2010 Polaris Sportsman 550 X2 EFI Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2010 Polaris Sportsman 550 X2 EFI manuals!
Problems with 2010 Polaris Sportsman 550 X2 EFI?
Ask a Question
Other Models
Free 2010 Polaris Sportsman 550 X2 EFI manuals!
Problems with 2010 Polaris Sportsman 550 X2 EFI?
Ask a Question
Other Models
Popular 2010 Polaris Sportsman 550 X2 EFI Manual Pages
Owners Manual - Page 2
If you cannot locate this product contains chemicals known to the State of California to the owner's manual on the next page. WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800-3423764 for assistance. A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 5
... for all of your vehicle, be performed only by a factory certified Master Service Dealer® (MSD) technician. Have your accessories and clothing delivered right to follow the instructions and recommendations in this owner's manual. We proudly produce an exciting line of utility and recreational products. • Snowmobiles • All-terrain vehicles (ATVs) • RANGER utility...
Owners Manual - Page 11
... ATV to ensure that all laws and regulations concerning the operation of your owner's manual. If you about safety training. We strongly advise you to strictly follow the recommended...SAFETY
Safety Training
ATV safety training is an off-road vehicle. A Polaris ATV is a top priority for a fee. Call ATV Enrollment Express at specific intervals. If you purchased a used Polaris ATV in...
Owners Manual - Page 15
... known to make sure it run in the owner's manual.
11 Always inspect the ATV before operating increases the risk of consciousness or death in safe operating condition. The engine exhaust from this vehicle only outdoors or in or near the area where refueling is performed or where gasoline is stored. • Do not...
Owners Manual - Page 19
... descending a hill. Always follow proper procedures for climbing hills as described in the owner's manual. Always descend a hill with the transmission in neutral. Always follow proper procedures as described in the owner's manual. See page 38. Always move the 4X4 switch to turn the ATV around on any hill unless absolutely necessary. Crossing Hillsides...
Owners Manual - Page 20
... procedure described in the owner's manual. See page 66. If the ATV begins rolling backwards: • Keep operator and passenger body weight uphill. • Never apply engine power. • Never apply ...vehicle is pointing straight uphill. See page 66. Never operate the ATV on hills too steep for the ATV or for your abilities. If all forward speed is lost: • Lean forward to ADC 4X4...
Owners Manual - Page 39
... N: Neutral R: Reverse P: Park To shift gears, brake to the desired gear. When the engine is left unattended, always place the transmission in heavy pulling situations and when operating at less than seven miles per hour for extended periods of the vehicle.
Gear Selector
Whenever the ATV is idling, move the lever to a complete stop...
Owners Manual - Page 43
... percent, such as E-85 fuel. Do not fill the tank neck. Fuel Tank Cap
39 Do not use fuel with the engine stopped, and outdoors or in a well ventilated area. Do not overfill. The fuel tank is designed to the fuel tank. Use either leaded or unleaded gasoline with a minimum pump octane number of fuel.
Refuel on a level...
Owners Manual - Page 72
... than the footrest level: • Proceed slowly. Avoid operating through water: 1. If the vehicle tips or overturns in water, or if the engine stops during or after operating in serious engine damage. After leaving water, test the brakes. Perform the services outlined in water. Avoid sudden movements. • Maintain a steady rate of the footrests. Do...
Owners Manual - Page 79
Place the transmission in the raised position can cause serious injury and damage to the vehicle. Dismount the vehicle. 5. If cargo weight is secured. 9. When loading cargo, always ...box, the load may dump unexpectedly and cause serious injury.
The rear tires will also catch the rear of the bed, damaging the vehicle and creating hazardous driving conditions. Lower the cargo box and make sure ...
Owners Manual - Page 82
... Daily Daily Daily Miles (Km) Inspect; clean often;
Always have an authorized Polaris dealer perform these operations more often for vehicles subjected to conduct this maintenance will not void the emissions warranty but may result in component failure and cause an accident, which may affect emissions.) Have an authorized Polaris dealer perform these services. apply dielectric...
Owners Manual - Page 84
...
X Perform these services.
80...pump;
every 25 hours if extreme use . replace lines every two years 1000 (1600) Inspect 1000 (1600) Inspect 1000 (1600) Inspect; MAINTENANCE
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first) Hours Calendar Fuel system X Engine mounts Exhaust muffler/ pipe E
Q Spark plug
Remarks
Miles (Km) 1000 (1600) Check for vehicles...
Owners Manual - Page 86
... Recommendations
Polaris recommends the use of Polaris PS-4 PLUS Performance Synthetic 2W-50 4-cycle oil or a similar oil for the part numbers of Polaris products. Always use the recommended oil. Never substitute or mix oil brands.
82 See page 133 for this engine. Follow the manufacturer's recommendations for fluid recommendations, capacities and...
Owners Manual - Page 102
... worn to the specifications section beginning on the vehicle. Remove the wheel nuts. 7. Lock the parking brake. Do not service axle nuts that have a cotter pin installed. All service must be performed by placing a suitable stand under the footrest frame. 6.
Stop the engine. WARNING! See your ATV with worn tires, improperly inflated tires, non-standard tires or improperly installed...
Owners Manual - Page 112
... filter with a new filter. 3. Check the air box. Turn the engine over several times using the electric start the engine. Attempt to water below . 1. MAINTENANCE
Vehicle Immersion
If your dealer before starting it or not. 8. Take the vehicle to take your dealer for service as soon as possible, whether you succeed in starting it , follow...
Owners Manual - Page 130
... carbon deposits from pistons, rings, valves and exhaust systems. 3. Fill the fuel tank. 2. Oil and Filter Change the oil and filter. Clean the Exterior Make any necessary repairs and clean the vehicle as recommended. Allow the engine to disperse through the entire fuel delivery system. Inspect and clean (or replace) the pre-cleaner and air...
Owners Manual - Page 138
SPECIFICATIONS
Sportsman X2 550 EFI
Maximum Weight Capacity 735 lbs. (333 kg) (includes operator, passenger, cargo, accessories) Dry Weight 799 lbs. (362.4 kg) Fuel Capacity 5.25 gal. (20 l) Engine Oil Capacity 2 qts. (1.9 l) Coolant Capacity 2 qts. (1.9 l) Transmission Oil Capacity 32 oz. (948 ml) Demand Drive Fluid Capacity 9.3 oz. (275 ml) Rear Gearcase Oil Capacity 6.1 oz. (180 ml...
Owners Manual - Page 144
... least 1000 hours when subjected to perform warranty service. SPARK ARRESTOR
Polaris warrants that you may use any warranty issues. however, you use of USFS standard 5100-1c for your original selling dealer; Engine Oil
1. We recommend the use your ATV. 2. Damage resulting from state to repair Polaris ATVs. When requesting warranty service you must present your dealer...
Owners Manual - Page 148
... any engine that may deny warranty claims for failures that you have been caused by the owner's or operator's improper maintenance or use . Any qualified repair shop or person may not apply if it is inconsistent with emission controls is a potential violation of any service that has been structurally altered, or when the vehicle has...
Owners Manual - Page 152
... with a Passenger...60-61
A
Access, Front Compartment ...42 Accessories ...128 Active Descent Control Fluid ...90-91 Active Descent Control...Limited Warranty . . 143-144 Engaging 4X4 ...37 Engaging Active Descent Control ...38 Engine Break-In...53 Engine Fogging ...127 Engine Oil ...82-85 Engine Stop...Engine Oil ...83 Rear Gearcase ...88 Transmission Oil ...86 Fluid Change ADC...91 Demand Drive ...87...
2010 Polaris Sportsman 550 X2 EFI Reviews
We have not received any reviews for the 2010 Polaris Sportsman 550 X2 EFI yet.