Husqvarna AR19 Support and Manuals
Get Help and Manuals for this Husqvarna item
View All Support Options Below
Free Husqvarna AR19 manuals!
Problems with Husqvarna AR19?
Ask a Question
Free Husqvarna AR19 manuals!
Problems with Husqvarna AR19?
Ask a Question
Husqvarna AR19 Videos
Husqvarna AR19 aerator
Duration: 1:12
Total Views: 168
Duration: 1:12
Total Views: 168
AR19 Husqvarna GX120 3.5 HP Honda Engine Aerator
Duration: :14
Total Views: 4,853
Duration: :14
Total Views: 4,853
husqvarna ar19
Duration: :42
Total Views: 123
Duration: :42
Total Views: 123
2006 Husqvarna AR19 Commercial Aerator
Duration: :44
Total Views: 398
Duration: :44
Total Views: 398
Popular Husqvarna AR19 Manual Pages
Operation Manual - Page 1
Operator´s manual
AR19 AR25
Please read these instructions carefully and make sure you understand them before using the machine. English
Operation Manual - Page 3
...4
SAFETY 5 General Information 5 Safety Procedures 5
CONTROLS 6 Model AR19 6 Models AR25 7
ASSEMBLY 8 Model AR19 Handle 8 Model AR25 Handle 9 Clutch and Throttle Cables 10 Before Starting 10
OPERATION 11 Aeration Tips 11 Aerating 11 Rear Wheel Adjustment 12 Turning and Maneuvering 12 Operating On Slopes 13 Transporting 14
MAINTENANCE AND SERVICE 15 Cleaning 15 Two Minute Rule...
Operation Manual - Page 4
...and only in service questions, guarantee issues, etc., please consult the following information: • The machine's type designation (MODEL).
• ...replacement engine parts.
4 Read the manual carefully before attempting to use , service, maintenance, etc.) can be found on insurance coverage for purchasing a Husqvarna lawn care product. This ensures that you need spare parts or support...
Operation Manual - Page 5
...
This manual will be modified without the manufacturer's prior written authorization. Call your Husqvarna equipment. Safety Procedures
DO:
• Read all maintenance and service instructions before attempting work.
• Read engine manufacturer's operating and maintenance instructions.
• Remove spark plug wire before commencing service. • Inspect lawn to be aerated and...
Operation Manual - Page 8
... to rear
wheel control handle with the handle folded. Use protective glasses when removing unit from crate. Model AR19 Handle
1. Rotate handle into upright position and lock, using the front
holes. (See illustration)
2
1
1. The aerator is shipped with the fasteners located
on the rear wheel control handle, using the cam lock lever or link lock (dependent...
Operation Manual - Page 10
...! Route clutch cable through the guide hole in its operating position, lock the handle cam lock or link lock. (Model AR19).
3. Check that the clutch cable is not within correct range.
10
Removable wheel weight
1 3
1.
The throttle cable has been installed by the engine
manufacturer. Consult the engine manufacturer's manual for instructions to the "S" hook located...
Operation Manual - Page 15
...'s operating and maintenance instructions.
Two Minute Rule
Aerators may result from gasoline draining into the crankcase if prolonged. Engine damage may be tipped on these items. Do not exceed 1000 psi water pressure for no more than 2 minutes. MAINTENANCE AND SERVICE
Cleaning
Regular cleaning, washing and lubricating will prolong the service of Box
First...
Operation Manual - Page 16
... for Husqvarna to an Authorized Service Dealer. Adjust the keeper, or clutch cable length if necessary.
8. Remove and retain V-pulley and key. 7. Replacement procedure opposite of use. Check that the aerator rolls freely (with each other. Large pulley Replace belt on small pulley first
8060-010
IMPORTANT INFORMATION
Many parts, including the drive belt on Model AR19), with...
Operation Manual - Page 17
... setting, some additional adjustment may be lost.
17 If engine speeds too low, the engine will increase.
If engine speed is engaged. MAINTENANCE AND SERVICE
Clutch Cable
Removal and Replacement .... Remove the old throttle cable and route the new cable through guides
8060-002
Throttle Cable
Removal and Replacement
1. As the cable length decreases between the cable screw and adjuster...
Operation Manual - Page 20
...). Refer to
master link. 6. NOTE: Replace worn lock nuts to loosen the chain. 7. Turn chain idler adjustment screw counter
clockwise to insure that it was removed. Fold handle on the AR19 Model. 3. Remove the rotor shaft assembly. 10. MAINTENANCE AND SERVICE
Tines
Tine Wear
After the Husqvarna Aerator has been used for sometime, the tines will hold...
Operation Manual - Page 21
... grease on the bearing assemblies.
7. Handle
Model AR19, Cam Lock
Inspection
1. If the lock turns freely by reversing steps 1 through 12 in previous section, then proceed with moderately heavy hand pressure. IMPORTANT: excessive adjustment of the handle. MAINTENANCE AND SERVICE
Free-Wheeling Tine Assembly
Removal and Replacement
Complete steps 1 through 12 in previous action...
Operation Manual - Page 22
...AR19 and 6 on adjustment screw to prevent aerator from wheel.
If bearings are double set screws stacked two in each hole) use blue loctite with the wheel and shaft.
8. Install bearings and sprocket loosely onto the shaft. Replace.... Remove weights and drive guard. 3. MAINTENANCE AND SERVICE
Wheels
1. ALWAYS replace a free spinning nut to be approximately one foot off engine...
Operation Manual - Page 23
...Use washer and lock nut, tighten firmly.
6. Slide the wheel assembly off .
2. Install...assembly 3. MAINTENANCE AND SERVICE
Rear Wheels
Removal and Replacement Model AR19
1. Remove the axle ...aerator rest on level ground and the engine is turned off the machine. 6. Axle Removable wheel - Lower the rear wheel control handle to let the aerator rest on the wheel bushing. Install...
Operation Manual - Page 24
...
Measured Value Guaranteed Value Operator Ear
24
AR19 / 968982102
Honda GX120K1HX2 4 hp* / 2.98kW Belt ...installed in the final machine will depend on the operating speed, environmental conditions and other variables. Mass production engines may differ from this value.
Actual power output for the engine model...Bearings
Rear Tires Front Tire Aeration Tines Aeration Width Hole Pattern Core ...
Operation Manual - Page 27
...Address:
Husqvarna Turf Care 401 North Commerce Beatrice, NE 68310 USA Notified Body:
TUV SUD Industrie Service GmbH Westendstrasse 199 D-80686 Muenchen
27 Aerator Machine ...instructions. Take care of them as an addendum to special requirements for any of the states, (California emission rules etc.). This is included as they are placed on the engine and/or in the Engine manual...
Husqvarna AR19 Reviews
We have not received any reviews for Husqvarna yet.