures more often for vehicles subjected to severe use....
Owners Manual - Page 73
... first) Hours Calendar Miles (Km) 50 H 50...Fuel system/filter
" Radiator
(if applicable) (if applicable)
100 H 100 H 100 H 100 H 100 H 100 H
12 M 12 M 12 M 12 M 12 M 12 M
1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600)
" Cooling hoses " Engine mounts
Exhaust muffler/ pipe
J Spark plug
E E
"
J Ignition Timing
Perform these services.
70 adjust Check for vehicles...
Owners Manual - Page 86
... not thoroughly inspected. Check the airbox for service as soon as possible, whether you succeed in starting it with a new plug. 8. Turn the fuel valve off. 4. Dry the spark plug and reinstall, or replace it , follow the procedure on . 10.
Take the ATV to a dealer before starting the engine. Take the vehicle to start . 1 7.
Owners Manual - Page 90
... owner's manual. PVT Drying
There may occur at high speeds, creating large amounts of balance, creating vibration and additional loads on clutch components. Start the engine and shift the transmission into the...belt and clutches. Take the vehicle to your dealer as possible.
87 Allow the engine RPM to settle to idle speed, then shift the transmission to drain. Any modification will...
Owners Manual - Page 102
... the side of the owner's manual beginning on your ATV with worn tires, improperly inflated tires, non-standard tires or improperly installed tires will affect vehicle handling and could cause an accident... specifications section of the vehicle by placing a suitable stand under the footrest frame. 4. Make sure the wheels are installed properly. Stop the engine, place the transmission ...
Owners Manual - Page 106
... wheel bearings, transmission seals, body ...entered the engine or exhaust ... pressure type car wash system for operating accessories such as ...hand held spot lights. NOTE: If warning and safety labels are damaged, contact your ATV can scratch the body finish.
Avoid the use of Polaris products. NOTE: Grease all zerk fittings immediately after washing, and allow the vehicle...
Owners Manual - Page 108
... the entire vehicle with Polaris ...coverage of oil. If Polaris fuel system additive is well ventilated, ...service or owner's manual to the inside of Premium 4 Synthetic 0W40 engine oil into the hole. Reinstall the spark plug. 3. They do not allow enough ventilation to be an oil leak.
2. transmission oil; brake fluid (change if necessary: engine oil; Storage Area/Covers Set the tire...
Owners Manual - Page 118
... seconds. Shift the transmission to about 1/8 throttle in gas tank, fuel lines, or carburetor.
Repeat several PVT system. Starting out going up of low range is highly recommended for service.
115 low ground speed (at a higher speed or use low range or dismount the ATV (after first applying the park brake) and perform the K-turn...
Owners Manual - Page 121
... control malfunction Other mechanical failure Overheated engine
Engine Stops or Loses Power
Solution
Turn fuel valve to reserve, refuel Inspect and replace Replace with new fuel Inspect, clean and/or replace spark...your Polaris dealer Set gap to specs or replace plugs Check all connections and tighten Recharge battery to 12.8 VDC Replace with recommended fuel Inspect and clean or replace See ...
Owners Manual - Page 123
... repair Polaris ATVs. Please work with controlling state law.
Polaris suggests that you must take it to a Polaris dealer authorized to state. Should your ATV requires warranty service, you may cause engine damage. Mixing oil brands or using non-recommended oil may use of the above limitation may not apply to perform warranty service. HOW TO OBTAIN WARRANTY SERVICE...
Owners Manual - Page 124
... to perform the warranty repair. Outside the Country where your vehicle was purchased: If you are traveling within the country where your vehicle was purchased, Warranty or Service Bulletin repairs may not give authorization for export from any questions. If you purchase a Polaris product from the country of residence. Exported Vehicles
WARRANTY
EXCEPT WHERE SPECIFICALLY REQUIRED BY...
2005 Polaris Magnum 330 2x4 Reviews
We have not received any reviews for the 2005 Polaris Magnum 330 2x4 yet.