E-Z-GO Shuttle 22 RXV - Gas Support and Manuals
Get Help and Manuals for this E-Z-GO item
View All Support Options Below
Free E-Z-GO Shuttle 22 RXV - Gas manuals!
Problems with E-Z-GO Shuttle 22 RXV - Gas?
Ask a Question
Free E-Z-GO Shuttle 22 RXV - Gas manuals!
Problems with E-Z-GO Shuttle 22 RXV - Gas?
Ask a Question
Popular E-Z-GO Shuttle 22 RXV - Gas Manual Pages
Owner Manual - Page 3
... previously sold and the information contained in this manual is subject to change without notice. E-Z-GO Division of TEXTRON Inc. OWNER'S MANUAL AND SERVICE GUIDE
GASOLINE POWERED FLEET GOLF CARS
RXV GOLF CAR RXV FREEDOM™ RXV SHUTTLE 2 + 2 STARTING MODEL YEAR 2011
E-Z-GO Division of TEXTRON Inc. is not liable for errors in this manual or for incidental or consequential damages that...
Owner Manual - Page 5
...CONTROLS AND INDICATORS 2
KEY SWITCH...3 DIRECTION SELECTOR 3 ACCELERATOR PEDAL 3 COMBINATION SERVICE BRAKE & PARK BRAKE PEDAL 3 CHOKE ...3 FUEL GAUGE ...3 LOW OIL ...REPAIR...8 LIFTING THE VEHICLE 9
WHEELS AND TIRES ...9 TIRE REPAIR...9 WHEEL INSTALLATION 10
LIGHT BULB REPLACEMENT 10
HEADLIGHT BULB REPLACEMENT 10 TURN SIGNAL BULB REPLACEMENT 11 TAIL LIGHT/BRAKE LIGHT BULB REPLACEMENT...
Owner Manual - Page 6
SHUTTLE 2 + 2 VEHICLE SPECIFICATIONS 30 DECLARATION OF CONFORMITY 35
Page iv
Owner's Guide
FLEET VEHICLE SPECIFICATIONS 28 RXV GAS - FREEDOM VEHICLE SPECIFICATIONS 29 RXV GAS - SERVICE AND MAINTENANCE 13
PERIODIC SERVICE SCHEDULE 13 CAPACITIES AND REPLACEMENT PARTS 14 HARDWARE...15 TIRE INSPECTION 16 REAR AXLE ...16 CHECKING THE LUBRICANT LEVEL 16 CHECKING THE OIL LEVEL 16 ...
Owner Manual - Page 12
... a replacement manual. PARKING
ALWAYS fully engage the parking brake and remove the key BEFORE leaving the vehicle. To Prevent Roll-Back 2.
NEVER leave the key in reverse, congested areas, and wet or loose terrain. STARTING the vehicle: Apply service brake , move the direction selector to increase travel speeds above factory specifications.
release the parking brake (Gas...
Owner Manual - Page 21
... as Repair and Service Manuals are on Front Frame
Serial Number
SERIAL NUMBER LOCATION
Three serial number and manufacture date code labels are available from a local Distributor, an authorized Branch or the E-Z-GO Service Parts Department. Some countries have individual requirements to obtain correct components for purchasing this guide can be provided when ordering service parts. Most...
Owner Manual - Page 23
... attention to all of manual to assure the longest service life of the brake pedal...service brake system. Contact a local distributor or an authorized branch.
• If the oil level is used to the 'H' mark. This is a feature to assure the vehicle is not driven with an electric fuel gauge (2), it is repeatedly between the 'L' (low) and 'H' (high) marks on the seat support panel, this guide...
Owner Manual - Page 25
...when the engine runs smoothly. Failure to install the dipstick and cap will sound to ...the off position, set the park brake and determine the cause of the problem. B COLD STARTING...Guide
Page 5
As internal moving parts are run in , oil consumption should be in place before attempting to start within 10 seconds, use of manual to become familiar with the Periodic Service...
Owner Manual - Page 35
...34)
(66)
(117)
(184)
Fig. 22 Torque Specifications and Bolt Grades
To reduce the possibility of severe injury or death from the battery before servicing.
Wrap wrenches with this vehicle.
Unmarked hardware is...arc, which can be made to the Technician's Repair and Service Manual for 'dry' fasteners. B OPERATION AND SERVICE INFORMATION
Read all NOTICES, CAUTIONS, WARNINGS and ...
Owner Manual - Page 36
...extreme care.
For major repair, refer to install the valve dust cap ...be inspected per the Periodic Service Schedule . Page 16
Owner's Guide B skin and eyes.
Aerosol...Repair and Service Manual. Unless leakage is the best guarantee for the first five years is in this vehicle. To access the powertrain for proper lifting procedure and safety information. The vehicle should be replaced...
Owner Manual - Page 41
.... BATTERY REMOVAL AND INSTALLATION
Tool List
Qty....problem. Rinse the entire area with a solution of baking soda and water. lbs 1
Owner's Guide... BATTERY
To reduce the possibility of manual to become familiar with a solution ...22 Nm) torque. The correct cleaning technique is indicated by a dirty air filter element or other restrictions in the Periodic Service Schedule, check, clean and set...
Owner Manual - Page 42
...22). All driving brake tests must be good" vehicles or to the braking performance of troubleshooting a problem vehicle. BATTERY +
BATTERY TIE DOWN
BATTERY
TIE DOWN SCREW
Fig. 40 Battery Removal When installing...see Periodic Service Schedule) as part of a new or "known to all corrosion from contacting battery terminals which could result in the torque specifications(Ref.
...
Owner Manual - Page 43
... failure.
Dry, Level, Clean, Paved Surface
Accelerate To Maximum Speed
B sure the vehicle stopping distance from the point at the line or marker in the Service and Repair Manual, to one side should be removed from moving parts.
Then repeat the Periodic Brake Performance Tests. Owner's Guide
Page 23 The vehicle should stop within the "normal...
Owner Manual - Page 48
...magneto
Replaceable dry cartridge element
11.42:1 Helical geared with neutral lock & ground speed ... tees
18 x 8.5 - 8 (4 ply rated)**
18 - 22 psi (124 - 152 kPa)**
3.3 inches (8 cm) at differential...use any E-Z-GO vehicle.
GENERAL SPECIFICATIONS
RXV GAS - dards under conditions of mesurement ...in the Owner's Guide
Page 28
Owner's Guide FLEET VEHICLE SPECIFICATIONS
BATTERY
ENGINE
AIR...
Owner Manual - Page 49
...
RXV GAS - FREEDOM VEHICLE SPECIFICATIONS
BATTERY
ENGINE
Air Cleaner TRANSAXLE TRANSMISSION FUEL TANK BRAKES PARKING BRAKE FRONT SUSPENSION REAR SUSPENSION STEERING STEERING WHEEL SEATING SEATING CAPAPCITY TOTAL LOAD CAPACITY SPEED CHASSIS
BODY
STANDARD COLORS DASH PANEL TIRES TIRE PRESSURE* LIGHTS GROUND CLEARANCE WEIGHT OPERATING CONTROLS &
INSTRUMENTATION
NOISE VIBRATION, WBV VIBRATION...
Owner Manual - Page 50
... 8.5 - 8 (4 ply rated)**
18 - 22 psi (124 - 152 kPa)**
3.3 inches (8 ... Guide
Page 30
Owner's Guide SHUTTLE 2 + 2 VEHICLE SPECIFICATIONS
BATTERY...SPEED CHASSIS
BODY
STANDARD COLORS DASH PANEL TIRES TIRE PRESSURE* GROUND CLEARANCE WEIGHT OPERATING CONTROLS &
INSTRUMENTATION
NOISE VIBRATION, WBV VIBRATION, HAV
One 12 Volt Maintenance Free
13 hp (9.7 kW) rated 24.5 cu. GENERAL SPECIFICATIONS
RXV GAS...
E-Z-GO Shuttle 22 RXV - Gas Reviews
We have not received any reviews for E-Z-GO yet.