2011 Polaris 600 RMK 155 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2011 Polaris 600 RMK 155 manuals!
Problems with 2011 Polaris 600 RMK 155?
Ask a Question
Other Models
Free 2011 Polaris 600 RMK 155 manuals!
Problems with 2011 Polaris 600 RMK 155?
Ask a Question
Other Models
Popular 2011 Polaris 600 RMK 155 Manual Pages
Owners Manual - Page 2
WARNING
Read, understand, and follow the safety precautions could result in this manual and on all of California to cause cancer, birth defects or other reproductive harm.
Failure to the State of the instructions and safety precautions in serious injury or death. WARNING
The engine exhaust from this product contains chemicals known to follow all product labels.
Owners Manual - Page 5
... Polaris vehicle, making it the finest machine we've ever produced. Many years of experience have gone into the engineering, design, and development of Polaris owners. Have your accessories and clothing delivered right to your dealership for all of excellence for minor maintenance, but information about major repairs is interested in the Polaris Service Manual and...
Owners Manual - Page 7
...role, in the owner's manual.
Polaris Products ...104 Troubleshooting ...105 Warranty ...110 Maintenance Log ...119 Index ...122
3 Safety ...8
This section describes safe vehicle operation and identifies warning decals ...Ride Inspections...47
This section explains procedures that should be performed before riding.
TABLE OF CONTENTS
Introduction...5
This section contains helpful information ...
Owners Manual - Page 20
... driving, manually turn the skis to the left and right steering. When driving on long downhill stretches, pump the brakes.... If difficulty is encountered, remove ice and snow build-up that may be sure ice and snow are not interfering with the steering of brakes and/or fire and may result in brake failure. Apply just enough throttle to keep the clutch engaged, allowing the engine...
Owners Manual - Page 26
... printed on the snowmobile.
Never service clutches yourself. See your Polaris dealer to release cap. 13 PSI
22
WARNING Do not operate engine with engine running. Replacement safety decals are ...Read and follow the instructions of the decals depicted in this manual differ from the decals on your protection. Never run engine with plenum/belt guard removed. WARNING Do not open ....
Owners Manual - Page 28
...; Machine stopped and engine at low speeds, can cause loss of control resulting in unfamiliar terrain. (continued on the console of all warnings and the Owner's Manual before and while backing... only when stopped. • Apply throttle slowly. If manual is missing, contact a Polaris dealer for a replacement. • This vehicle is located on next page)
24 WARNING Reverse operation, even...
Owners Manual - Page 29
... injection system: Use unmixed fuel only. Check oil level when refueling.
25 Be seated and in insufficient time for you should have a proper balance of the throttle control assembly, to stop . • To maintain vehicle control on the top of ski carbides to track studs. See Owner's Manual for proper use only. A passenger...
Owners Manual - Page 33
... responds to regain full power. This results in power.
The sensor must be reconnected or repaired to detonation by automatically reducing the engine timing and adding fuel.
The rider will experience a loss in decreased engine RPM and performance. When the detonation returns to a permissible level, the system will flash six times if the sensor fails...
Owners Manual - Page 38
...symbol continues to cycle through the following screens: hour meter, engine temperature, air temperature (available as an accessory) and altimeter (available as an accessory). FEATURES
Instrumentation
MFD Digital Display Programs
Performance Program Trip Settings Trip F automatically displays when the fuel level is low if the snowmobile is active. The default display for this screen includes...
Owners Manual - Page 58
... the engine is in serious engine damage, especially if the transmission is running .
2. Pull the engine stop switch up to the ON position when the engine starts. 3. If equipped with electric start, grasp the starter handle and pull slowly until the engine starts. Repeat the cranking procedure as eight to ten pulls to prime the fuel system...
Owners Manual - Page 66
... when the throttle lever is released: 1. Turn the ignition switch to an authorized Polaris dealer for service as soon as possible.
62 Test the throttle lever by compressing and releasing it 's necessary to start the engine, the throttle safety switch and engine stop switch may cause the safety switch to activate, preventing the...
Owners Manual - Page 71
... Polaris dealer to perform any service that apply to operate on , you purchase the snowmobile.
Specifications and adjustments for engine tune-ups are located...performed. Non-ionizing Radiation
This vehicle emits some electromagnetic energy. You may be removed, even after you must not be engaged during engine tune-ups. Reverse (if equipped) must take your use in the Service Manual...
Owners Manual - Page 74
... Leaks Brake Pads Brake Disc Parking Brake Brake System Brake Fluid Idle RPM Throttle Lever Oil Pump Lever (synchronize) Throttle Cable Vent Lines Throttle Position Sensor Fuel Lines Fuel Filter Oil Filter Oil Lines Air Box/Plenum Fuel Injectors Engine Stop Switch Throttle Safety Switch Ignition Switch Taillight Brakelight Headlight ---84 -50 49, 84 85...
Owners Manual - Page 83
... system parts can cause burns. Check for signs of deterioration or damage. MAINTENANCE
Fuel Filter
See your dealer. CAUTION! Contaminated or poor quality fuel will shorten the life of storage. Always store fuel in poor engine performance. If low fuel pressure or reduced engine performance occurs between the recommended fuel filter service intervals, the filter may need replacement.
Owners Manual - Page 85
...service.
Steam and hot liquids will cause burns to cool down. Driving in deep snow will not allow the engine to your snowmobile. Add coolant if the level is warm or hot. Flushing the Cooling System
To ensure that should be performed when the engine...check the coolant when he performs the fall tune-up on . Ask your Polaris dealer to protect the engine, drain the system completely ...
Owners Manual - Page 109
Problem
Erratic engine operating RPM during acceleration or load variations Harsh drive clutch engagement...chain tightener is loose. Machine fails to lack of spec Engine mount broken or loose • SEE YOUR DEALER. • Inspect and replace. TROUBLESHOOTING
Engine Troubleshooting
Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems arise.
Owners Manual - Page 114
... your snowmobile and its engine. Serial number 2. Dealer name 4. Date of operation 7. Previous correspondence
Use the page provided near the front of trouble experienced 6.
WARRANTY
Service And Warranty Information
Obtaining Service and Warranty Assistance
Read and understand the service data and the Polaris warranty information contained in this manual. Model number 3. Your dealer...
Owners Manual - Page 117
... not apply to repair Polaris snowmobiles. Your dealer will remain in effect. This warranty gives you specific legal rights, and you use of transportation to resolve any of the above limitation may use any Polaris Servicing Dealer to perform warranty service. Mixing oil brands or using non-recommended oil may not be covered by warranty.
113 Engine Oil
1. We...
Owners Manual - Page 118
... coverage may be denied. improper engine timing; surface imperfections caused by the Owner's manual is highly recommended. use of completing an effective repair. Warranty will not apply to any product which has been damaged by abuse, accident, fire or any dealer to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly...
Owners Manual - Page 122
... that has been structurally altered, or when the vehicle has been used in the owner's manual. THE REMEDIES SET FORTH IN THIS LIMITED WARRANTY ARE THE ONLY REMEDIES AVAILABLE TO ANY PERSON FOR BREACH OF THIS WARRANTY. POLARIS DISCLAIMS ALL EXPRESS WARRANTIES NOT STATED IN THIS WARRANTY. Any qualified repair shop or person may maintain, replace, or...
2011 Polaris 600 RMK 155 Reviews
We have not received any reviews for the 2011 Polaris 600 RMK 155 yet.