Poulan XT627ES Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan XT627ES manuals!
Problems with Poulan XT627ES?
Ask a Question
Free Poulan XT627ES manuals!
Problems with Poulan XT627ES?
Ask a Question
Popular Poulan XT627ES Manual Pages
User Manual - Page 1
Always Wear Eye Protection During Operation
437920 08.25.10 JA Printed in serious injury. Failure to do so can result in the U.S.A.
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
XT627ES
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
...trouble...instructions on clothing, change clothing immediately.
5. containers on a truck
thrower for hidden hazards or traffic.
(c) Fill fuel tank outdoors with the controls and the proper use on sidewalks, driveways and other engine parts become extremely hot during operation or while performing an adjustment or repair to prevent accidental starting when setting...when specifically ...
User Manual - Page 3
...storing in any problem you to 50...SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 18
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 19
OPERATION 7-12
REPAIR PARTS...manual.
Maintain or replace safety and instruction labels, as hot water heaters, space heaters, or clothes dryers. Do not run .
16.
SERIAL NUMBER
DATE OF PURCHASE
THE MODEL...
User Manual - Page 11
...information. Acidic gas can be reversed, providing additional service before storage of an engine while in the fuel... problems, the fuel system should be used within 30 days to bottom of this manual. Use fresh fuel next season. See Storage Instructions ... aanndd wwaaiitt ffoorr aallll mmoovviinngg ppaarrttss ttoo ssttoopp..
22.. Replace a damaged or worn scraper bar. Do not overfill. ...
User Manual - Page 13
... be sure they begin to the operator. Check engine oil level. 2. TIRES • Maintain proper air pressure in the Service and Adjustments section of special construction
to be replaced by original equipment manufacturer
local parts dealer. Check controls to slow leaks, tire sealant may be purchased from wear. (See "TO REMOVE BELT COVER" in...
User Manual - Page 14
...approximate capacity see "PRODUCT SPECIFICATIONS" section of continuous use only Ronex ED #1 grease. SPARK PLUG
Replace spark plug at the factory. Install drain plug and tighten securely.
5. Refill engine with API service classification SG-SL. MUFFLER
Inspect and replace corroded muffler as it cannot come in a suitable container.
4.
ENGINE
See engine manual. Tighten oil fill cap...
User Manual - Page 16
... thrower should be raised and discharge chute to the snow thrower. SERVICE AND ADJUSTMENTS
TO REPLACE BELTS (See Fig. 20)
The auger and traction drive belts are...manual.
4. REMOVE BELT COVER - REMOVE AUGER BELT from snow thrower.
3. Remove bolt, flat washer securing pulley to the ground. Install flat washer, bolt and tighten securely (41-47 N-m torque). WARNING: Belt replacement...
User Manual - Page 17
... the engine above the factory high speed setting can be affected at altitudes up to suspected carburetor problems, take your local parts dealer.
Adjust until cable is not adjustable.
...manual.
NOTE: To seal punctures or prevent flat tires due to slow leaks, tire sealant may be sure to a qualified service center. Tire sealant also prevents tire dry rot and corrosion. SERVICE...
User Manual - Page 18
... Store in the Maintenance section of this manual).
2. Inspect moving parts for 30 days or more.
NOTE: Fuel...replace with a suitable protective cover that all rusted or chipped paint surfaces; STORAGE
Immediately prepare your unit for storage at least 10 minutes after adding stabilizer to allow the stabilizer to gasoline in the Service and Adjustments section of this manual...
User Manual - Page 19
... to FULL position. 6. Prime as instructed in the Operation section of fuel. 4. Wait a few minutes before restarting, DO NOT prime. 8. Throwing too much snow. 3. Reconnect spark plug wire. 2. Water in OFF position. 6. Excessive vibration
1. Replace damaged parts. If vibration remains, contact an authorized service center/department.
Check / replace drive belt. Drive belt is...
User Manual - Page 20
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
20 MODEL XT627ES (96192004501)
AUGER HOUSING / IMPELLER ASSEMBLY
5
15 14
4
11 6
11
16
12
13 11
3 12
10...)
01.07.026-D
NOTE: All component dimensions given in U.S. REPAIR PARTS
SNOW THROWER -
User Manual - Page 25
...ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL XT627ES (96192004501)
CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *7
KEY NO.
1 2 *3 *4 *5 *6 *7
PART NO.
428272 17501010 420678 ... and void your warranty.
25 NOTE: All component dimensions given in U.S. REPAIR PARTS
SNOW THROWER -
User Manual - Page 26
...
2
427513X431 PIVOT SUPPORT WELDMENT
3
428867
SCREW 5/16−18 X .750
4
4
17000616
SCREW 3/8−16 X 1.00
3
4
4
3
4
01-05-013-A
NOTE: All component dimensions given in U.S. MODEL XT627ES (96192004501)
4
4 3
2
3
4
4
3
3
KEY PART NO. NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS HANDLES
SNOW...
User Manual - Page 37
...LEV/PWRST OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S.
Failure to do so could be hazardous, damage your snow thrower and void your warranty.
37 MODEL XT627ES (96192004501)
5 2 6
3 1
KEY NO.
1 2 3 4 5 6 - - - inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS DECALS
1 4
SNOW...
User Manual - Page 40
...with the instructions furnished.
4....you specific legal ...will repair or replace,...installation, delivery damage, or to an authorized service dealer. Battery Warranty: On products equipped with a Battery, we will replace, without charge for parts...Service Dept. 9335 Harris Corners Parkway Charlotte, NC 28269 USA
In Canada contact:
HOP 5855 Terry Fox Way Mississauga, Ontario L5V 3E4
giving the model...
Poulan XT627ES Reviews
Do you have an experience with the Poulan XT627ES that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!