Owners Manual
Page 10
... severely damage the engine. Do not operate vehicle without the air filter element will increase your Owner's Manual. See your risk of losing control. Safety Decals and Locations WARNING IMPROPER TIRE PRESSURE OR OVERLOADING can cause loss of control resulting in dusty conditions. at 0-900 meters). 7170007 7 Be careful if load extends over the side of the rack. Factory setting: 40_ to the racks. Do not block headlight.
... severely damage the engine. Do not operate vehicle without the air filter element will increase your Owner's Manual. See your risk of losing control. Safety Decals and Locations WARNING IMPROPER TIRE PRESSURE OR OVERLOADING can cause loss of control resulting in dusty conditions. at 0-900 meters). 7170007 7 Be careful if load extends over the side of the rack. Factory setting: 40_ to the racks. Do not block headlight.
Owners Manual
Page 12
... Owner's Manual. 7079906 THIS VEHICLE IS AN ALL TERRAIN VEHICLE AND IS NOT INTENDED FOR USE ON PUBLIC ROADS. Loss of control or forward flipover may cause severe drive shaft and clutch damage. This may result, especially in power and traction if too much throttle is limited. AWD models 2WD models 7171492 Canadian Certification Decal ALL WHEEL DRIVE SWITCH Do not push switch to engage AWD if the rear wheels...
... Owner's Manual. 7079906 THIS VEHICLE IS AN ALL TERRAIN VEHICLE AND IS NOT INTENDED FOR USE ON PUBLIC ROADS. Loss of control or forward flipover may cause severe drive shaft and clutch damage. This may result, especially in power and traction if too much throttle is limited. AWD models 2WD models 7171492 Canadian Certification Decal ALL WHEEL DRIVE SWITCH Do not push switch to engage AWD if the rear wheels...
Owners Manual
Page 18
... for your ATV. The warranty on your ATV, and always maintain proper tire pressure. S Never exceed the stated load capacity for braking. Any modifications to ) mowers, blades, tires, sprayers, or large racks, may change the handling characteristics of the vehicle. S Never modify an ATV through improper installation or use the size and type of tires specified for your Polaris ATV is terminated if...
... for your ATV. The warranty on your ATV, and always maintain proper tire pressure. S Never exceed the stated load capacity for braking. Any modifications to ) mowers, blades, tires, sprayers, or large racks, may change the handling characteristics of the vehicle. S Never modify an ATV through improper installation or use the size and type of tires specified for your Polaris ATV is terminated if...
Owners Manual
Page 39
... Fuel Filter The in starting a cold engine. Do not attempt to the engine starting . Refuel when the instrument gauge indicates a low fuel level. ON: For normal operation. Fuel Tank The fuel tank filler cap (1) is located on page 46 for correct choke and throttle settings during starting procedure on the bottom of the fuel tank. Refer to clean the fuel filter. 36 CONTROLS Choke The choke assists in -line fuel filter should be replaced by...
... Fuel Filter The in starting a cold engine. Do not attempt to the engine starting . Refuel when the instrument gauge indicates a low fuel level. ON: For normal operation. Fuel Tank The fuel tank filler cap (1) is located on page 46 for correct choke and throttle settings during starting procedure on the bottom of the fuel tank. Refer to clean the fuel filter. 36 CONTROLS Choke The choke assists in -line fuel filter should be replaced by...
Owners Manual
Page 40
... recoil housing, especially when traveling in neutral. 3. NOTE: If the engine is in the ON position. If the starter rope handle is fully seated on a 1 level surface. Place the transmission in wet areas. 37 Recoil Starter CONTROLS If the battery has been drained or damaged and cannot start the engine. 6. Repeat steps 4-5 if necessary. Make sure the engine stop pulling immediately. 5. Lock the parking brake. 2.
... recoil housing, especially when traveling in neutral. 3. NOTE: If the engine is in the ON position. If the starter rope handle is fully seated on a 1 level surface. Place the transmission in wet areas. 37 Recoil Starter CONTROLS If the battery has been drained or damaged and cannot start the engine. 6. Repeat steps 4-5 if necessary. Make sure the engine stop pulling immediately. 5. Lock the parking brake. 2.
Owners Manual
Page 42
... rear wheels are spinning, release the throttle before getting into conditions where front wheel drive may cause severe drive shaft and gearcase damage. There is 1 in AWD. All Wheel Drive (AWD) System (AWD Models) FEATURES The All Wheel Drive system is on. Always switch to AWD while the rear wheels are at all wheel drive. When the switch is on or off . NOTE: The override switch allows activation of time the vehicle may be needed. CAUTION Switching to AWD...
... rear wheels are spinning, release the throttle before getting into conditions where front wheel drive may cause severe drive shaft and gearcase damage. There is 1 in AWD. All Wheel Drive (AWD) System (AWD Models) FEATURES The All Wheel Drive system is on. Always switch to AWD while the rear wheels are at all wheel drive. When the switch is on or off . NOTE: The override switch allows activation of time the vehicle may be needed. CAUTION Switching to AWD...
Owners Manual
Page 47
.... OPERATION Break-In Period Engine and Drivetrain Break-in of the clutches and drive belt will ensure a longer life and better performance. Pull only light loads. 7. See page 45. 6. PVT Break-in (Clutches/Belt) A proper break-in 1. Fill the fuel tank with vehicle operation and handling. 4. During the break-in period, change both the oil and the filter at slower speeds during the break-in period...
.... OPERATION Break-In Period Engine and Drivetrain Break-in of the clutches and drive belt will ensure a longer life and better performance. Pull only light loads. 7. See page 45. 6. PVT Break-in (Clutches/Belt) A proper break-in 1. Fill the fuel tank with vehicle operation and handling. 4. During the break-in period, change both the oil and the filter at slower speeds during the break-in period...
Owners Manual
Page 48
... Checklist Item Brake system / lever travel Brake fluid Auxiliary brake Front suspension Rear suspension Steering Tires Wheels / fasteners Frame nuts, bolts, fasteners Fuel and oil Coolant level (if applicable) Coolant hoses (if applicable) Throttle Indicator lights / switches Engine stop switch Air filter, pre-filter Air box sediment tube Headlamp Brake light / tail lamp Riding gear Remarks Ensure proper operation Ensure proper level Ensure proper operation Inspect, lubricate if necessary Inspect, lubricate if necessary Ensure free operation Inspect condition and pressure Inspect...
... Checklist Item Brake system / lever travel Brake fluid Auxiliary brake Front suspension Rear suspension Steering Tires Wheels / fasteners Frame nuts, bolts, fasteners Fuel and oil Coolant level (if applicable) Coolant hoses (if applicable) Throttle Indicator lights / switches Engine stop switch Air filter, pre-filter Air box sediment tube Headlamp Brake light / tail lamp Riding gear Remarks Ensure proper operation Ensure proper level Ensure proper operation Inspect, lubricate if necessary Inspect, lubricate if necessary Ensure free operation Inspect condition and pressure Inspect...
Owners Manual
Page 49
... neutral. Sit on . Do not press the throttle while starting a cold engine, pull the choke knob out until it does not readily start and all conditions are favorable, change the spark plug and try again. Never run an engine in severe injury or death. Turn the engine stop switch to a point where it stops. If starting . Release the throttle lever immediately after the engine starts. Place the transmission in . If the engine...
... neutral. Sit on . Do not press the throttle while starting a cold engine, pull the choke knob out until it does not readily start and all conditions are favorable, change the spark plug and try again. Never run an engine in severe injury or death. Turn the engine stop switch to a point where it stops. If starting . Release the throttle lever immediately after the engine starts. Place the transmission in . If the engine...
Owners Manual
Page 52
... WARNING Hauling cargo improperly can create unstable operating conditions, which could result in loss of control of the vehicle. Always follow these precautions when hauling cargo: S REDUCE SPEED AND ALLOW GREATER DISTANCES FOR BRAKING WHEN HAULING CARGO. When handling off-centered loads that extend over rough or hilly terrain, reduce speed and cargo to the hitch point designated for your vehicle. S CARGO WEIGHT...
... WARNING Hauling cargo improperly can create unstable operating conditions, which could result in loss of control of the vehicle. Always follow these precautions when hauling cargo: S REDUCE SPEED AND ALLOW GREATER DISTANCES FOR BRAKING WHEN HAULING CARGO. When handling off-centered loads that extend over rough or hilly terrain, reduce speed and cargo to the hitch point designated for your vehicle. S CARGO WEIGHT...
Owners Manual
Page 70
... Inspect Inspect for leaks at tank cap, lines, fuel valve, filter, pump, carburetor; adjust when parts are replaced Adjust as needed Inspect periodically; adjust Check for wear, routing, security; replace as needed J Valve clearance E E J Fuel system/filter " Engine mounts 100 H 100 H 100 H 100 H 100 H 12 M 12 M 12 M 12 M 12 M 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) Exhaust muffler/ pipe J Spark plug E E J Ignition Timing " Wiring J Clutches (drive and driven) bearings 100 H 100...
... Inspect Inspect for leaks at tank cap, lines, fuel valve, filter, pump, carburetor; adjust when parts are replaced Adjust as needed Inspect periodically; adjust Check for wear, routing, security; replace as needed J Valve clearance E E J Fuel system/filter " Engine mounts 100 H 100 H 100 H 100 H 100 H 12 M 12 M 12 M 12 M 12 M 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600) Exhaust muffler/ pipe J Spark plug E E J Ignition Timing " Wiring J Clutches (drive and driven) bearings 100 H 100...
Owners Manual
Page 101
... (positive) battery cable next. 8. Lift the battery out of one tablespoon baking soda and one cup water to prevent damage to tip a conventional battery sideways, which could spill electrolyte. R N H 3. Remove the hold-down strap holding the battery in gear. 2. CAUTION If electrolyte spills, immediately wash it off with a solution of the ATV. Lock the parking brake. Place the transmission in position...
... (positive) battery cable next. 8. Lift the battery out of one tablespoon baking soda and one cup water to prevent damage to tip a conventional battery sideways, which could spill electrolyte. R N H 3. Remove the hold-down strap holding the battery in gear. 2. CAUTION If electrolyte spills, immediately wash it off with a solution of the ATV. Lock the parking brake. Place the transmission in position...
Owners Manual
Page 106
...soap and water. Waxing the ATV Unless it can also extend the life of various components. Polaris recommends washing the ATV by hand or with any water that have entered the engine or exhaust system. Do not allow the vehicle to run for a ... garden hose and a pail of products to avoid damaging wheel bearings, radiator, transmission seals, body panels, brakes and warning labels. Use a professional type washing mitten, cleaning the upper body first and the lower parts last. CAUTION High water pressure may have a camouflage finish. 103 Avoid the use of Polaris products....
...soap and water. Waxing the ATV Unless it can also extend the life of various components. Polaris recommends washing the ATV by hand or with any water that have entered the engine or exhaust system. Do not allow the vehicle to run for a ... garden hose and a pail of products to avoid damaging wheel bearings, radiator, transmission seals, body panels, brakes and warning labels. Use a professional type washing mitten, cleaning the upper body first and the lower parts last. CAUTION High water pressure may have a camouflage finish. 103 Avoid the use of Polaris products....
Owners Manual
Page 119
SPECIFICATIONS 2006 Hawkeye 2X4 Gross Vehicle Weight Fuel Capacity Engine Oil Capacity Transmission Oil Front Gearcase Oil Front Rack Rear Rack Tongue Weight Hitch Towing Rating Unbraked Trailer Towing Capacity* Turn Radius Ground Clearance Length Width Height Dry Weight Wheel Base Engine Model Number / Type Lubrication Bore x Stroke Displacement Compression Ratio Engine Cooling Alternator Output Carburetion Main Jet Pilot Jet Needle Jet Pilot Air Jet Jet Needle Ignition Timing Spark Plug Type / Gap Capacities 930 lbs. (422 kg) 4.5 gal. (17 l) 2 qts. (1.9 l) 15.2 oz. (450 ml) 5 oz. (148 ml) 70...
SPECIFICATIONS 2006 Hawkeye 2X4 Gross Vehicle Weight Fuel Capacity Engine Oil Capacity Transmission Oil Front Gearcase Oil Front Rack Rear Rack Tongue Weight Hitch Towing Rating Unbraked Trailer Towing Capacity* Turn Radius Ground Clearance Length Width Height Dry Weight Wheel Base Engine Model Number / Type Lubrication Bore x Stroke Displacement Compression Ratio Engine Cooling Alternator Output Carburetion Main Jet Pilot Jet Needle Jet Pilot Air Jet Jet Needle Ignition Timing Spark Plug Type / Gap Capacities 930 lbs. (422 kg) 4.5 gal. (17 l) 2 qts. (1.9 l) 15.2 oz. (450 ml) 5 oz. (148 ml) 70...
Owners Manual
Page 122
2006 Hawkeye 4X4 Gross Vehicle Weight Fuel Capacity Engine Oil Capacity Transmission Oil Front Gearcase Oil Front Rack Rear Rack Tongue Weight Hitch Towing Rating Unbraked Trailer Towing Capacity* Turn Radius Ground Clearance Length Width Height Wheel Base Dry Weight Engine Model Number / Type Lubrication Bore x Stroke Displacement Compression Ratio Engine Cooling Alternator Output (watts) Carburetion Main Jet Pilot Jet Needle Jet Pilot Air Jet Jet Needle Ignition Timing Spark Plug Type / Gap SPECIFICATIONS Capacities 930 lbs. (422 kg) 4.5 gal. (17 l) 2 qts. (1.9 l) 20.3 oz. (600 ml) 5 oz. (...
2006 Hawkeye 4X4 Gross Vehicle Weight Fuel Capacity Engine Oil Capacity Transmission Oil Front Gearcase Oil Front Rack Rear Rack Tongue Weight Hitch Towing Rating Unbraked Trailer Towing Capacity* Turn Radius Ground Clearance Length Width Height Wheel Base Dry Weight Engine Model Number / Type Lubrication Bore x Stroke Displacement Compression Ratio Engine Cooling Alternator Output (watts) Carburetion Main Jet Pilot Jet Needle Jet Pilot Air Jet Jet Needle Ignition Timing Spark Plug Type / Gap SPECIFICATIONS Capacities 930 lbs. (422 kg) 4.5 gal. (17 l) 2 qts. (1.9 l) 20.3 oz. (600 ml) 5 oz. (...
Owners Manual
Page 123
SPECIFICATIONS 2006 Hawkeye 4X4 Drive System Type Shift Type Front Drive (ratio) Final Drive (ratio) Front Tires Rear Tires Drive System PVT Side Lever, H/N/R 3.6:1 15.18:1 22 x 7-12 (5 psi) 22 x 10-12 (5 psi) Suspension and Brakes Front Suspension: Mac Strut 7 in. (18 cm) travel Rear Suspension: Progressive Rate 8 in. (20 cm) travel Swing Arm Shock Adjustment CAM Front Brake Single-Control Hydraulic Disc Rear Brake Single-Control Hydraulic Disc Auxiliary Brake Hydraulic, Rear Wheel Park Brake Hydraulic Lock, All Wheel Headlight Taillight Brake Light Battery DC Plug-In (Rear) Electric Start ...
SPECIFICATIONS 2006 Hawkeye 4X4 Drive System Type Shift Type Front Drive (ratio) Final Drive (ratio) Front Tires Rear Tires Drive System PVT Side Lever, H/N/R 3.6:1 15.18:1 22 x 7-12 (5 psi) 22 x 10-12 (5 psi) Suspension and Brakes Front Suspension: Mac Strut 7 in. (18 cm) travel Rear Suspension: Progressive Rate 8 in. (20 cm) travel Swing Arm Shock Adjustment CAM Front Brake Single-Control Hydraulic Disc Rear Brake Single-Control Hydraulic Disc Auxiliary Brake Hydraulic, Rear Wheel Park Brake Hydraulic Lock, All Wheel Headlight Taillight Brake Light Battery DC Plug-In (Rear) Electric Start ...
Owners Manual
Page 127
... THE ABOVE SIX MONTH WARRANTY PERIOD. When requesting warranty service you if inconsistent with Polaris recommendations. 124 POLARIS FURTHER DISCLAIMS ALL EXPRESS WARRANTIES NOT STATED IN THIS WARRANTY. Should your ATV requires warranty service, you use of state or federal law, all other rights which vary from the use and when maintenance and installation are void because of Polaris engine oil for at...
... THE ABOVE SIX MONTH WARRANTY PERIOD. When requesting warranty service you if inconsistent with Polaris recommendations. 124 POLARIS FURTHER DISCLAIMS ALL EXPRESS WARRANTIES NOT STATED IN THIS WARRANTY. Should your ATV requires warranty service, you use of state or federal law, all other rights which vary from the use and when maintenance and installation are void because of Polaris engine oil for at...
Owners Manual
Page 128
... traveling temporarily outside the country of residence. You should take your vehicle was purchased: Warranty or Service Bulletin repairs must show the dealer photo identification from Polaris Industries. This policy does not apply to perform the warranty repair. You may be authorized to Safety Recalls. Outside the Country where your vehicle was purchased: If you should consult an authorized dealer to...
... traveling temporarily outside the country of residence. You should take your vehicle was purchased: Warranty or Service Bulletin repairs must show the dealer photo identification from Polaris Industries. This policy does not apply to perform the warranty repair. You may be authorized to Safety Recalls. Outside the Country where your vehicle was purchased: If you should consult an authorized dealer to...
Owners Manual
Page 133
... ...11 Air Filter ...84-85 All Wheel Drive ...39 All Wheel Drive Switch ...31 Automatic Transmission ...38 AWD ...39 AWD Switch ...31 E Engaging Front Gearcase ...Engine Break-in ...Engine Stop Switch ...Equipment Modifications ...Exhaust Emission Control System . 39 44 31 15 63 F Features ...39-41 Footwell Removal ...86 Front Gearcase Oil ...75-76 Front Wheel Hub Tightening ...81 Fuel Filter ...36 Fuel Safety ...42 Fuel Tank ...36 Fuel Valve ...36 B Battery ...98-102 Battery (Conventional) ...97 Battery Charging (Sealed) ...101-102 Battery Fluid...
... ...11 Air Filter ...84-85 All Wheel Drive ...39 All Wheel Drive Switch ...31 Automatic Transmission ...38 AWD ...39 AWD Switch ...31 E Engaging Front Gearcase ...Engine Break-in ...Engine Stop Switch ...Equipment Modifications ...Exhaust Emission Control System . 39 44 31 15 63 F Features ...39-41 Footwell Removal ...86 Front Gearcase Oil ...75-76 Front Wheel Hub Tightening ...81 Fuel Filter ...36 Fuel Safety ...42 Fuel Tank ...36 Fuel Valve ...36 B Battery ...98-102 Battery (Conventional) ...97 Battery Charging (Sealed) ...101-102 Battery Fluid...
Owners Manual
Page 134
... Throttle Lever ...32 Tires ...81 Toe Alignment ...80 Transmission Oil ...73-74 Transporting the ATV ...107 Trip Meter ...41 Troubleshooting ...113-115 Turning Around on a Hill ...56-57 R Rear Spring ...Recoil Housing ...Recoil Starter ...Reverse Override Switch ...Rider Information Center ...108 94 37 31 41 V Vehicle Identification Numbers ...5 Vehicle Immersion ...92 S Safe Riding Gear ...10 Safety ...6-30 Safety Decals and Locations ...6-9 W Warranty ...122-126 Wheel Nut Torque Specifications . . 83 Wheel Replacement...
... Throttle Lever ...32 Tires ...81 Toe Alignment ...80 Transmission Oil ...73-74 Transporting the ATV ...107 Trip Meter ...41 Troubleshooting ...113-115 Turning Around on a Hill ...56-57 R Rear Spring ...Recoil Housing ...Recoil Starter ...Reverse Override Switch ...Rider Information Center ...108 94 37 31 41 V Vehicle Identification Numbers ...5 Vehicle Immersion ...92 S Safe Riding Gear ...10 Safety ...6-30 Safety Decals and Locations ...6-9 W Warranty ...122-126 Wheel Nut Torque Specifications . . 83 Wheel Replacement...