2014 Polaris Sportsman 550 EPS Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2014 Polaris Sportsman 550 EPS manuals!
Problems with 2014 Polaris Sportsman 550 EPS?
Ask a Question
Other Models
Free 2014 Polaris Sportsman 550 EPS manuals!
Problems with 2014 Polaris Sportsman 550 EPS?
Ask a Question
Other Models
Popular 2014 Polaris Sportsman 550 EPS Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800342-3764 for assistance. If you cannot locate this product contains chemicals known to the State of California to the owner's manual on the next page. A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 3
... safe and enjoyable operation of your vehicle best and is outlined in the POLARIS Service Manual and should be sure to follow the instructions and recommendations in your vehicle, be performed only by a factory certified Master Service Dealer® (MSD) technician. Your POLARIS dealer knows your service needs during, and after, the warranty period.
1 Be sure to your...
Owners Manual - Page 9
.... If you purchased a used POLARIS ATV in the United States, you and your owner's manual. Call ATV Enrollment Express at 1-800-342-3764.
7 A POLARIS ATV is included in the... that explain safe operating procedures. FOR MORE INFORMATION ABOUT ATV SAFETY in your vehicle are thoroughly inspected at specific intervals. If you purchased a POLARIS ATV outside the United States, please contact...
Owners Manual - Page 16
...check the terrain carefully before ascending or descending a hill. Do not descend a hill with the transmission in neutral. If crossing a hillside is required when braking while traveling downhill. NOTE: A ...owner's manual. Never attempt to ADC 4X4 before descending a hill. • Shift your weight rearward. • Never travel down a hill at an angle, which would cause the vehicle to ...
Owners Manual - Page 45
... level of fuel in neutral. 13.
The vehicle should be brought to display, an open or short circuit has occurred in a 12-hour or 24-hour format. See your dealer for service.
43 See your dealer. 11. 4X4 Display - The time will display for resetting instructions. 8. It may also occur when the engine is at...
Owners Manual - Page 55
...manual. Do not operate at first. Engine ...fuel tank with vehicle operation and handling. 4. OPERATION
WARNING
Failure to operate the ATV properly can result in a collision, loss of a new engine and drive components will damage close-fitted engine parts and drive components.
Do not operate at 25 hours. 8. Always exercise extreme caution whenever handling gasoline. 2. Perform...
Owners Manual - Page 66
... while keeping body weight uphill. 2. Leave the transmission in forward. 9. Dismount on the uphill side of the vehicle, turn around to ADC 4X4 before ascending or descending a hill. Always move the 4X4 switch to your right until the vehicle is pointing straight uphill. 5. Restart the engine with the service brake, until it down the hill! Use the...
Owners Manual - Page 67
...your dealer for service at the first opportunity.
4. Determine water depths and current before restarting the engine. If the vehicle tips or overturns in water, or if the engine stops during ...special attention: engine oil, transmission oil, demand drive fluid, rear gearcase oil, ADC fluid and all grease fittings.
The friction will help dry out the pads. Perform the services outlined in...
Owners Manual - Page 87
...dealer perform these operations more often for vehicles subjected to severe use. Perform all services at...warranty but may affect emissions) Have an authorized POLARIS dealer perform these services. Item Maintenance Interval
(whichever comes first) Hours Calendar Steering Front suspension Rear suspension Tires Brake fluid level Brake lever travel Brake system Wheels/fasteners Frame fasteners Engine...
Owners Manual - Page 88
...Service D Have an authorized POLARIS dealer perform these procedures more often for proper sealing/air leaks Inspect; clean; Break-in oil level check Break-in oil level check Break-in oil and filter change Ź Demand drive fluid (normal use) Ź Rear gearcase oil Ź Transmission... etc. replace if necessary Inspect duct for vehicles subjected to extreme use. replace as needed ...
Owners Manual - Page 90
...Nm) See Page 89 89 92
550 Engine 850 Engine Transmission Oil
PS-4 5W-50 4-Cycle 2 qt. (1.9 l) Oil PS-4 5W-50 4-Cycle 2 qt. (1.9 l) Oil AGL Gearcase Lubricant & Transmission Fluid
37 oz. 10-14 ft..... lbs. (14-19 Nm) (14-19 Nm) ---------
96
28 94
Grease fittings (3 pumps maximum) every 500 miles, before long periods of storage, or after extreme use , grease zerks have been provided for...
Owners Manual - Page 132
...; Rear gearcase • Transmission • Brake fluid (change every two years and any necessary repairs and then clean the vehicle as recommended. Clean the Exterior Make any time the fluid looks dark or contaminated) • Coolant (test strength) Stabilize the Fuel 1. Add POLARIS Carbon Clean Fuel Treatment or POLARIS Fuel Stabilizer. Fill the fuel tank. 2. Change fluids...
Owners Manual - Page 134
... ATV. Stop the engine. Always tie the frame of additional accessories available for all models. Accessory outlets are approved for operating accessories. Place the transmission in PARK. POLARIS also has a wide range of the ATV to prevent loss during transporting. Always install accessories that are available for your POLARIS dealer.
132 Secure the fuel cap, oil cap...
Owners Manual - Page 140
SPECIFICATIONS
SPORTSMAN 550 EPS
Maximum Weight Capacity 575 lbs. (261 kg) (includes operator, cargo and accessories) Dry Weight 718 lbs. (325.7 kg) 724 lbs. (328.4 kg) (EPS) Fuel Capacity 5.25 gal. (20 l) Engine Oil Capacity 2 qts. (1.9 l) Coolant Capacity 2 qts. (1.9 l) Rear Gearcase Oil Capacity 7.1 oz. (210 ml) Demand Drive Fluid Capacity 9.3 oz. (275 ml) Transmission Oil Capacity...
Owners Manual - Page 142
.... (261 kg) (includes operator, cargo and accessories) Dry Weight 759 lbs. (344.3 kg) (XP) 767 lbs. (347.9 kg) (XP EPS) Fuel Capacity 5.25 gal. (20 l) Engine Oil Capacity 2 qts. (1.9 l) Coolant Capacity 2 qts. (1.9 l) Rear Gearcase Oil Capacity 7.1 oz. (210 ml) Demand Drive Fluid Capacity 9.3 oz. (275 ml) Transmission Oil Capacity 37 oz. (1100 ml) Front...
Owners Manual - Page 146
... PERSON FOR BREACH OF THIS WARRANTY. ALL OTHER IMPLIED WARRANTIES (INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTY OF MERCHANTABILITY) ARE LIMITED IN DURATION TO THE ABOVE SIX MONTH WARRANTY PERIOD. POLARIS DISCLAIMS ALL EXPRESS WARRANTIES NOT STATED IN THIS WARRANTY. This warranty provides no coverage for personal loss or expense, including mileage, transportation costs, hotels, meals...
Owners Manual - Page 149
... be covered subject to meet these regulations. EPA Emissions Limited Warranty
This emissions limited warranty is the responsibility of a service contract or other components not covered by original retail purchaser and continues for a period of 500 hours of engine operation, 5000 kilometers (3100 miles) of vehicle travel , or 30 calendar months from the date of purchase...
Owners Manual - Page 150
...beyond the control of any engine that has been structurally altered, or when the vehicle has been used in material or workmanship. This limited warranty does not cover damage ... PURPOSE. This limited warranty also does not cover any defective materials, components or products. The exclusive remedy for evaporative emissions:
Fuel Tank Fuel Cap Fuel Line Fuel Line Fittings Clamps* Pressure...
Owners Manual - Page 151
...'s improper maintenance or use only Pure POLARIS parts. Any modifications to perform any questions regarding your vehicle. POLARIS recommends that you contact an authorized POLARIS dealer to these features may maintain, replace, or repair the emission control devices or systems on your warranty rights and responsibilities, please contact POLARIS Customer Assistance.
EPA Emissions...
Owners Manual - Page 156
... Uphill ...61
A
Access, Front Compartment ...52 Accessories ...132 Active Descent Control Fluid ...94-95 Active...Warranty . . 148-149 Engaging 4X4 ...33 Engaging Active Descent Control ...33 Engine Break-In...53 Engine Fogging ...131 Engine Oil ...89-91 EPS Warning Indicator ...43 Equipment Modifications ...9 Error Codes, Engine...Engine Oil ...89-91 Rear Gearcase ...96-97 Transmission Oil ...92
154
2014 Polaris Sportsman 550 EPS Reviews
We have not received any reviews for the 2014 Polaris Sportsman 550 EPS yet.