Planning Guides
Page 1
... must be installed in accordance with Backguard Specifications subject to change without Backguard Combustible rear wall Backguard mandatory if gap from back of cooktop to combustible wall is less than 2 1/2" (Figure 2). A Product Dimensions - Combustible rear wall 2 1/2" (64 mm) Min...mm) 47 7/8" (1216 mm) IMPORTANT: Installation of unit, end is recessed 2" (51 mm) from the cooktop is 1/2 p.s.i. When installing a backguard, use only Dacor model numbers AEB3609, AEB3612 (EG366), AEB4809 or AEB4812 (EG486). to accompanying installation instructions. Side View cabinet/countertop ...
... must be installed in accordance with Backguard Specifications subject to change without Backguard Combustible rear wall Backguard mandatory if gap from back of cooktop to combustible wall is less than 2 1/2" (Figure 2). A Product Dimensions - Combustible rear wall 2 1/2" (64 mm) Min...mm) 47 7/8" (1216 mm) IMPORTANT: Installation of unit, end is recessed 2" (51 mm) from the cooktop is 1/2 p.s.i. When installing a backguard, use only Dacor model numbers AEB3609, AEB3612 (EG366), AEB4809 or AEB4812 (EG486). to accompanying installation instructions. Side View cabinet/countertop ...
Planning Guides
Page 2
...to combustible surface from the edge of finished counter Cutout for utility access Cabinet/Countertop Dimensions ISO View 1 Vertical to change without notice. www.Dacor.com Phone: (800) 793-0093 4.2 Top View 3 Not applicable for minimum required clearances. 2 See Cabinet/Countertop Dimensions - EG366 EG486 ...installing an overhead vent hood, also check the hood specifications for cabinets more than a horizontal distance of 10" (254mm) from cooktop grate level; Install all appliances according to combustible side wall Min. EG366, EG486 Document # PG04-001 36 Inch and 48 Inch...
...to combustible surface from the edge of finished counter Cutout for utility access Cabinet/Countertop Dimensions ISO View 1 Vertical to change without notice. www.Dacor.com Phone: (800) 793-0093 4.2 Top View 3 Not applicable for minimum required clearances. 2 See Cabinet/Countertop Dimensions - EG366 EG486 ...installing an overhead vent hood, also check the hood specifications for cabinets more than a horizontal distance of 10" (254mm) from cooktop grate level; Install all appliances according to combustible side wall Min. EG366, EG486 Document # PG04-001 36 Inch and 48 Inch...
Planning Guides
Page 3
...Model No. EG366 EG486 B - Hole Offset 16 5/8" (422 mm) 20 13/16" (529 mm) Specifications subject to change without Raised Vent - www.Dacor.com Phone: (800) 793-0093 4.3 D D CL CL B 2" (51 mm) 1" (25 mm) Cabinet face below countertop CL overhang Cabinet/Countertop ... 48" (1219 mm) D - to accompanying installation instructions. Document # PG04-001 EG366, EG486 36 Inch and 48 Inch Wide Epicure® Gas Cooktops Cutout tolerances: +1/16", -0, (+1.6 mm, -0) unless otherwise stated Revised 05/06/10 Page 3/4 PLANNING GUIDE Gas and electrical connections at right rear section...
...Model No. EG366 EG486 B - Hole Offset 16 5/8" (422 mm) 20 13/16" (529 mm) Specifications subject to change without Raised Vent - www.Dacor.com Phone: (800) 793-0093 4.3 D D CL CL B 2" (51 mm) 1" (25 mm) Cabinet face below countertop CL overhang Cabinet/Countertop ... 48" (1219 mm) D - to accompanying installation instructions. Document # PG04-001 EG366, EG486 36 Inch and 48 Inch Wide Epicure® Gas Cooktops Cutout tolerances: +1/16", -0, (+1.6 mm, -0) unless otherwise stated Revised 05/06/10 Page 3/4 PLANNING GUIDE Gas and electrical connections at right rear section...
Planning Guides
Page 4
...bolts 10" (254 mm) Min. EG366 EG486 B - EG366, EG486 Document # PG04-001 36 Inch and 48 Inch Wide Epicure® Gas Cooktops Cutout tolerances: +1/16", -0, (+1.6 mm, -0) unless otherwise stated Revised 05/06/10 Page 4/4 PLANNING GUIDE 2 5/8" (67 mm) 3/8" (10... mm) Min. Install all appliances according to clear stiffener Dacor approved raised vent 3/8" Min. (10 mm) flat countertop overhang required behind raised vent chassis to accompanying installation instructions. countertop overhang Non combustible ...
...bolts 10" (254 mm) Min. EG366 EG486 B - EG366, EG486 Document # PG04-001 36 Inch and 48 Inch Wide Epicure® Gas Cooktops Cutout tolerances: +1/16", -0, (+1.6 mm, -0) unless otherwise stated Revised 05/06/10 Page 4/4 PLANNING GUIDE 2 5/8" (67 mm) 3/8" (10... mm) Min. Install all appliances according to clear stiffener Dacor approved raised vent 3/8" Min. (10 mm) flat countertop overhang required behind raised vent chassis to accompanying installation instructions. countertop overhang Non combustible ...
Installation Instructions
Page 1
Installation Instructions Epicure® Cooktop Models: EG366, EG486 Part No. 102025 Rev. N THIS APPLIANCE HAS BEEN TESTED IN ACCORDANCE WITH THE LATEST EDITION OF ANSI Z21.1 STANDARD FOR HOUSEHOLD GAS APPLIANCES.
Installation Instructions Epicure® Cooktop Models: EG366, EG486 Part No. 102025 Rev. N THIS APPLIANCE HAS BEEN TESTED IN ACCORDANCE WITH THE LATEST EDITION OF ANSI Z21.1 STANDARD FOR HOUSEHOLD GAS APPLIANCES.
Installation Instructions
Page 2
...low altitude operation All specifications are printed on the appliance data plate. Dacor Customer Service Phone: (800) 793-0093 (U.S.A. Pacific Time Web site: www.Dacor.com Dacor Distinctive Service (repairs under warranty call , have questions or problems ...Requirements 3 Gas Supply Requirements 3 Product Dimensions 3 Cabinet and Countertop Layout 4 Cabinet/Cutout Dimensions 5 Installation Instructions 8 Cooktop Installation 8 Gas Line Connection 9 Burner Component Installation 10 Burner Knob Installation 11 Verifying Proper Operation 12 Installation Checklist 13...
...low altitude operation All specifications are printed on the appliance data plate. Dacor Customer Service Phone: (800) 793-0093 (U.S.A. Pacific Time Web site: www.Dacor.com Dacor Distinctive Service (repairs under warranty call , have questions or problems ...Requirements 3 Gas Supply Requirements 3 Product Dimensions 3 Cabinet and Countertop Layout 4 Cabinet/Cutout Dimensions 5 Installation Instructions 8 Cooktop Installation 8 Gas Line Connection 9 Burner Component Installation 10 Burner Knob Installation 11 Verifying Proper Operation 12 Installation Checklist 13...
Installation Instructions
Page 3
... violent steam explosion may also trap heat, causing a fire hazard. warning WARNING - NEVER cover any other appliance. • Always contact the Dacor Customer Service Team about problems and conditions that you already know how to operate it. ◊ The fire is small and contained in the ... WATER, including wet dish cloths or towels - NEVER use combustible, flammable or explosive vapors and liquids (such as gasoline) on the cooktop and cooktop chassis. Safety Symbols and Labels DANGER Immediate hazards that are on the list of substances which are not meant to cover all slots, ...
... violent steam explosion may also trap heat, causing a fire hazard. warning WARNING - NEVER cover any other appliance. • Always contact the Dacor Customer Service Team about problems and conditions that you already know how to operate it. ◊ The fire is small and contained in the ... WATER, including wet dish cloths or towels - NEVER use combustible, flammable or explosive vapors and liquids (such as gasoline) on the cooktop and cooktop chassis. Safety Symbols and Labels DANGER Immediate hazards that are on the list of substances which are not meant to cover all slots, ...
Installation Instructions
Page 4
...commercial or laboratory use . Do not allow clothing to use Dacor backguard model AEB3609, AEB3612, (for model EG366) AEB4809, AEB4812 (for cooking tasks expected of the cooktop to birds. Children could blow over the cooktop. • Do not leave children alone or unattended in the... hang flammable or heat sensitive objects over the cooktop and create a fire hazard. • Non-stick coatings, when heated, can cause suffocation. • If you receive a damaged product, immediately contact your dealer or builder. Dacor strongly recommends the installation of outlet is not ...
...commercial or laboratory use . Do not allow clothing to use Dacor backguard model AEB3609, AEB3612, (for model EG366) AEB4809, AEB4812 (for cooking tasks expected of the cooktop to birds. Children could blow over the cooktop. • Do not leave children alone or unattended in the... hang flammable or heat sensitive objects over the cooktop and create a fire hazard. • Non-stick coatings, when heated, can cause suffocation. • If you receive a damaged product, immediately contact your dealer or builder. Dacor strongly recommends the installation of outlet is not ...
Installation Instructions
Page 5
...See the inside cover for the purpose of the chassis. • The electrical outlet must be installed in the gas line that the cooktop being installed is correct for the gas service being provided (natural gas or LP gas). The electrical and gas supply data on this ...; Check your local building department for high altitude operation. Product Dimensions 28" (711 mm) 27" (686 mm) 26" (660 mm) Trim: 7/16" (11 mm) thick A COOKTOP WIDTH (A) EG366 35 7/8" (911 mm) EG486 47 7/8" (1216 mm) 1 1/2" (38 mm) cooking surface height (grate level) above 4000 ft. (1219 m) make sure it...
...See the inside cover for the purpose of the chassis. • The electrical outlet must be installed in the gas line that the cooktop being installed is correct for the gas service being provided (natural gas or LP gas). The electrical and gas supply data on this ...; Check your local building department for high altitude operation. Product Dimensions 28" (711 mm) 27" (686 mm) 26" (660 mm) Trim: 7/16" (11 mm) thick A COOKTOP WIDTH (A) EG366 35 7/8" (911 mm) EG486 47 7/8" (1216 mm) 1 1/2" (38 mm) cooking surface height (grate level) above 4000 ft. (1219 m) make sure it...
Installation Instructions
Page 6
...performance and to minimize gas pressure loss, attach the gas supply regulator as close as possible to the cooktop gas inlet. If installing another appliance in the room, Dacor strongly recommends installing a range hood. Installation Requirements Cabinet and Countertop Layout warning To avoid the risk of .... • For installations with a raised vent, install this appliance only with the approved Dacor raised vent models listed on the following pages covers the recessed portions of the cooktop behind the control panel and creates a seamless look for the routing of gas and electrical ...
...performance and to minimize gas pressure loss, attach the gas supply regulator as close as possible to the cooktop gas inlet. If installing another appliance in the room, Dacor strongly recommends installing a range hood. Installation Requirements Cabinet and Countertop Layout warning To avoid the risk of .... • For installations with a raised vent, install this appliance only with the approved Dacor raised vent models listed on the following pages covers the recessed portions of the cooktop behind the control panel and creates a seamless look for the routing of gas and electrical ...
Installation Instructions
Page 7
... unless otherwise noted. 10" (254 mm) to combustible surface from the edge of the cooktop. both sides 1/2" (13 mm) overhang, both sides B 1 1/2" (38 mm) typical countertop thickness 7 3/4" (197 mm) Cooktop platform 1" (25 mm) Min. thickness Recommended gas and electrical service location, consult local code... distance of finished counter Cutout for minimum required clearances. 2 See Cabinet/Countertop Dimensions - Front View 13" (330 mm) max.3 C Hood See note 2 Cooktop Model B C EG366 36" (914 mm) 36" (914mm)* 42" (1067 mm)** EG486 48" (1219 mm) 48" (1219 mm)* 54" (...
... unless otherwise noted. 10" (254 mm) to combustible surface from the edge of the cooktop. both sides 1/2" (13 mm) overhang, both sides B 1 1/2" (38 mm) typical countertop thickness 7 3/4" (197 mm) Cooktop platform 1" (25 mm) Min. thickness Recommended gas and electrical service location, consult local code... distance of finished counter Cutout for minimum required clearances. 2 See Cabinet/Countertop Dimensions - Front View 13" (330 mm) max.3 C Hood See note 2 Cooktop Model B C EG366 36" (914 mm) 36" (914mm)* 42" (1067 mm)** EG486 48" (1219 mm) 48" (1219 mm)* 54" (...
Installation Instructions
Page 8
...) Cabinet face CL below countertop overhang Cabinet/Countertop Cutout Dimensions without Raised Vent - Hole Offset 16 5/8" (422 mm) 20 13/16" (529 mm) E - Top View Cooktop Model EG366 EG486 B - Cutout Width 36" (914 mm) 48" (1219 mm) D - Installation Requirements Cabinet/Countertop Dimensions (cont.) Cutout tolerances +1/16" -0 (+1.6 mm, 0) unless otherwise noted...
...) Cabinet face CL below countertop overhang Cabinet/Countertop Cutout Dimensions without Raised Vent - Hole Offset 16 5/8" (422 mm) 20 13/16" (529 mm) E - Top View Cooktop Model EG366 EG486 B - Cutout Width 36" (914 mm) 48" (1219 mm) D - Installation Requirements Cabinet/Countertop Dimensions (cont.) Cutout tolerances +1/16" -0 (+1.6 mm, 0) unless otherwise noted...
Installation Instructions
Page 9
Hole 1/2" dia. (13 mm), 2 places, through the bottom of the cooktop when installed with a raised vent. Side View 7 countertop overhang Non combustible rear wall recommended 1/2" (13 mm) countertop overhang CL 24 5/8" 15" (625 ... (13 mm) countertop overhang Countertop Countertop 2" (51 mm) 1" (25 mm) D D Cabinet face CL CL CL below to clear stiffener Dacor approved raised vent EG366 or EG486 cooktop Control panel Cabinet face IMPORTANT: See raised vent installation instructions for raised vent, gas and electrical connections 1" thick mounting platform Min. Installation...
Hole 1/2" dia. (13 mm), 2 places, through the bottom of the cooktop when installed with a raised vent. Side View 7 countertop overhang Non combustible rear wall recommended 1/2" (13 mm) countertop overhang CL 24 5/8" 15" (625 ... (13 mm) countertop overhang Countertop Countertop 2" (51 mm) 1" (25 mm) D D Cabinet face CL CL CL below to clear stiffener Dacor approved raised vent EG366 or EG486 cooktop Control panel Cabinet face IMPORTANT: See raised vent installation instructions for raised vent, gas and electrical connections 1" thick mounting platform Min. Installation...
Installation Instructions
Page 10
...) • Crown burner caps (2) • Crown burner rings (2) • Crown burner heads (2) • Knobs (4 standard, 2 MAX GRIDDLE) • Dacor Stainless Steel Cleaner • WOK ring • Griddle • Hold down bolts may result in improper operation of sealant to the gas pressure regulator, install... it . Do not overtighten the bolts. * Model EG486 comes with (3) 14 inch grates. Secure the cooktop to the countertop using the two (2) provided hold down bolts/washers (2 sets) • Regulator • Product literature WARNING •...
...) • Crown burner caps (2) • Crown burner rings (2) • Crown burner heads (2) • Knobs (4 standard, 2 MAX GRIDDLE) • Dacor Stainless Steel Cleaner • WOK ring • Griddle • Hold down bolts may result in improper operation of sealant to the gas pressure regulator, install... it . Do not overtighten the bolts. * Model EG486 comes with (3) 14 inch grates. Secure the cooktop to the countertop using the two (2) provided hold down bolts/washers (2 sets) • Regulator • Product literature WARNING •...
Installation Instructions
Page 11
... loss by a licensed plumber or gas fitter. 1. Check for gas leaks: ◊ Turn all lines and connections for leaks as possible to the cooktop gas inlet. 2. important Within the Commonwealth of Massachusetts, this appliance must never exceed ½ pounds per square inch (psi) or 3.5 kPa. ...8226; Do not install or use the cooktop without the included gas regulator installed. • Ensure that the gas supply meets specifications before use Teflon tape or plumber's putty on the ...
... loss by a licensed plumber or gas fitter. 1. Check for gas leaks: ◊ Turn all lines and connections for leaks as possible to the cooktop gas inlet. 2. important Within the Commonwealth of Massachusetts, this appliance must never exceed ½ pounds per square inch (psi) or 3.5 kPa. ...8226; Do not install or use the cooktop without the included gas regulator installed. • Ensure that the gas supply meets specifications before use Teflon tape or plumber's putty on the ...
Installation Instructions
Page 12
... Burner Assembly 10 Ridge on top of burner cap STEP 3: Install burner cap. Installation Instructions Burner Component Installation warning • Never attempt to operate the cooktop with head slots. STEP 2: Turn ring until it drops into place. Twist back and forth to assure proper seating. Make sure that the rubber feet...
... Burner Assembly 10 Ridge on top of burner cap STEP 3: Install burner cap. Installation Instructions Burner Component Installation warning • Never attempt to operate the cooktop with head slots. STEP 2: Turn ring until it drops into place. Twist back and forth to assure proper seating. Make sure that the rubber feet...
Installation Instructions
Page 13
There are marked with the cooktop. The knobs for the center burners are two (2) different types of the valve shaft. Carefully push the knob on the outer valve shafts . • When ... on them . • Put the knobs with the end of knobs supplied with the maximum griddle settings. Installation Instructions Burner Knob Installation caution Installing the cooktop knobs in the wrong position may result in damage to the...
There are marked with the cooktop. The knobs for the center burners are two (2) different types of the valve shaft. Carefully push the knob on the outer valve shafts . • When ... on them . • Put the knobs with the end of knobs supplied with the maximum griddle settings. Installation Instructions Burner Knob Installation caution Installing the cooktop knobs in the wrong position may result in damage to the...
Installation Instructions
Page 14
...warning • Make sure that power to the electrical outlet is turned off at the gas supply valve before proceeding. • The cooktop must be steady. Prior to repair the appliance yourself. Verify that will be rotated counterclockwise from HIGH to LOW to adjust the flame height...may take up to four seconds for location. Connect the power OFF cord to the OFF position. Dacor is installed properly, the flame will spark. If the appliance still does not work, contact Dacor Distinctive Service at a time counterclockwise to dissipate, then repeat the test. • Once the ...
...warning • Make sure that power to the electrical outlet is turned off at the gas supply valve before proceeding. • The cooktop must be steady. Prior to repair the appliance yourself. Verify that will be rotated counterclockwise from HIGH to LOW to adjust the flame height...may take up to four seconds for location. Connect the power OFF cord to the OFF position. Dacor is installed properly, the flame will spark. If the appliance still does not work, contact Dacor Distinctive Service at a time counterclockwise to dissipate, then repeat the test. • Once the ...
Installation Instructions
Page 15
...pressure been measured to ensure that no part of the installation has been overlooked. • Proper installation is the responsibility of your Dacor cooktop cannot be completed by the installer to ensure that it does not exceed the maximums stated in these instructions and in accordance with... all applicable electrical codes? See page 8. □□ Is the cooktop connected to the gas supply according to these instructions and in accordance with all burner parts and grates properly installed according to these ...
...pressure been measured to ensure that no part of the installation has been overlooked. • Proper installation is the responsibility of your Dacor cooktop cannot be completed by the installer to ensure that it does not exceed the maximums stated in these instructions and in accordance with... all applicable electrical codes? See page 8. □□ Is the cooktop connected to the gas supply according to these instructions and in accordance with all burner parts and grates properly installed according to these ...
Use & Care Manuals
Page 1
H Use and Care Manual Epicure® Cooktop Models: EG366, EG486 Ta b l e o f C o n t e n t s Important Safety Instructions 1-3 Getting to Know Your Cooktop 4 Setting Up Your Cooktop 5-6 Operating Your Cooktop 6-8 Care and Cleaning 10-11 Accessories and Replacement Parts 11 Before You Call For Service 12 Warranty and Service 13 Notes 14-16 Warranty Card Back Cover Part No. 102024 Rev.
H Use and Care Manual Epicure® Cooktop Models: EG366, EG486 Ta b l e o f C o n t e n t s Important Safety Instructions 1-3 Getting to Know Your Cooktop 4 Setting Up Your Cooktop 5-6 Operating Your Cooktop 6-8 Care and Cleaning 10-11 Accessories and Replacement Parts 11 Before You Call For Service 12 Warranty and Service 13 Notes 14-16 Warranty Card Back Cover Part No. 102024 Rev.