2013 Polaris 600 Indy SP Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2013 Polaris 600 Indy SP manuals!
Problems with 2013 Polaris 600 Indy SP?
Ask a Question
Other Models
Free 2013 Polaris 600 Indy SP manuals!
Problems with 2013 Polaris 600 Indy SP?
Ask a Question
Other Models
Popular 2013 Polaris 600 Indy SP Manual Pages
Owners Manual - Page 2
WARNING
Read, understand, and follow the safety precautions could result in this manual and on all of California to follow all product labels. Failure to cause cancer, birth defects or other reproductive harm.
WARNING
The engine exhaust from this product contains chemicals known to the State of the instructions and safety precautions in serious injury or death.
Owners Manual - Page 5
... to your service needs during, and after, the warranty period.
1...manual contains instructions for all utility and recreational vehicles manufactured in the POLARIS Service Manual and should be sure to our world-wide family of your dealership for minor maintenance, but information about major repairs is interested in your vehicle, be performed only by a factory certified Master Service...
Owners Manual - Page 7
Specifications ...POLARIS Products...Troubleshooting ...Warranty ...Maintenance Log ...Index ...
106 108 109 114 123 125
3 Pre-Ride Inspections ...55
This section explains procedures that should be performed before riding. TABLE OF CONTENTS
Introduction ...5
This section contains helpful information for the perfect riding experience.
Safety ...8
This section describes safe vehicle ...
Owners Manual - Page 20
Before driving, manually turn the skis to the left and right steering. Proceed slowly and use extra caution when...prolonged periods on slippery surfaces. Never attempt an abrupt change of direction when operating on liquid cooled models, cooling for the engine, adequate snow cover is opened, the snowmobile will be obstructing the steering linkage. Operating in Deep Snow
If the snowmobile ...
Owners Manual - Page 25
... in this manual differ from the labels on your POLARIS dealer to release cap. 13 PSI
21 Read and follow the instructions of applicable liquid cooled models:
WARNING Do not open . The part number is found on the oil bottle:
WARNING Do not operate engine with drive belt removed. Never service clutches yourself...
Owners Manual - Page 26
... maximum performance see Reverse Warning Owner's Manual. If electric reverse: • Machine stopped and engine at low speeds, can cause loss of control, always: • Look behind before and while backing up. • Avoid sharp turns. • Shift to forward.
22 SAFETY
Safety Labels and Locations
No Passenger Warning/Fuel Recommendation Label
WARNING This vehicle...
Owners Manual - Page 28
...manual is missing, contact a POLARIS dealer for a replacement. • This vehicle...read and understand all warnings and the Owner's Manual before or while operating this vehicle. • This vehicle is capable of control. Check local laws for... an approved helmet, eye protection, and adequate clothing while operating this vehicle. • In an emergency, push down the Auxiliary Shut-Off Switch,...
Owners Manual - Page 29
... loss of ski carbides to control the vehicle. • When operating on approved models only) reduce speed and allow extra space for steering and stopping. Oil injection system: Use unmixed fuel only. Do not leave brake engaged for more than five minutes. • Before starting engine, check throttle, brake, and steering for long...
Owners Manual - Page 37
... Serious engine damage could result in miles per hour.
It will also illuminate when the service brake...Engine
33 See page 68. See page 86. See your dealer. FEATURES
Instrument Cluster
Indicator Lamps
Lamp Indicates Vehicle Speed Condition When standard mode is selected, speed displays in serious engine damage. Reverse High Beam Parking Brake This indicator flashes when the transmission...
Owners Manual - Page 71
... deicer. NOTICE: Operating with obstructed fuel systems will decrease. Fuel System Deicers
If you use fuel containing more than 87 octane fuel. See page 108 for the part numbers of gasoline to prevent damage resulting from fuel system icing. Although 87 octane fuel is usable, some engine performance will be lost and fuel economy will result in your snowmobile...
Owners Manual - Page 74
... quickly and completely. 4.
When these switches are disconnected, the ignition key switch must return to start the engine, the throttle safety switch and engine stop switch may be used to an authorized POLARIS dealer for service. If the throttle lever does not work properly, DO NOT start , take the snowmobile to activate, preventing...
Owners Manual - Page 75
... when the engine is operating above idle speed. • Shift to make sure the transmission is in reverse.The maximum engine RPM will indicate that the transmission is in forward gear when it's restarted.
71 Engaging Reverse
1.
OPERATION
Electronic Reverse (PERC)
WARNING
Improper reverse operation, even at idle. • Look behind your vehicle is clear...
Owners Manual - Page 78
... the limitations of the tunnel or the engine recoil cover.
You are responsible for diagnostic service. POLARIS recommends that you contact an authorized POLARIS dealer to a qualified dealer for ensuring that the specified maintenance is available to this vehicle.
74 Specifications and adjustments for your use in the Service Manual, which is equipped at the time...
Owners Manual - Page 88
... deterioration or damage. Replace worn or damaged fuel lines promptly. NOTICE: Kinking the fuel lines or using a pliers or similar tools to remove fuel lines may cause damage to service the fuel pump. See your dealer for signs of snow. If low fuel pressure or reduced engine performance occurs between the recommended fuel filter service intervals, the filter may occur. When...
Owners Manual - Page 90
... the instrument cluster will illuminate when the engine is cold. Stop the engine immediately. If engine overheating seems to cool down. This service must continue to operate while the indicator light is low. • Stop the engine and allow it to be performed when the engine is overheating. MAINTENANCE
Cooling System
Engine Overheating
The over-temperature indicator on...
Owners Manual - Page 113
... slide melted to the track clips due to lack of spec Engine mount broken or loose • SEE YOUR DEALER. • Inspect and replace. TROUBLESHOOTING
Engine Troubleshooting
Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems arise.
Problem
Erratic engine operating RPM during acceleration or load variations Harsh drive clutch...
Owners Manual - Page 118
... 6. WARRANTY
Service and Warranty Information
Obtaining Service and Warranty Assistance
Read and understand the service data and the POLARIS warranty information contained in this manual. Your...snowmobile and its engine. Model number 3. POLARIS Customer Service United States: 1-888-704-5290 Canada: 1-204-925-7100
114 When contacting us about parts, service, or warranty, always provide the...
Owners Manual - Page 121
... If you if inconsistent with your original selling dealer; Engine Oil
1. This warranty gives you specific legal rights, and you use any POLARIS Servicing Dealer to resolve any type of extended warranty coverage as part of warranties and remedies
ALL IMPLIED WARRANTIES (INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE) ARE...
Owners Manual - Page 122
... by abuse, accident, fire or any dealer to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up /delivery Loss of vacation/personal time
This warranty also excludes failures resulting from warranty coverage in denial of completing an effective repair. The following items are considered part of normal maintenance...
Owners Manual - Page 126
...or workmanship.This limited warranty does not cover damage due to perform any service that have any questions regarding your vehicle. Any qualified repair shop or person may deny warranty claims for failures that...this limited warranty shall be, at 1-888-704-5290.
122 POLARIS also recommends that has been structurally altered, or when the vehicle has been used in the owner's manual. If ...
2013 Polaris 600 Indy SP Reviews
We have not received any reviews for the 2013 Polaris 600 Indy SP yet.