Tire Warranty 1st Printing
Page 15
... or damage due to change its appearance (e.g., white inlay on passenger cars in any tire that has failed as a result of Goodyear, Dunlop or Kelly except as police pursuit service. • Goodyear Unisteel Commercial Radial Light Truck Tires • Loss of time, inconvenience, loss of vehicle use of tire chains, improper mounting or demounting, improper repair, wreck, collision or fire. • Road hazards (includes, but not...
... or damage due to change its appearance (e.g., white inlay on passenger cars in any tire that has failed as a result of Goodyear, Dunlop or Kelly except as police pursuit service. • Goodyear Unisteel Commercial Radial Light Truck Tires • Loss of time, inconvenience, loss of vehicle use of tire chains, improper mounting or demounting, improper repair, wreck, collision or fire. • Road hazards (includes, but not...
Tire Warranty 1st Printing
Page 25
... events. • Tires improperly repaired or with repairs not conforming to tires fitted as misalignment, defective brakes, defective shock absorbers, or improper rims. • Tires damaged by fire, chemical corrosion, vandalism, wrecks, chains, theft, run while flat, underinflated, overinflated, or abused during servicing. Tires affected by Flat Spotting caused by improper transport or storage. • Tires which become unserviceable because of road hazard injuries (e.g., nails...
... events. • Tires improperly repaired or with repairs not conforming to tires fitted as misalignment, defective brakes, defective shock absorbers, or improper rims. • Tires damaged by fire, chemical corrosion, vandalism, wrecks, chains, theft, run while flat, underinflated, overinflated, or abused during servicing. Tires affected by Flat Spotting caused by improper transport or storage. • Tires which become unserviceable because of road hazard injuries (e.g., nails...
Scheduled Maintenance Guide 1st Printing
Page 7
... basic maintenance checks and inspections be performed at 500 miles (800 km) of all hinges, latches, door check straps (see "Owner's Guide"). and lubricate upper and lower sliding door tracks, if equipped. and lubricate door rubber weatherstrips. safety warning lamps (brake, ABS, air bag, safety belt) for wear and proper operation. engine cooling system level and strength. battery connections and clean if necessary. clutch fluid level, if equipped. OWNER CHECKS AND SERVICES General Owner's Information...
... basic maintenance checks and inspections be performed at 500 miles (800 km) of all hinges, latches, door check straps (see "Owner's Guide"). and lubricate upper and lower sliding door tracks, if equipped. and lubricate door rubber weatherstrips. safety warning lamps (brake, ABS, air bag, safety belt) for wear and proper operation. engine cooling system level and strength. battery connections and clean if necessary. clutch fluid level, if equipped. OWNER CHECKS AND SERVICES General Owner's Information...
Scheduled Maintenance Guide 1st Printing
Page 16
Replace engine air filter. Change automatic transmission fluid on vehicles equipped with dipstick. Inspect automatic transmission/transaxle fluid level on the vehicles equipped with zerk fittings. Replace cabin air filter, if equipped. Inspect wheel ends for ❑ optimal tire life. Replace fuel filter (see page 47). Inspect engine cooling system and hoses. Inspect and lubricate 4X4 front axle shaft U-joints (F250/350/450/550). Rotation recommended for endplay and noise. Inspect steering linkage, ball joints, suspension and, if equipped, halfshafts, ...
Replace engine air filter. Change automatic transmission fluid on vehicles equipped with dipstick. Inspect automatic transmission/transaxle fluid level on the vehicles equipped with zerk fittings. Replace cabin air filter, if equipped. Inspect wheel ends for ❑ optimal tire life. Replace fuel filter (see page 47). Inspect engine cooling system and hoses. Inspect and lubricate 4X4 front axle shaft U-joints (F250/350/450/550). Rotation recommended for endplay and noise. Inspect steering linkage, ball joints, suspension and, if equipped, halfshafts, ...
Scheduled Maintenance Guide 1st Printing
Page 23
... DATE: P&A CODE: MILEAGE: 105,000 miles Change engine oil and replace oil filter. Inspect wheel ends for optimal tire life. ❑ Inspect accessory drive belt(s). ❑ Replace spark plugs. ❑ Replace rear axle lubricant (Class A Motorhome, F450/550 and E450). Inspect engine cooling system and hoses. Rotation recommended for endplay and noise. Inspect automatic transmission fluid level, if equipped with zerk fittings. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Lubricate ball joints and steering linkage...
... DATE: P&A CODE: MILEAGE: 105,000 miles Change engine oil and replace oil filter. Inspect wheel ends for optimal tire life. ❑ Inspect accessory drive belt(s). ❑ Replace spark plugs. ❑ Replace rear axle lubricant (Class A Motorhome, F450/550 and E450). Inspect engine cooling system and hoses. Rotation recommended for endplay and noise. Inspect automatic transmission fluid level, if equipped with zerk fittings. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Lubricate ball joints and steering linkage...
Scheduled Maintenance Guide 1st Printing
Page 25
... steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace engine air filter. Consult your dealer for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect engine cooling system and hoses. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for your particular requirements. Change automatic transmission fluid on all light trucks over 6,000 Gross Vehicle Weight (except 3V engines...
... steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Replace engine air filter. Consult your dealer for wear and rotate. ❑ Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system. Inspect engine cooling system and hoses. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for your particular requirements. Change automatic transmission fluid on all light trucks over 6,000 Gross Vehicle Weight (except 3V engines...
Scheduled Maintenance Guide 1st Printing
Page 28
... Vans & SUVs Change rear axle lubricant on CD4E). Inspect PCV for endplay and noise. ❑ Inspect engine cooling system and hoses. ❑ Change Motorcraft Premium Gold Engine Coolant (see page 47). Replace 4X2 wheel bearings and grease seals, lubricate and adjust bearings. Change front axle lubricant (4X4 only). Replace cabin air filter, if equipped. Replace engine air filter. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 150,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes...
... Vans & SUVs Change rear axle lubricant on CD4E). Inspect PCV for endplay and noise. ❑ Inspect engine cooling system and hoses. ❑ Change Motorcraft Premium Gold Engine Coolant (see page 47). Replace 4X2 wheel bearings and grease seals, lubricate and adjust bearings. Change front axle lubricant (4X4 only). Replace cabin air filter, if equipped. Replace engine air filter. NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 150,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads/shoes...
Scheduled Maintenance Guide 1st Printing
Page 31
Inspect exhaust system and heat shields. Replace cabin air filter, if equipped. Replace climate-controlled seat filter if equipped (LS and Monterey). Inspect engine cooling system and hoses. Replace engine air filter (not required for endplay and noise. Inspect wheel ends for Focus). Replace fuel filter (see page 47) (not required for your particular requirements. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Inspect automatic transmission/transaxle fluid level on all other vehicles, if equipped with dipstick...
Inspect exhaust system and heat shields. Replace cabin air filter, if equipped. Replace climate-controlled seat filter if equipped (LS and Monterey). Inspect engine cooling system and hoses. Replace engine air filter (not required for endplay and noise. Inspect wheel ends for Focus). Replace fuel filter (see page 47) (not required for your particular requirements. Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and U-joints. Inspect automatic transmission/transaxle fluid level on all other vehicles, if equipped with dipstick...
Scheduled Maintenance Guide 1st Printing
Page 33
... oil filter. ❑ Inspect tires for your particular requirements. Inspect exhaust system and heat shields. Replace cabin air filter, if equipped. Inspect automatic transmission/transaxle fluid level on all vehicles equipped with 4F27E. Replace climate-controlled seat cushion filter, if equipped (Zephyr) Multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule Cars & Minivans RO#: DATE: P&A CODE: MILEAGE: ❑ ❑ ❑ ❑ Scheduled Maintenance 33 Normal Schedule Cars & Minivans Inspect engine cooling system and hoses. Inspect steering...
... oil filter. ❑ Inspect tires for your particular requirements. Inspect exhaust system and heat shields. Replace cabin air filter, if equipped. Inspect automatic transmission/transaxle fluid level on all vehicles equipped with 4F27E. Replace climate-controlled seat cushion filter, if equipped (Zephyr) Multi-point inspection (recommended) DEALER VALIDATION: Normal Schedule Cars & Minivans RO#: DATE: P&A CODE: MILEAGE: ❑ ❑ ❑ ❑ Scheduled Maintenance 33 Normal Schedule Cars & Minivans Inspect engine cooling system and hoses. Inspect steering...
Scheduled Maintenance Guide 1st Printing
Page 36
...; Change engine oil and replace oil filter. Inspect engine cooling system and hoses. Replace climate-controlled seat cushion filter, if equipped (Zephyr). Replace climate-controlled seat filter if equipped (LS and Monterey). Inspect exhaust system and heat shields. Consult your dealer for optimal tire life. Inspect automatic transmission/transaxle fluid level on all other vehicles, if equipped with dipstick. NORMAL SCHEDULE CARS & MINIVANS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads...
...; Change engine oil and replace oil filter. Inspect engine cooling system and hoses. Replace climate-controlled seat cushion filter, if equipped (Zephyr). Replace climate-controlled seat filter if equipped (LS and Monterey). Inspect exhaust system and heat shields. Consult your dealer for optimal tire life. Inspect automatic transmission/transaxle fluid level on all other vehicles, if equipped with dipstick. NORMAL SCHEDULE CARS & MINIVANS 90,000 miles ❑ Change engine oil and replace oil filter. ❑ Inspect tires for wear and rotate. ❑ Inspect brake pads...
Scheduled Maintenance Guide 1st Printing
Page 41
... Scheduled Maintenance 41 Normal Schedule Cars & Minivans Replace accessory drive belt(s) (if not replaced within last 100,000 miles). Replace cabin air filter, if equipped. Change rear axle lubricant on all rear wheel drive (RWD) vehicles (see below). Replace climate-controlled seat filter if equipped (LS and Monterey). Check air filter restriction gauge, replace filter as required (Focus only). Change automatic transmission/transaxle fluid (except CVT). Replace fuel filter (see page 47) (not required for endplay and noise. ❑ Inspect engine cooling system and hoses...
... Scheduled Maintenance 41 Normal Schedule Cars & Minivans Replace accessory drive belt(s) (if not replaced within last 100,000 miles). Replace cabin air filter, if equipped. Change rear axle lubricant on all rear wheel drive (RWD) vehicles (see below). Replace climate-controlled seat filter if equipped (LS and Monterey). Check air filter restriction gauge, replace filter as required (Focus only). Change automatic transmission/transaxle fluid (except CVT). Replace fuel filter (see page 47) (not required for endplay and noise. ❑ Inspect engine cooling system and hoses...
Owner Guide 4th Printing
Page 85
... Interior in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. The safety belt warning light and warning chime turn off . 85 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) Inspect the safety belts to make sure they do not need to be inspected after a collision. Safety belt warning light and indicator chime The safety belt warning light illuminates in the Cleaning chapter. Safety belt assemblies not in use in vehicles...
... Interior in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. The safety belt warning light and warning chime turn off . 85 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) Inspect the safety belts to make sure they do not need to be inspected after a collision. Safety belt warning light and indicator chime The safety belt warning light illuminates in the Cleaning chapter. Safety belt assemblies not in use in vehicles...
Owner Guide 4th Printing
Page 136
.... • Consult your local motor vehicle speed regulations for long distances, your vehicle will also assist in P (Park). • Vehicles with trailers should be parked on a grade, place wheel chocks under the trailer's wheels. 136 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) If you are driving down a long or steep hill, shift to a lower gear. Servicing after towing If you are towing on a trip to your Scheduled Maintenance Guide for more information. Refer...
.... • Consult your local motor vehicle speed regulations for long distances, your vehicle will also assist in P (Park). • Vehicles with trailers should be parked on a grade, place wheel chocks under the trailer's wheels. 136 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) If you are driving down a long or steep hill, shift to a lower gear. Servicing after towing If you are towing on a trip to your Scheduled Maintenance Guide for more information. Refer...
Owner Guide 4th Printing
Page 151
... Service Contractors, if not prohibited by state, local or municipal law shall deliver up to 2.0 gallons (7.5L) of gasoline or 5 gallons (18.9L) of 35 miles (56.3 km). This program is the customer's responsibility) • fuel delivery - Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement...
... Service Contractors, if not prohibited by state, local or municipal law shall deliver up to 2.0 gallons (7.5L) of gasoline or 5 gallons (18.9L) of 35 miles (56.3 km). This program is the customer's responsibility) • fuel delivery - Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement...
Owner Guide 4th Printing
Page 194
... shift feel. 194 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) This operation is eventually relearned. Maintenance and Specifications When lifting a plastic-cased battery, excessive pressure on the end walls could cause acid to flow through the vent caps, resulting in P (Park) (automatic transaxle) or the neutral position (manual transaxle), turn off all accessories and start the engine. 3. Shield your eyes when working near the battery to relearn its idle trim...
... shift feel. 194 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus) This operation is eventually relearned. Maintenance and Specifications When lifting a plastic-cased battery, excessive pressure on the end walls could cause acid to flow through the vent caps, resulting in P (Park) (automatic transaxle) or the neutral position (manual transaxle), turn off all accessories and start the engine. 3. Shield your eyes when working near the battery to relearn its idle trim...
Owner Guide 4th Printing
Page 226
... Keyless entry system autolock ...59 Keys ...59, 68 positions of the ignition ...138 L Lamps bulb replacement specifications chart ...39 daytime running light ...36 fog lamps ...35 headlamps ...35 headlamps, flash to pass ...36 instrument panel, dimming ...36 interior lamps ...38-39 replacing bulbs ...40 Heating heater only system ...31 Hood ...188 I Ignition ...138, 219 Infant seats (see Safety seats) ...106 Inspection/maintenance (I/M) testing ...211 Instrument panel cleaning ...183 cluster ...10 lighting up panel and interior ...36 J Jump-starting your vehicle ...166 2007 Focus...
... Keyless entry system autolock ...59 Keys ...59, 68 positions of the ignition ...138 L Lamps bulb replacement specifications chart ...39 daytime running light ...36 fog lamps ...35 headlamps ...35 headlamps, flash to pass ...36 instrument panel, dimming ...36 interior lamps ...38-39 replacing bulbs ...40 Heating heater only system ...31 Hood ...188 I Ignition ...138, 219 Infant seats (see Safety seats) ...106 Inspection/maintenance (I/M) testing ...211 Instrument panel cleaning ...183 cluster ...10 lighting up panel and interior ...36 J Jump-starting your vehicle ...166 2007 Focus...
Owner Guide 4th Printing
Page 229
Index W Warning lights (see Lights) ...10 Washer fluid ...190 Water, Driving through ...150 Windows power ...48 rear wiper/washer ...45 Windshield washer fluid and wipers checking and adding fluid ...190 operation ...45 replacing wiper blades ...190 Wrecker towing ...171 229 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus)
Index W Warning lights (see Lights) ...10 Washer fluid ...190 Water, Driving through ...150 Windows power ...48 rear wiper/washer ...45 Windshield washer fluid and wipers checking and adding fluid ...190 operation ...45 replacing wiper blades ...190 Wrecker towing ...171 229 2007 Focus (foc) Owners Guide (post-2002-fmt) USA (fus)
Warranty Guide 2nd Printing
Page 14
... fuel pump, electronic engine control unit, engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic front locking (four-wheel drive), locking rings (four-wheel drive), seals and gaskets, universal and constant velocity joints; The extended...
... fuel pump, electronic engine control unit, engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic front locking (four-wheel drive), locking rings (four-wheel drive), seals and gaskets, universal and constant velocity joints; The extended...
Warranty Guide 2nd Printing
Page 22
... Supply Manifold Fuel Tank Idle Air Bypass Valve Ignition Coil and/or Control Module Intake Manifold Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System PCV System and Oil Filler Cap Secondary Air Injection System Spark Control Components Spark Plugs and Ignition Wires Synchronizer Assembly Thermostat Throttle Body Assembly (MFI) Vacuum Distribution System Important Information About List of Parts Also covered by the two emissions warranties are used with components on a certain maintenance schedule: these parts remain under warranty until : (a) the first replacement time...
... Supply Manifold Fuel Tank Idle Air Bypass Valve Ignition Coil and/or Control Module Intake Manifold Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System PCV System and Oil Filler Cap Secondary Air Injection System Spark Control Components Spark Plugs and Ignition Wires Synchronizer Assembly Thermostat Throttle Body Assembly (MFI) Vacuum Distribution System Important Information About List of Parts Also covered by the two emissions warranties are used with components on a certain maintenance schedule: these parts remain under warranty until : (a) the first replacement time...
Warranty Guide 2nd Printing
Page 39
... and gaskets Torque converter REAR-WHEEL DRIVE: Axleshafts Bearings (front-wheel) Bearings (rear-wheel) Drive axle housing and all internal parts FRONT-WHEEL DRIVE: Axleshafts Bearings (front-wheel) Bearings (rear-wheel) Constant velocity and universal joints Final drive housing and all internal parts Parts and services NOT covered: • All items not specifically listed in the Parts Coverage Under Powertrain Limited Warranty • Repairs covered by the Ford New Vehicle Limited Warranty, recalls or Customer Satisfaction Programs. • Repairs needed to any engine, transmission...
... and gaskets Torque converter REAR-WHEEL DRIVE: Axleshafts Bearings (front-wheel) Bearings (rear-wheel) Drive axle housing and all internal parts FRONT-WHEEL DRIVE: Axleshafts Bearings (front-wheel) Bearings (rear-wheel) Constant velocity and universal joints Final drive housing and all internal parts Parts and services NOT covered: • All items not specifically listed in the Parts Coverage Under Powertrain Limited Warranty • Repairs covered by the Ford New Vehicle Limited Warranty, recalls or Customer Satisfaction Programs. • Repairs needed to any engine, transmission...