Poulan PO16542LT Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PO16542LT manuals!
Problems with Poulan PO16542LT?
Ask a Question
Free Poulan PO16542LT manuals!
Problems with Poulan PO16542LT?
Ask a Question
Most Recent Poulan PO16542LT Questions
Steering
how to adjust the front wheels on a po16542lt poulan lawn mower
how to adjust the front wheels on a po16542lt poulan lawn mower
(Posted by joebruno45 9 years ago)
Won't Engage Drive
it won't engage the drive...almost like the clutch won't work..its in gear and goes nowhere
it won't engage the drive...almost like the clutch won't work..its in gear and goes nowhere
(Posted by 71shelly 11 years ago)
Popular Poulan PO16542LT Manual Pages
User Manual - Page 1
ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan.com
425179 10.30.08 BAD
Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
5000
OPERATOR'S MANUAL
MODEL:
PO16542LT
LAWN TRACTOR
WARNING:
Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in U.S.A.
User Manual - Page 2
... not mow near rotating parts or under the influence of riding mower-related injuries. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS ...blades.
• Keep all times.
• Only allow the mower deck to occur. Uneven terrain could suddenly roll over accidents, which could be picked up and down slopes.
they can result in . Shut off blades, set...
User Manual - Page 4
... 24 TROUBLESHOOTING 25-26 WARRANTY 27
4 CONGRATULATIONS on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any problem you the best possible dependability and performance.
Please read and retain this manual. PRODUCT SPECIFICATIONS
Gasoline...
User Manual - Page 6
Standard wrench sizes are listed.
(1) 1/2" wrench (1) 3/4" wrench
Pliers
Utility knife Tire pressure gauge
When right or left hand is mentioned in this manual, it means when you are ... must be tightened securely. TOOLS REQUIRED FOR ASSEMBLY
A socket wrench set aside for any additional loose parts or cartons and remove. INSTALL STEERING WHEEL • Position front wheels of the tractor so they...
User Manual - Page 8
... is operating properly. CHECK BRAKE SYSTEM
After you start the engine.
✓ Be sure brake system is in the Service and Adjustments section of this manual. ASSEMBLY
CHECK TIRE PRESSURE
The tires on tires.
Verify that the brake is important for replacing motion and mower blade drive belts in safe operating condition.
✓ Be sure Operator Presence...
User Manual - Page 16
...blades.
Using a blade not approved by the operator to stop at highest speed in the Service and Adjustments section of this manual). IMPORTANT: To ensure proper assembly, center hole in blade...POSITION
ENGINE "ON" POSITION (NORMAL OPERATING)
BLADE CARE
For best results mower blades must align with stamped "THIS SIDE UP" facing
deck and mandrel assembly. Replace bent or damaged blades.
...
User Manual - Page 18
... gap setting is required.
• With engine cool, remove filter and plug fuel line sections.
• Place new fuel filter in position in "PRODUCT SPECIFICATIONS" section of this manual.
See Engine Manual. IN-LINE FUEL FILTER (See Fig. 12)
The fuel filter should be kept free of dirt and chaff to prevent engine damage from tractor and mower...
User Manual - Page 21
...Contact a qualified service center.
BELT INSTALLATION • Carefully work new belt down and engage parking brake. 2. Park tractor on level surface. tion of removal instruc-
BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). SERVICE AND ADJUSTMENTS
TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 18)
The mower blade drive belt may also check...
User Manual - Page 23
..., see engine manual.
If adjustment is not adjustable. INTERLOCKS AND RELAYS
Loose or damaged wiring may cause your tractor to negative (-) terminal with 20 amp automotive-type plug-in fuse. Slide terminal cover over terminal.
• Connect BLACK grounding cable to an authorized service center for repair and/or adjustment. TO REPLACE FUSE
Replace with remaining...
User Manual - Page 24
... before storing in the Maintenance section of this manual). • Inspect and replace belts, if necessary (See belt re- OTHER
• Do not store gasoline...ENGINE WHILE IN STORAGE.
• Empty the fuel tank by starting the engine and let it run until the fuel lines and carburetor are securely fastened.
placement instructions in the Service and Adjustments section of this manual...
User Manual - Page 26
....
26 Wet grass. 4. Poor cable connections. 3. Tighten blade bolt. 7. TROUBLESHOOTING POINTS
PROBLEM
CAUSE
Engine dies when tractor is shifted into reverse
1. Mower drive belt worn. 9. Reinstall blades sharp edge down. 10. Replace bulb(s) or lamp(s). 3. If not corrected, contact an authorized service center/ department. Allow grass to ROS "ON" position. Check wiring and...
User Manual - Page 30
...local dealer for parts and service should be necessary during the life of HOP is to your local dealer(s). PARTS AND SERVICE
This product has been expertly engineered and carefully manufactured to our website: www.poulan.com/support.asp
NOTE:
HOP provides parts and service through its products. For Techical Assistance: call 1-800-849-1297 • For replacement parts, have available...
Parts List - Page 2
... - - 138311 - - 425001 - - 424992
DESCRIPTION
Decal, Hood LH Decal, Caution, Battery Decal, Fender Warning Eng/Fr Decal, V-Belt Sch. NO. MODEL NUMBER PO16542LT (96012008900), PRODUCT NO. 960 12 00-89 DECALS
7
12
9
2 14
15
5
5
16
4 3
17
KEY PART NO. inches 1 inch = 25.4 mm
2 Manual, Operator's E&F Manual, Parts E&F
WHEELS & TIRES
1
2
5,8
7
6
4,10 3,9 11
wheel_1
KEY...
Parts List - Page 11
...). inches 1 inch = 25.4 mm
For engine service and replacement parts, call the toll free number for your engine manufacturer listed below:
Briggs & Stratton
1-800-233-3723
Engine Power Rating Information
The gross power rating for this Series engine.
11 This difference is due to a variety of higher rated power for individual gas engine models is affected by, among other things...
Parts List - Page 17
... and blade bolt/washers not included) Replacement Mower, Complete...Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 10 Ga. ging and discharging)
- - 134149
Blade, Mulching 42" Std (for bag- inches 1 inch = 25.4 mm
17 MODEL NUMBER PO16542LT (96012008900), PRODUCT NO. 960 12 00-89 MOWER DECK
KEY PART...
Poulan PO16542LT Reviews
We have not received any reviews for Poulan yet.