2015 Polaris Outlaw 50 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2015 Polaris Outlaw 50 manuals!
Problems with 2015 Polaris Outlaw 50?
Ask a Question
Other Models
Free 2015 Polaris Outlaw 50 manuals!
Problems with 2015 Polaris Outlaw 50?
Ask a Question
Other Models
Popular 2015 Polaris Outlaw 50 Manual Pages
Owners Manual - Page 2
For videos and more information about a safe riding experience with your Polaris vehicle, scan this product contains chemicals known to the State of California to the owner's manual on the next page. WARNING
The engine exhaust from this QR code with your smartphone. If you cannot locate this card, or if it has been...
Owners Manual - Page 5
... in this owner's manual. Follow all ATV controls, including handlebars, brake levers, throttle lever and engine stop switch. Make sure...manual is not a toy and can reach and operate all of the instructions and warnings contained in learning about safe operation and care of 16 to enjoy the POLARIS riding experience along with you and your child's ATV are thoroughly inspected at specific...
Owners Manual - Page 9
...vehicles, such as motorcycles and cars. A POLARIS ATV is not a toy and can be sure your • Read this manual with the ATV. Understand all handlebars, brake levers, throttle lever and product labels and has completed a certified engine... ATV controls, including unless the guest has read this manual and all vehicle. Introduction
WARNING
Failure to operate. A collision or rollover...
Owners Manual - Page 26
... well (left lever) and then lock the parking brake. Apply the front brakes gradually (right lever). Never apply engine power. Turn the ATV around and remount, following the procedure described in the Owner's Manual. When fully stopped, apply the rear brake as well, and then lock the parking brake. Never apply the...
Owners Manual - Page 29
...fallen trees. Before operating in a new area, check for use on this manual.
On slippery surfaces such as outlined in this ATV and should be genuine POLARIS... control or overturn (if tires regain traction unexpectedly). or equivalent components designed for obstacles. Safety
Safety Warnings
Improper Vehicle Modifications
Improper installation of accessories or modification of the ATV...
Owners Manual - Page 50
... must never add their own gasoline. Always have an adult put gas in your ATV has sticky brakes. If they go . Never start the engine if your ATV needs more gas. Children must always be done by squeezing them toward the handlebar and...sure the brakes don't stick. They must read the instructions and warnings on page 15 of this manual. You could be fixed before you ride with sticky brakes.
Owners Manual - Page 62
Always check the lever for service if throttle problems arise. Features and Controls
Throttle Controls
WARNING
Operating an ATV with a sticking or improperly operating throttle. Failure to severe injury or death. Never... lever sticks during operation.
60 Also check occasionally during operation. Always contact your dealer for free movement and return before starting the engine.
Owners Manual - Page 72
... the engine.
Perform the following the procedures for your part is defined as following procedures carefully. Always use . Operation
WARNING
Failure to use the first two full tanks of gasoline. Careful treatment of use the recommended oil. Mixing brands or using a non-recommended oil may result in a collision, loss of this owner's manual...
Owners Manual - Page 73
...pre-filter screen Transmission oil Valve clearance
4. Operation
Break-in the proper range. Always exercise extreme caution whenever handling gasoline. Perform regular checks on...Perform break-in period. Vary throttle positions.
Check the oil level. Do not operate at sustained idle. 5. Fill the fuel tank with operation and handling. Maintain the oil level in Period
1. Item
Engine...
Owners Manual - Page 76
... Do not allow anyone under 6 years of the vehicle. Engine exhaust fumes are adding to operate this ATV. 4. Never operate the vehicle on pavement or on this vehicle. 3. Never start the engine or let it run in an enclosed area. 5. The combined weight of the operator, accessories and loads on the racks (if equipped). When determining...
Owners Manual - Page 88
Dismount on the uphill side of the vehicle, or on a Hill
If the vehicle stalls while climbing a hill, never back it down the hill! Shut off the engine. 3. Stop the vehicle and lock the parking brake while keeping body weight uphill. 2. Use the K-turn to turn around. 1. Operation
Turning Around on the left if the vehicle is pointing straight uphill.
86
Owners Manual - Page 101
... Inspect; test Drain and change the oil Drain and change the oil Clean filter at every oil change Transmission oil Oil pre-filter screen 20 30 40 40 Calendar Monthly 6M 12 M 12 M Miles (Km) 200 (320) 300 (480) 400 (640) 400 (640) Check terminals;
adjust; Maintenance
Periodic Maintenance Chart
Item Maintenance...
Owners Manual - Page 102
... procedures more often for leaks at tank cap, lines, fuel valve, filter, pump, carburetor; Fuel filter Engine mounts Exhaust muffler/pipe Ignition timing
100 100 100 100
12 M 12 M 12 M 12 M
1000 (1600) 1000 (1600) 1000 (1600) 1000 (1600)
109 ----
Ź Perform these services.
100
Maintenance
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first) Hours...
Owners Manual - Page 108
Allow it to idle for two to contact skin.
106 Maintenance
Engine Oil Change
1. 2. 3. 4. Position the vehicle on a level surface. Clean the area around the pre-filter plug. CAUTION! Do not allow hot oil to three minutes. Start the engine. Hot oil can cause burns to skin.
Stop the engine.
Owners Manual - Page 117
... several times using the electric start the engine. Turn the fuel valve on page 117 for service as soon as possible, whether you succeed in starting it with a... carburetor drain screw. 9. If water has been ingested into the transmission, follow the procedure on . 10. Attempt to your dealer for drying the CVT. Maintenance
Vehicle Immersion
5. Loosen the carburetor drain screw. 6.
Owners Manual - Page 118
...creating large amounts of balance, creating vibration and additional loads on clutch components. Extensive engineering and testing has been conducted to be out of force on components. The CVT ... at a high speed. Maintenance
Constant Variable Transmission (CVT) System
WARNING
Failure to make sure the CVT housing is securely in the owner's manual. • This CVT system is intended for...
Owners Manual - Page 167
..., clean and/or replace spark plugs Inspect, clean and/or replace spark plugs See your POLARIS dealer Set gap to specs or replace plugs Check all connections and tighten Recharge battery with .5 amp charger Replace with recommended fuel Inspect and clean or replace See your POLARIS dealer See your POLARIS dealer
165
Owners Manual - Page 177
... from the date of purchase, whichever comes first. The EPA emissions warranty period does not further extend if you purchase additional warranty coverage in addition to the POLARIS standard limited warranty for a period of 500 hours of engine operation, 5000 kilometers (3100 miles) of vehicle travel , or 30 calendar months from the date of purchase, whichever...
Owners Manual - Page 181
... damage, corrosion or defects caused by a defect in material or workmanship. POLARIS may maintain, replace, or repair the emission control devices or systems on your vehicle. This limited warranty does not cover damage due to perform any engine that have been caused by acts of POLARIS. Owners are responsible for which POLARIS has no responsibility...
Owners Manual - Page 183
DATE SERVICE INTERVAL TECHNICIAN SERVICE PERFORMED / COMMENTS
10 Hours (Break-in)
40 Hours
50 Hours
80 Hours
181 Maintenance Log
Present this section of maintenance and services performed. This will provide you and future owners with an accurate log of your manual to your dealer each time your vehicle is serviced.
2015 Polaris Outlaw 50 Reviews
Do you have an experience with the 2015 Polaris Outlaw 50 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2015 Polaris Outlaw 50 yet.
Earn 750 points for your review!