Hayward HCF230C Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward HCF230C manuals!
Problems with Hayward HCF230C?
Ask a Question
Free Hayward HCF230C manuals!
Problems with Hayward HCF230C?
Ask a Question
Popular Hayward HCF230C Manual Pages
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 1
COMERCIAL SAND FILTER MANUAL
Models: HCF230, HCF234, HCF236
1
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 2
...
Head Loss Tables
Replacement Parts List
Warranty
Product Registration
Warranty Registration
Commercial Sand Filter
Models: HC2F30, HC2F34, HC2F36
2
Section 10. Section 12. Section 7.
Section 11. Section 9. Section 2.
2.1 2.2 2.3 2.3.1 2.3.2 2.3.3 Section 3. 3.1 Section 4. 4.1 4.2 4.3 4.4 4.5 4.6 4.7 Section 5.
5.1
5.2
5.3
Section 6. Important Safety Instructions
General
Swimming...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 3
... your equipment or in this owner's manual and on the equipment.
All components ...instructions may result in mechanical bind or swelling of access to prevent children from center to use or climb on the backrest for jewelry, swimsuits, hair decorations, fingers, toes, or knuckles to be installed and serviced... inspected frequently and replaced at all instructions in this product....
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 4
...filter manual air relief valve must be set in open position. o Never use Pool or Spa if any service or maintenance on electrical equipment turn off position and filter manual ...Failure to follow safety and operation instructions could result in violent separation of pump components.
High voltage electricity can result in filter body.
o Replace damaged, broken, cracked, missing,...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 5
...) are manufactured from proprietary resins and fiberglass, they must be aware of these codes before designing, specifying or installing any piece of equipment for a swimming pool or spa.
2.1 Swimming Pool Filters... work, which will affect the resultant condition of swimming pool water. It should be serviced while one filter to obtain the correct amount of a filter are suspended in mind ...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 6
...Disposal of filter inlet to prevent contaminants from draining back into the pool.
• Install a check valve between filter and heater to prevent hot water from backing up into ...• Install a check valve ahead of "waste water" must meet local, state and national codes. • See Chart on Page 8 for vertical and horizontal clearance.
2.3.3 Piping Connection Kits
Filter Model: HCF230 ...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 7
... of NSF test data
7 Ft. Characteristics and Dimensions
3.1 Dimensions and Sand Requirements Use only High Rate Sand No. 20 Silica Sand (.45mm - .55mm)
Figure 3-1
Filter
Model
A
Number
HCF230* 16.5
Dimensions (Inches)
B
C
D
Max Flow
Filter Area
Rate
Filter
Clearance (Inches)
Sand
Qty
(Lbs)
E Sq. Sq.
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 8
...filter, being careful not to the installation of the filter making sure they are complete. By hand, check the tightness of all costs to repair will be the responsibility of the ... that mechanical means be supplied directly from the mechanical room, per federal, state and local codes.
4.2 Filter Installation When moving by hand. It is any of delivery. Make note on a level, hard...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 9
... Re-installing the Manway Cover
1. This product should be installed and serviced only by hand. 6. Inspect the manway cover and o-ring, replace as needed... in the filter during startup.
1 -
Set all the parts from flowing to the filter. 3. Remove ...onto manway seat. 5. The manual air bleed valve (vent valve) must be serviced, follow these instructions carefully: 1. With a clean...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 10
...installation damage. Run system as normal and check for the HCF230, HCF234, HCF236 filters. Hayward® will not be responsible for the removal and replacement of sand, the seal will Hayward provide labor to evacuate and replace the sand for repair...). Notice - If the manway cover is a problem with water. Use the Hayward 2" Multi-Port...pump, set valve(s) to turn pump off and set the valve...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 11
...changing the filter sand is as required in Figure 3-1 (Page 8) of this manual. 7. Clean remaining sand from filter. WARNING - Remove manway cover and seal... certain to freezing conditions.
11 Open vent valve. Using a hose, spray the sand to isolate filter. 2. Replace the manway cover and seal. Section 7. Close necessary valves to loosen if necessary. 5.
Turn pump(s) OFF....
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 14
FILTER SERVICE PART LIST
NO. SUB-NUMBER
DESCRIPTION
1 LID HARDWARE KIT (CONTAINS 8 SETS PER KIT)
1.1
NUT COVER
1.2
NUT
1.3
WASHER
2 POLYCARBONATE MANWAY... COUPLING
8.4
PIPE SECTION (Not Shown)
9
COLLECTOR AIR RELIEVE KIT
9.1
COLLECTOR TUBING
9.2
PIPE CUP
PART NUMBER HCXFMCH1000
HCXFMCL1000 HCXFMCG1000 HCXFDIF1000 HCXFBHE1000
QTY PER FILTER
8 8 8
HCXFDK1000 1 1 1 1
HCXFLAT0825 ...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 15
...its products free from defects in obtaining warranty replacements. Parts which vary from the date of Hayward Pool Products. This warranty gives you specific legal rights, and you . Hayward Pool ... purchase, or to state. To obtain warranty replacements or repair, defective components or parts should be responsible for an authorized service center near you may not apply to the...
Commercial-Sand-Filter-Manual-ISHCF230RevA-English - Page 16
... State Zip Phone Number Purchase Date E-Mail Address Serial Number (10-17 digit number Model Number Pool Capacity U.S.
Product Registration
DATE OF INSTALLATION
INITIAL PRESSURE GAUGE READING (CLEAN FILTER
PUMP MODEL HORSEPOWER
* Retain this Warranty Certificate in service: 1< year
1-3
6-10
11-15
>15
Purchased from _____
Builder___ Retailer___ Pool Service____ Internet...
Hayward HCF230C Reviews
We have not received any reviews for Hayward yet.