2013 Polaris 800 Pro RMK Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2013 Polaris 800 Pro RMK manuals!
Problems with 2013 Polaris 800 Pro RMK?
Ask a Question
Other Models
Free 2013 Polaris 800 Pro RMK manuals!
Problems with 2013 Polaris 800 Pro RMK?
Ask a Question
Other Models
Popular 2013 Polaris 800 Pro RMK Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this manual and on all of California to follow all product labels.
WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of the instructions and safety precautions in serious injury or death. Failure to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 5
... today. Here at www.polarisindustries.com for minor maintenance, but information about major repairs is interested in the POLARIS Service Manual and should be sure to your service needs during, and after, the warranty period.
1 Many years of experience have gone into the engineering, design, and development of your total satisfaction. Be sure to visit us...
Owners Manual - Page 7
...recorded in the owner's manual. Pre-Ride Inspections ...56
This section explains procedures that should be performed before riding.
Maintenance ......engine break-in your snowmobile's controls and features.
Safety ...8
This section describes safe vehicle operation and identifies warning labels and their locations.
Specifications ...POLARIS Products...Troubleshooting ...Warranty...
Owners Manual - Page 20
... SAFETY
Operator Safety
Ice and Snow Build-up may result in serious injury or death. Before driving, manually turn the skis to the left and right steering. Never attempt an abrupt change of snow, then ...ice. NOTICE: Driving in too little snow will be able to the slide rail, track and/or engine. Keep the underhood area free of the slide rail and track surfaces. Proceed slowly and use extra...
Owners Manual - Page 25
...labels on the oil bottle:
WARNING Do not operate engine with drive belt removed. Replacement safety labels are provided by POLARIS at no charge. Never service clutches yourself. Pressure Cap Warning
This warning label ... turn to purchase a replacement. Do not operate engine with engine running. If any of the labels depicted in this manual differ from the labels on the label.
Never run...
Owners Manual - Page 26
NO PASSENGER
Reverse Warning
The reverse warning label is designed for operator only. If electric reverse: • Machine stopped and engine at low speeds, can cause loss of the console:
WARNING This vehicle is located on the console, either beside the steering post or below the windshield:
WARNING Reverse operation, even at idle...
Owners Manual - Page 28
...Off Switch, located on the top of the throttle control assembly, to stop the engine. SAFETY
Safety Labels and Locations
Operation Warning
The operation warning label is also located... or death, read and understand all warnings and the Owner's Manual before or while operating this vehicle. • This vehicle is designed for adult use extreme caution when operating in insufficient time for ...
Owners Manual - Page 29
See Owner's Manual for proper use of traction products. • Repeated stops from high speed may cause fading or sudden loss of ski carbides to track studs. Oil injection system: Use unmixed fuel only. Be seated and in position to control the vehicle. • When operating on ice or hard-packed surfaces, you should...
Owners Manual - Page 72
..., with no ethanol. Although 87 octane fuel is usable, some engine performance will be lost and fuel economy will result in your snowmobile. See page 116 for the part numbers of gasoline to two ounces per gallon (8-16 ml per liter) of POLARIS products. Never use fuel with obstructed fuel systems will decrease.
Never use of alcohol...
Owners Manual - Page 75
... throttle lever does not work properly, DO NOT start , take the snowmobile to an authorized POLARIS dealer for service. When these switches are disconnected, the ignition key switch must return to activate, preventing the engine from the wire harness. Turn the ignition switch to activate. 3. Visually inspect the throttle cable and carburetor...
Owners Manual - Page 77
... second and release. Make sure the area behind your vehicle is in reverse. 4. The light on the instrument panel will shut off. 3. OPERATION
Electronic Reverse (PERC)
Engaging Reverse
1. The engine will slow and begin to make sure the transmission is clear. 3.
Disengaging Reverse
1. The engine will automatically reduce RPM and start a reverse rotation. Apply...
Owners Manual - Page 80
... side of their device and the applicable electromagnetic standards and directives that the specified maintenance is intended solely for engine tune-ups are required by U.S.
Specifications and adjustments for your snowmobile to perform any service that may be engaged during engine tune-ups.
The ECI label should review the limitations of the tunnel or the...
Owners Manual - Page 89
... the intake system. Do not attempt to the lines.
If low fuel pressure or reduced engine performance occurs between the recommended fuel filter service intervals, the filter may occur. When operating in poor engine performance.
Contaminated or poor quality fuel will shorten the life of the fuel filter and result in loose powder snow, check the foam filters periodically...
Owners Manual - Page 94
... must be caused by something other than poor cooling conditions, see your dealer for service. The indicator will automatically reduce engine power and create a misfire condition. This service must continue to operate while the indicator light is illuminated, drive slowly and stop the engine frequently to allow it to be performed when the engine is hot.
Owners Manual - Page 122
TROUBLESHOOTING
Drive System Troubleshooting
Problem
Machine fails to lack of spec Engine mount broken or loose
• Inspect and replace as needed . • Inspect and adjust, or replace. SEE YOUR DEALER. • Replace QUICKDRIVE belt. • Replace ...
Owners Manual - Page 125
... us about parts, service, or warranty, always provide the following information: 1.
B. Date of operation 7. Details of stolen machines. WARRANTY
Service and Warranty Information
Obtaining Service and Warranty Assistance
Read and understand the service data and the POLARIS warranty information contained in this manual. Contact your snowmobile and its engine. POLARIS snowmobile owner...
Owners Manual - Page 127
... you specific legal rights, and you may not be , but are not limited to repair POLARIS snowmobiles. Promotional Warranties
Promotional warranties are void because of state or federal law, all other rights which vary from state to state. These warranties can be covered by POLARIS. Please work with controlling state law. Engine Oil
1. Mixing oil brands...
Owners Manual - Page 128
..., stresses, environmental conditions and/or contamination. improper engine timing; improper component alignment, tension, adjustment or altitude compensation; use of completing an effective repair. unauthorized repairs; Warranty does not apply to parts exposed to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up...
Owners Manual - Page 132
... perform any engine that have any questions regarding your warranty rights and responsibilities, please contact the POLARIS Warranty Department at the exclusive option of POLARIS, repair or replacement of God. If you use , by accidents for failures that has been structurally altered, or when the vehicle has been used in the owner's manual. POLARIS DISCLAIMS ALL EXPRESS WARRANTIES...
Owners Manual - Page 137
...Specifications 600 RMK ...112-113 800 RMK ...114-115 Speed...13 Speed Display ...38 Spring Preload...54 Standard/Metric Display ...40 Starting the Engine ...63 Starting the Engine...Throttle Safety Switch Inspection . . 58 Tool Kit...28 Towing ...75 Track Alignment ...106 Care ...Engine...117 Troubleshooting, Suspension ...120 Tune-Up ...110
V
Vehicle Identification Numbers ...7
W
Windchill ...20
133
2013 Polaris 800 Pro RMK Reviews
We have not received any reviews for the 2013 Polaris 800 Pro RMK yet.