2014 Polaris 600 Indy Voyager Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2014 Polaris 600 Indy Voyager manuals!
Problems with 2014 Polaris 600 Indy Voyager?
Ask a Question
Other Models
Free 2014 Polaris 600 Indy Voyager manuals!
Problems with 2014 Polaris 600 Indy Voyager?
Ask a Question
Other Models
Popular 2014 Polaris 600 Indy Voyager Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this manual and on all of the instructions and safety precautions in serious injury or death. WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. Failure to follow all product labels.
Owners Manual - Page 3
... welcome to our world-wide family of excellence for all of your vehicle, be performed only by a factory certified Master Service Dealer® (MSD) technician. Your manual contains instructions for minor maintenance, but information about major repairs is interested in your total satisfaction. Be sure to visit us online at POLARIS we 've ever produced...
Owners Manual - Page 5
... explains proper engine break-in, operation of your snowmobile's regular maintenance.
TABLE OF CONTENTS
Introduction ...5
This section contains helpful information for the perfect riding experience.
Pre-Ride Inspections ...53
This section explains procedures that should be performed before riding.
Specifications ...POLARIS Products...Troubleshooting ...Warranty ...Maintenance Log...
Owners Manual - Page 18
... Snow Build-up and over the snow.
16 Before driving, manually turn the skis to the slide rail, track and/or engine. Slow down the snow in serious injury. Avoid operating for operation..., then step down and use extra caution. Driving on liquid cooled models, cooling for the engine, adequate snow cover is a requirement for prolonged periods on ice or hardpacked snow reduces steering ...
Owners Manual - Page 23
...label becomes illegible or comes off, contact your protection. Never run engine with hood or side panels open hot. Pressure Cap Warning
This warning... any of applicable liquid cooled models:
WARNING Do not open . Never service clutches yourself. Press down and turn to purchase a replacement. Replacement safety... manual differ from the labels on your dealer. The part number is found...
Owners Manual - Page 24
... and engine at low speeds, can cause loss of control resulting in serious injury or death. NOTE: For more information, see Owner's Manual. SAFETY...
Safety Labels and Locations
"No Passenger" Warning
Reverse Warning
"No Passenger" Warning
Snowmobiles designed for a single rider only have the NO PASSENGER warning label on the lower left side of the console:
WARNING This vehicle...
Owners Manual - Page 26
..., to stop the engine. Then pull the brake lever to stop. • Always wear an approved helmet, eye protection, and adequate clothing while operating this vehicle. • In an...or drugs before operation. Reduce speed and use only. If manual is missing, contact a POLARIS dealer for a replacement. • This vehicle is designed for age requirements.
(continued on the console.
...
Owners Manual - Page 27
...more than five minutes. • Before starting engine, check throttle, brake, and steering for steering and stopping. Oil injection system: Use unmixed fuel only. SAFETY
Safety Labels and Locations
Operation Warning.... • To maintain vehicle control on hard-packed snow, ice, or when crossing roads, steering and braking ability are latched. See Owner's Manual for proper use of traction...
Owners Manual - Page 69
... as recommended. Always protect painted surfaces when handling fuel. Never use lower than 10% ethanol. Although 87 octane fuel is usable, some engine performance will be lost and fuel economy will result in your snowmobile. Add one to two ounces per gallon (8-16 ml per liter) of 91 octane fuel or higher, with no ethanol. If you...
Owners Manual - Page 72
... occurs, return the snowmobile to an authorized POLARIS dealer for service. Turn the ignition switch to the idle position quickly and completely. 4. OPERATION
Throttle Lever
WARNING! If the engine stops abruptly when the throttle lever is released: 1. If the engine doesn't start the engine. An improperly functioning throttle lever may cause erratic snowmobile behavior...
Owners Manual - Page 73
... will automatically reduce RPM and start a reverse rotation. OPERATION
Electronic Reverse (PERC)
WARNING
Improper reverse operation, even at idle. • Look behind your vehicle is in reverse. 4. NOTICE: Engaging the starter when the engine is running . Damage will indicate that the transmission is running WILL result in serious injury or death. Engaging Reverse
1.
Owners Manual - Page 76
... either the right side of the tunnel or the engine recoil cover. Emission Control Maintenance Requirements
Your snowmobile is available to this vehicle.
74 If your snowmobile is performed. Reverse (if equipped) must take your use in the Service Manual, which is intended solely for diagnostic service. Emission Control Label
Your snowmobile is permanently affixed to...
Owners Manual - Page 85
... Maintenance Table beginning on page 76. When operating in clean fuel containers.
NOTICE: Kinking the fuel lines or using a pliers or similar tools to service the fuel pump. Do not attempt to remove fuel lines may occur. If low fuel pressure or reduced engine performance occurs between the recommended fuel filter service intervals, the filter may need replacement. Always store...
Owners Manual - Page 90
... down. Flushing the Cooling System
To ensure that the coolant maintains its ability to cool down . MAINTENANCE
Cooling System
Engine Overheating
The over-temperature indicator on your dealer for service. Illuminated Indicator Take action to check the coolant when he performs the fall tune-up on the instrument cluster will illuminate when the...
Owners Manual - Page 120
...lubrication. • Track may be caught or the rail slide melted to the track clips due to lack of spec Engine mount broken or loose
• SEE YOUR DEALER. • SEE YOUR DEALER.
• Inspect and replace ...8226; Inspect and replace as needed . TROUBLESHOOTING
Drive System Troubleshooting
Problem
Machine fails to the ground. • Chain is loose or broken or chain tightener is loose.
Owners Manual - Page 123
... maintenance, which may supercede information contained in this manual. Model number 3. Details of operation 7. Contact your snowmobile and its engine. Dealer name 4. Length of time and conditions of trouble experienced 6. Date of your POLARIS dealer for replacement parts, service or warranty. POLARIS Customer Service United States: 1-888-704-5290 Canada: 1-204-925...
Owners Manual - Page 125
...
1. Some states do not allow limitations on how long an implied warranty lasts, so the above terms are sometimes offered by warranty.
123 When requesting warranty service you use any warranty issues. however, you may cause engine damage. This warranty gives you specific legal rights, and you may not apply to state. Mixing oil brands or using non...
Owners Manual - Page 126
...; unauthorized repairs; Failure of any dealer to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up /delivery Loss of vacation/personal time
This warranty also excludes failures resulting from warranty coverage in the event of a warranty claim:
Spark Plugs Filters Fuel Sealants Hotel fees Towing charges Mileage Rentals...
Owners Manual - Page 130
... perform any service that have any questions regarding your vehicle. POLARIS also recommends that has been structurally altered, or when the vehicle has been used in racing competition. EPA Emissions Limited Warranty
The exclusive remedy for breach of this limited warranty shall be necessary for failures that may be , at 1-888-704-5290.
128 Any qualified repair...
Owners Manual - Page 135
... Throttle Lever Inspection ...55 Throttle Safety Switch ...69 Throttle Safety Switch Inspection . . 55 Tool Kit...28 Torsion Spring Preload ...50 Towing ...73 Track Alignment ...104 Inspection...101 Lubrication ...101 Tension..., Drive System ...118 Troubleshooting, Engine...117 Troubleshooting, Suspension ...120 Tune-Up ...112
V
Vehicle Identification Numbers ...7
W
Windchill ...20
133
2014 Polaris 600 Indy Voyager Reviews
We have not received any reviews for the 2014 Polaris 600 Indy Voyager yet.