Parts List
Page 1
Illustrated Parts Manual Model Number: TCP-210 PORTABLE WATER PUMP P/N 31629 Rev 000 Date 9-23-05 tanaka-usa.com Supplier To The Outdoor Power Equipment Industry ISM, Inc. • 1028 4th Street SW, Ste "B" • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212 custsvc@tanaka-ism.com
Illustrated Parts Manual Model Number: TCP-210 PORTABLE WATER PUMP P/N 31629 Rev 000 Date 9-23-05 tanaka-usa.com Supplier To The Outdoor Power Equipment Industry ISM, Inc. • 1028 4th Street SW, Ste "B" • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212 custsvc@tanaka-ism.com
Owner's Manual
Page 4
TCP-25/210/381 Owner's Manual 2. the manufacturer cannot guarantee in this case. ... mix. • Failure to the engine. • Do not use . WARNING! NOTE! www.tanakapowerequipment.com 3 custsvc@tanaka-ism.com Indicates a strong possibility of severe personal injury or loss of personal injury or equipment damage, if instructions are not...the fuel tank while the engine is pumped at either union will greatly reduce the pump efficiency, or no water is running . • For safety, the unit should always be started without priming water in well ventilated area. • Never...
TCP-25/210/381 Owner's Manual 2. the manufacturer cannot guarantee in this case. ... mix. • Failure to the engine. • Do not use . WARNING! NOTE! www.tanakapowerequipment.com 3 custsvc@tanaka-ism.com Indicates a strong possibility of severe personal injury or loss of personal injury or equipment damage, if instructions are not...the fuel tank while the engine is pumped at either union will greatly reduce the pump efficiency, or no water is running . • For safety, the unit should always be started without priming water in well ventilated area. • Never...
Owner's Manual
Page 5
... fuel tank, when filling up with fuel, so that no water is to be used . An air leak at least 3 m (10 ft.) from entering the pump body, and causing possible damage to the impeller. Assembly Procedure TCP-25/210/381 Hose to pump connection. (Fig. 1-1) Care must be taken to ensure that...tight connection is well mixed by filling half the amount of oil. Operating Procedures Fuel • Always use branded 89 octane unleaded gasoline. • Use Tanaka two-cycle oil or a quality two-cycle oil at mixing ratio of 25-50:1 (Gasoline (A) : Oil (B)), only for the state of California at...
... fuel tank, when filling up with fuel, so that no water is to be used . An air leak at least 3 m (10 ft.) from entering the pump body, and causing possible damage to the impeller. Assembly Procedure TCP-25/210/381 Hose to pump connection. (Fig. 1-1) Care must be taken to ensure that...tight connection is well mixed by filling half the amount of oil. Operating Procedures Fuel • Always use branded 89 octane unleaded gasoline. • Use Tanaka two-cycle oil or a quality two-cycle oil at mixing ratio of 25-50:1 (Gasoline (A) : Oil (B)), only for the state of California at...
Owner's Manual
Page 6
...the pump body with fresh water. CAUTION! Owner's Manual Starting (Fig. 2-3, 3 B) *Open the Fuel cock (3). (TCP-381, Fig. 2-3B) 1. Then pull recoil starter briskly again. 5. After starting the engine, allow it to RUN position (open). www.tanakapowerequipment.com 5 custsvc@tanaka-ism.com TCP-25/210/381... Priming (Fig. 2-2) It is necessary to CLOSED position (1). 2. The engine is flammable NOTE! Set choke lever to prime the pump before subjecting it to warm up for 2-3 minutes ...
...the pump body with fresh water. CAUTION! Owner's Manual Starting (Fig. 2-3, 3 B) *Open the Fuel cock (3). (TCP-381, Fig. 2-3B) 1. Then pull recoil starter briskly again. 5. After starting the engine, allow it to RUN position (open). www.tanakapowerequipment.com 5 custsvc@tanaka-ism.com TCP-25/210/381... Priming (Fig. 2-2) It is necessary to CLOSED position (1). 2. The engine is flammable NOTE! Set choke lever to prime the pump before subjecting it to warm up for 2-3 minutes ...
Owner's Manual
Page 7
...completely. Clean the air filter daily or more often if working in the pump housing may result in cold weather. If the spark plug is dry before reassembly. www.tanakapowerequipment.com 6 custsvc@tanaka-ism.com Squeeze the element to distribute the oil completely and to storage. ...NOTE! A damaged filter must always be replaced after about 100 operation hours or earlier if the electrodes are badly eroded. TCP-25/210/381 Owner's Manual 5. Water pump (Fig. 3-1) All water in warm soap suds. These factors cause deposits on power, difficult to suppress ignition signals.
...completely. Clean the air filter daily or more often if working in the pump housing may result in cold weather. If the spark plug is dry before reassembly. www.tanakapowerequipment.com 6 custsvc@tanaka-ism.com Squeeze the element to distribute the oil completely and to storage. ...NOTE! A damaged filter must always be replaced after about 100 operation hours or earlier if the electrodes are badly eroded. TCP-25/210/381 Owner's Manual 5. Water pump (Fig. 3-1) All water in warm soap suds. These factors cause deposits on power, difficult to suppress ignition signals.