E-Z-GO Express L6 - Gas Support and Manuals
Get Help and Manuals for this E-Z-GO item
This item is in your list!
View All Support Options Below
Free E-Z-GO Express L6 - Gas manuals!
Problems with E-Z-GO Express L6 - Gas?
Ask a Question
Free E-Z-GO Express L6 - Gas manuals!
Problems with E-Z-GO Express L6 - Gas?
Ask a Question
Popular E-Z-GO Express L6 - Gas Manual Pages
Owner Manual - Page 3
... distribution of this vehicle. These are the original instructions as defined by E-Z-GO Division of Textron, Inc., and therefore is subject to change without obligation to products in this Manual. FOREWORD
Read all Notices, Cautions, Warnings, and Dangers. OWNER'S GUIDE GASOLINE POWERED VEHICLE
EXPRESS S6 EXPRESS L6
STARTING MODEL YEAR 2012
Never modify the vehicle in this...
Owner Manual - Page 10
...set...be carefully observed:
Certain replacement parts can be obtained at Title 49 of the Code of Federal Regulations, section ...Speed Vehicle (LSV) subject to title or register the vehicle as personal transportation vehicles BE OPERATED ONLY BY PERSONS WITH VALID DRIVERS... these procedures and troubleshooting tips will ensure the best possible service from the product. This manual has been designed ...
Owner Manual - Page 12
... the manufacturer's periodic service schedule • ensure that repairs are smoking • be aware that a vehicle that is a potential hazard and must not be sure to rewire the batteries correctly • use specified replacement parts, NEVER use replacement parts of lesser quality • use recommended tools • determine that tools and procedures not specifically recommended by the...
Owner Manual - Page 19
...
Read all Notices, Cautions, Warnings, and Dangers. TITLE
PAGE NO. EXPRESS S6 Vehicle Specifications ...2 - 3
EXPRESS L6 Vehicle Specifications ...2 - 4
2
EXPRESS S6 & L6 Vehicle Dimensions...2 - 5
EXPRESS S6 & L6 Vehicle Incline Information and Turning Diameter 2 - 6
2- 1 Pay particular attention to become thoroughly familiar with this manual to all of this vehicle.
Owner Manual - Page 21
...box Cargo Bed: Roto-molded cross-linked polyethelene. Parking Brake
Self-compensating, single point engagement
Electrical System
Starter/Generator.
MODEL: EXPRESS S6
2
TYPE: GAS POWERED PERSONNEL CARRIER (CARB)
MODEL YEAR: 2012
Part No: 618866
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
Engine: 13 hp (9.7 kW) Exceeds SAE J1940 Standard, 4 cycle, 24.5 ci (401 cc) single cylinder...
Owner Manual - Page 22
...installation charges
2- 4 GENERAL SPECIFICATIONS
Read all Notices, Cautions, Warnings, and Dangers.
2 MODEL: EXPRESS L6 TYPE: GAS POWERED PERSONNEL CARRIER MODEL YEAR: 2012
Part No: 618868
PRODUCT SPECIFICATION...this manual to... Regulator Service Brake
Rear wheel mechanical...rotating balance shaft
Air Cleaner: Replaceable dry cartridge
Electrical: Drive Train...gears, ground speed governor, forward/...
Owner Manual - Page 23
GENERAL SPECIFICATIONS
Read all Notices, Cautions, Warnings, and Dangers.
2
73.0 in. (185.0 cm)
Front 37.5 in. (95.0 cm)
Rear 38.5 in. (98.0 cm)
EXPRESS S6
93.5 in. (237.0 cm) 141.8 in. (....0 cm)
Rear 38.5 in. (98.0 cm)
EXPRESS L6
99.0 in. (241.0 cm) 138.0 in. (351.0 cm)
46.5 in. (119.0 cm)
2- 5 Pay particular attention to all of this manual to become thoroughly familiar with this vehicle.
Owner Manual - Page 24
EXPRESS S6
2
RECOMMENDED MAX SIDE TILT 25% or 14° MAX
RECOMMENDED MAX RAMP GRADE 25% or 14° MAX
2- 6
TURNING CLEARANCE DIAMETER
EXPRESS S6 EXPRESS L6
35 ft 6inches (10.8 m) 25 ft 6inches (7.8 m) Pay particular attention to become thoroughly familiar with this vehicle. GENERAL SPECIFICATIONS
Read all of this manual to all Notices, Cautions, Warnings, and Dangers.
Owner Manual - Page 37
... flap on the body below the front, driver side of this vehicle. In order to become thoroughly familiar with this manual to obtain correct components for the vehicle, the manufacture date code, serial number and vehicle model mustacture date code, serial number and vehicle model must be provided when ordering service parts. OPERATING PROCEDURES
Read all Notices, Cautions...
Owner Manual - Page 40
...models.
STARTING THE VEHICLE ON A HILL
To reduce the possibility of roll-back which could result in reverse. Pay particular attention to all of the choke. If the vehicle does not start within 10 seconds, use of this manual to start the engine. Release service... • Apply the service brake, place the key in the key switch and turn the key switch off, set the park brake and determine...
Owner Manual - Page 54
...generator and does not idle. FUSE REPLACEMENT
To replace fuses, locate the fuse block under the driver side seat.
The vehicle is more... Distributor, an authorized Branch or the Service Parts Department. Pull out old fuse and replace with the hardware. Install replacement bulb,
then secure the lens with ...understand all instructions provided by the manufacturer of premature bulb failure, do...
Owner Manual - Page 57
...sure to install the valve dust cap after five years. Too much oil may cause engine to the appropriate Technician's Repair and Service Manual. Some service procedures may...Service Schedule. Refer to the Service and Repair Manual for lubricant leakage. FOUR CYCLE ENGINE
Engine Specifications
Engine model ...FJ400D Type ...Four cycle, OHV Number of the rear axle for the fluid replacement ...
Owner Manual - Page 64
...replaced, a drain plug is provided with this manual...Repair and Service Manual. Add lubricant slowly until lubricant starts to prevent engine damage. ping distance from service...attention to the TROUBLESHOOTING section in the... of any combustible material. Install the check plug and the... burns, engine parts should refer to...driver side at which the brakes were latched.
Cleaning will...
Owner Manual - Page 69
...cracks/deterioration Check operation and governed speed Check for loose or missing hardware and components
Tighten or replace missing hardware
SEMI-ANNUAL - 125 HOURS (... filter element, clean/replace as required
5
OIL FILTER
Replace (at head and muffler gaskets Check cold (intake/exhaust) per Technician's Repair and Service Manual
500 HOURS (includes ...
Owner Manual - Page 70
...hardware are considered 'wet' and require approximately 80% of this manual to the Technician's Repair and Service Manual for specific torque values. Fasteners should be inspected for loose fasteners. BOLT ... or lubricated when installed are used in accordance with this chart. Unmarked hardware is identified by the three marks on the head. CAPACITIES AND REPLACEMENT PARTS
Fuel Tank / ...
E-Z-GO Express L6 - Gas Reviews
Do you have an experience with the E-Z-GO Express L6 - Gas that you would like to share?
Earn 750 points for your review!
We have not received any reviews for E-Z-GO yet.
Earn 750 points for your review!