2009 Polaris 600 IQ Shift Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2009 Polaris 600 IQ Shift manuals!
Problems with 2009 Polaris 600 IQ Shift?
Ask a Question
Other Models
Free 2009 Polaris 600 IQ Shift manuals!
Problems with 2009 Polaris 600 IQ Shift?
Ask a Question
Other Models
Popular 2009 Polaris 600 IQ Shift Manual Pages
Owners Manual - Page 3
Failure to cause cancer, birth defects or other reproductive harm. WARNING
The engine exhaust from this manual and on all of California to follow all product labels. WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of the instructions and safety precautions in serious injury or death.
Owners Manual - Page 4
... your dealership for all utility and recreational vehicles manufactured in our complete line of your vehicle, be performed only by a Factory Certified Master Service Dealer (MSD) Technician.
Your manual contains instructions for minor maintenance, but information about major repairs is interested in this owner's manual. Have your accessories and clothing delivered right to visit us...
Owners Manual - Page 6
... proper engine break-in, operation of important identification numbers that must be recorded in your snowmobile's controls and features. Polaris Products...Troubleshooting ...Warranty ...Maintenance...owner's manual. Pre-Ride Inspections ...44
This section explains procedures that should be performed before riding. TABLE OF CONTENTS
Safety ...6
This section describes safe vehicle operation ...
Owners Manual - Page 7
...manual. INTRODUCTION
Vehicle Identification Numbers
Record your snowmobile's identification numbers and key number in a safe place. This completed form is sold. Your key can be replaced.
+
Vehicle Model Number: _____ Tunnel VIN (+)(right side of the tunnel):_____ Engine...dealer at specific mileage intervals. Protect and preserve your snowmobile and forward it in this manual, store it...
Owners Manual - Page 24
... service clutches yourself -- Do not attempt adjustment with drive belt removed. Do not operate engine with hood open hot. Pressure Cap Warning
This warning decal is found under the hood on the pressure cap of the decals on the snowmobile for your protection. If any of the decals depicted in this manual differ...
Owners Manual - Page 26
...
Reverse Warning
The reverse warning decal is located on the lower console. SAFETY
+
If electric reverse: • Machine stopped and engine at low speeds, can cause loss of control, always: • Look behind before and while backing up. • Avoid ...loss of control resulting in serious injury or death. NOTE: For more information, see Owner's Manual. See page 24 for the text.
+
23
Owners Manual - Page 27
..., eye protection, and adequate clothing while operating this vehicle. • This vehicle is latched. Check local laws for age requirements. • When operating with limited visibility, can cause loss of control. See Owner's Manual for proper use only. Oil injection system: Use unmixed fuel only. If manual is capable of high speeds. Reduce speed and...
Owners Manual - Page 64
... throttle lever is released: 1. Test the throttle lever by compressing and releasing it 's necessary to an authorized Polaris dealer for service. If this occurs, return the machine to start the engine. Throttle Lever WARNING
OPERATION
An improperly functioning throttle lever may cause erratic machine behavior and loss of control, which could result...
Owners Manual - Page 65
... area behind the vehicle before and while backing. • Avoid sharp turns. • Apply throttle slowly. Push the yellow reverse button for one second and release. A flashing reverse light on the instrument panel will shut off. 3.
Damage will occur to the chaincase or transmission if shifting is attempted when the engine is operating...
Owners Manual - Page 68
Polaris recommends that you contact an authorized Polaris dealer to perform any service that the specified maintenance is performed. Emission Control Information
Owner's Responsibilities
MAINTENANCE
Please read the Snowmobile Engine Emissions Limited Warranty, and read the maintenance section of your owner's manual. You are responsible for ensuring that may be necessary.
65
Owners Manual - Page 77
...-2500 miles (3200-4000 km). Torque spark plugs to be read after the engine has been warmed up and the vehicle has been driven at higher speeds.
MAINTENANCE
Spark Plugs
A new engine can result in serious engine damage. Avoid prolonged idle speeds, which cause plug fouling and carbonization.
Refer to your Owner's Manual Supplement for the specific...
Owners Manual - Page 84
... temperature becomes too hot for service. Flushing the Cooling System
To ensure that the coolant maintains its ability to protect the engine, drain the system completely every two years and add a fresh mixture of the engine.
If you continue operating when the high temperature light is cold. NOTE: Engine performance will be reduced if you...
Owners Manual - Page 110
... Check for appli- • Replace the drive belt.
Machine fails to lack of spec Engine mount broken or loose • SEE YOUR DEALER. • Inspect and replace. ...tightener is loose. Engine Troubleshooting
TROUBLESHOOTING
Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems arise. Problem
Erratic engine operating RPM during ...
Owners Manual - Page 115
... page provided near the front of your Owner's Manual to assist you. Contact your snowmobile and its engine. Serial number 2. Dealer name 4. WARRANTY
Service and Warranty Information
Obtaining Service and Warranty Assistance
Read and understand the service data and the Polaris warranty information contained in this manual. Your dealer receives frequent updates on changes, modifications...
Owners Manual - Page 118
... of transportation to perform warranty service. however, you use of warranties and remedies
WARRANTY
ALL IMPLIED WARRANTIES (INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE) ARE LIMITED IN DURATION TO THE ABOVE ONE YEAR WARRANTY PERIOD.
Polaris recommends that you may cause engine damage. How to repair Polaris snowmobiles...
Owners Manual - Page 119
... required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up /delivery Loss of personal loss. Failure of product use of completing an effective repair. Warranty does not apply to parts exposed to delivery may be denied. improper fuel; The following items are excluded from the use of non-recommended products, warranty...
Owners Manual - Page 120
... not limited to the ECU box, coils, stator plate, and sensors. The fuel pump is covered. • Clutches and related clutch parts, including but not limited to the first 5,000 miles or two (2) calendar years from coverage. The free Second Year Engine Service Contract is honored by all eligible new and unused snowmobiles that were...
Owners Manual - Page 121
... or are traveling temporarily outside of any questions. If You Move: If you move to perform the warranty repair. You should take your new country. WARRANTY
Exported Vehicles
EXCEPT WHERE SPECIFICALLY REQUIRED BY LAW, THERE IS NO WARRANTY OR SERVICE BULLETIN COVERAGE ON THIS VEHICLE IF IT IS SOLD OUTSIDE THE COUNTRY OF THE SELLING DEALER'S AUTHORIZED LOCATION. This...
Owners Manual - Page 122
...conforms with the controlling state law.
119 The warranty period for a period of 200 hours of engine operation, 4000 kilometers (2485 miles) of vehicle travel, or 30 calendar months from defects ...OF EXPRESS OR IMPLIED WARRANTY OR ANY OTHER CONTRACT, NEGLIGENCE OR OTHER TORT OR OTHERWISE. This engine emissions limited warranty covers the parts and labor charges for repair or replacement of ...
Owners Manual - Page 123
... service that has been structurally altered, or when the snowmobile has been used in racing competition. Performance of other similar causes beyond the control of the vehicle's emission controls. It is not necessary to keep the emissions-related warranty valid. This limited warranty does not cover damage due to perform any engine that may maintain, replace, or repair...
2009 Polaris 600 IQ Shift Reviews
We have not received any reviews for the 2009 Polaris 600 IQ Shift yet.