Hayward Power-Flo LX Support Question
Hayward Power-Flo LX Support Question
Find answers below for this question about Hayward Power-Flo LX.Need a Hayward Power-Flo LX manual? We have 3 online manuals for this item!
Question posted by thujde01 on June 14th, 2014
What Is The Flow Rate Of A Hayward Sp1515 Pump?
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward Power-Flo LX Manual Pages
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 1
...Open all times. 2. Priming time depends on power and allow a reasonable time for priming. IS-1580-TL-98
HAYWARD HIGH-PERFORMANCE PUMPS
INSTALLATION AND OPERATING INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
When ... Never operate the pump without water. Failure to the pool as large or larger than discharge pipe. NOTE: NSPI-4 Article V, standard for the HP (KW) rating and distance from lawn...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 2
...SPX1500-RA
SPX1500-RA
SPX1500-LX
SPX1500-LX
SPX1500-LX
SPX1500-P
SPX1500-P
SPX1500-P
SPX1500...-D-2
SPX1500-D-2
SPX1500-D-2
SPX1700-FG
SPX1700-FG
SPX1700-FG
SPX1500-X1
SPX1500-X1
SPX1500-X1
SPX1550-WA-1
SPX1550-WA-1
SPX1550-WA-1 DESCRIPTION
Bolt, No. 10-24 Hex. Head Housing Cover Housing O-Ring Impeller Seal Assembly Pump...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 3
...-polished surface facing out. AMPS
15
15
20
20
20
20
A separate electrical circuit, utilizing a rating as to keep shaft from the impeller.
8. The impeller is recommended. Reconnect pump to piping system.
SEAL CHANGE INSTRUCTIONS
Power Flo™ LX Series with strainer attached) by removing the eight (8) housing bolts and nuts which fasten housing cover...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 4
... seated. LOW FLOW - Generally, check for : 1. Clean strainer basket regularly. Shut off , under normal conditions, before heat damage build-up to the factory
without the expressed written authorization of Hayward Pool Products, Inc. SERVICE & REPAIRS Consult your local authorized Hayward dealer or service center. Binding and overload. (Amperage reading)
NOTE:
Your Hayward pump motor is...
SP1575X15 - Page 1
... adequate for aboveground and on-ground pools, advises that components such as the filtration system, pumps and heater be displaced from power source. The advanced design reduces required maintenance to clean.
If cord connected, use only a properly-grounded receptacle. NOTE: NSPI-4 Article V, standard for the motor's HP (KW) rating and distance from the suction...
SP1575X15 - Page 2
...DESCRIPTION
Bolt, No. 10-24 Hex. Motor Strainer Housing O-Ring Basket Strainer Cover O-Ring Strainer Cover Drain Plug w/Gasket Strainer Shim Ring (Horizontal Outlet Pumps Only)
NO. REQ'D.
7 1 1 1 1 1 7 1 1 1 1 1 1 2 1
PART NUMBER MODEL
SP1575X15 (With Strainer) SPX1500N2 SPX1500B SPX1500H SPX1500F SPX1500KA SPX1500AA SPX1500Y2 SPX1515Z1E SPX1500CA SPX1500W SPX1250R SPX1500P SPX1500D2 SPX1700FG...
SP1575X15 - Page 3
...the spring seal and pull it off electrical power before restarting.
*For A.O. b. Clean and lubricate the impeller hub shaft and pump housing seal recess with strainer attached) by...sure to pump housing with ceramic seat inside, into clear plastic seat retainer-polished surface facing out. SINGLE PHASE
MOTOR
KW
HP
VOLTS
CIRCUIT BREAKER RATINGS-AMPS
BRANCH FUSETRON RATINGS-AMPS
...
SP1575X15 - Page 4
... level is equipped with water and that pool water level is up to improper mounting, etc. 4. MOTOR HUMS, BUT DOES NOT START- Binding of obstruction.
Open pump and check for : 1. LOW FLOW-Generally, check for : 1. Air leak in suction piping.
F. SERVICE & REPAIRS
Consult your local authorized Hayward Dealer or service center. Manually check rotation...
Owners Manual - Page 1
...severe injury and/or death. Hayward Pool Products 620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995 www.haywardnet.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
1 When ...indicates special instructions that are unpredictable and unsafe.
ISPFSERIES Rev G
PowerFlo LX™ / PowerFlo II™ / EP Pump Series
Owner's Manual
Contents
Product Warnings 2 Installation 4 Start-...
Owners Manual - Page 2
... - o The maximum system flow rate shall not exceed the flow rating as the filtration system, pumps and heater must be positioned to prevent children from using them as a means of the pump housing and cover, and/or filter housing and clamp due to the pool. o Installation of the limb.
Failure to use Pool or Spa if any suction outlet...
Owners Manual - Page 3
..., push the test button. The GFCI should be readily disassembled for bonding requirements. If the GFCI interrupts power to a gas supply line. CAUTION - SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
3 Before servicing pool and spa circulation system, filters manual air relief valve must be in this electrical equipment. WARNING - To reduce the...
Owners Manual - Page 4
...
Piping -
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
4 Pump motors require free circulation of TFE tape, and re-install connector.
vibration free.
The pump suction and outlet ports ...pump and run is only necessary to tighten fittings enough to right).
level -
Installation Instructions
Pump Location
The PowerFlo LX™ and EP series pumps MUST be installed below the pool...
Owners Manual - Page 5
.... Fittings
Fittings restrict flow. For better efficiency...power supply. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
5
Voltage
Voltage at full load, consult power...power before figuring wire and circuit breaker sizes. (NOTE: If unsure how to pool users. Electrical
WARNING - Ground motor before
working on end of swimming pool, spa, or hot tub, and to
ground pump... of rated voltage when motor is ...
Owners Manual - Page 6
.... To avoid dangerous or fatal electrical shock hazard, turn OFF power to anyone nearby. Once the pump is being pressure tested, be sure pressure has been released before...a dry enclosure.
Store pump in your pool/spa system. WARNING - CAUTION -
fill strainer and pump with water. Clean and lubricate strainer cover O-ring with water to pool/spa system directly in front ...
Owners Manual - Page 7
...shutdown period. Install all electrical power service to base. 4. ...pool to pool. Shut off water flow to pump by closing appropriate valves or by pushing clip down onto grooved pump cover coupling. Remove the strainer by sliding strainer housing onto pump...pump cover, exposing the impeller. 4. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
7 Clean and lubricate the impeller stem and the pump...
Owners Manual - Page 8
... position. 2. Low Flow -
backwash as per manufacturer's instructions; Air leak in suction. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
8 open and not blocked, that pool water level is again.... Plugged or restricted impeller or impeller sheared off if power supply drops before heat damage can confirm this manual.) 3. If pump develops a vacuum, check for clogging or obstruction in ...
Owners Manual - Page 9
... out the grease causing bearing to wear or damage. Put a rubber pad under metal mounting feet. 4. Foreign matter in pool, and
unrestricted discharge return lines. Inspect strainer cover gasket regularly and replace as necessary.
Hayward pumps have self-lubricating motor bearings and shaft seals. No lubrication is necessary. Keep motor clean.
Owners Manual - Page 10
... SPX1250RA SPX1500P SPX1500D2A SP1516 SPX1700FG SPX1515C
SPX1250WA SPX1550WA1
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
10
Motor (for SW1585X20) - 2 HP...----
Motor (for SP1750) - 1/2 HP
----
---- Model No. on
6 Impeller
Original Equipment
Original Equipment
7 Pump Housing
SPX1500AA
SPX1580AAP
8 Housing Nut, No. 10-24 Hex Head
SPX1500Y2 (7 Req'd.)
SPX1500Y2 (8 Req'd.)
Motor ...
Owners Manual - Page 11
... of incidental or consequential damages, so the above constitutes the entire warranty of Hayward Pool Products with respect to its products to you.
The limited warranty excludes damage from... repair or installation labor or any Acts of God. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
11 HAYWARD® Pool Products Limited Warranty
To original purchasers of this Warranty Certificate (upper ...
Owners Manual - Page 12
... Other
New Installation
Replacement
Installation for:
In Ground
Above Ground
Spa
Hayward is located on all e-mail communications regarding Hayward® Equipment or promotions.
PowerFlo LX™ / PowerFlo II™ / EP Pump Series Warranty Card Registration
Register online at www.hayward.com
Please Print Clearly:
Years Pool has been in service
First Name Last Name 1 year...
Similar Questions
Power Flo Lx Model Sp1510z1xbc Hums Will Not Start
I have a power flo lx model sp1510z1xbc when i 1st turned on it started for a minute I shut it off a...
I have a power flo lx model sp1510z1xbc when i 1st turned on it started for a minute I shut it off a...
(Posted by christinedomon77 5 years ago)
I Am Looking For A Hayward Power Flo Lx Pump Model Sp1510-2-xes. Can You Help?
(Posted by gregjaws 8 years ago)
How To Rotate Pump Return Hayward Power Flo Lx 90 Degree To 45
(Posted by lensy 9 years ago)
Hayward Pool Pumps Power Flo Lx Power Switch Won't Shut Off
(Posted by JLCASdm86 10 years ago)
How To Prime Hayward Power Flo Lx Above Ground Pool Pump
(Posted by meriosdeluc 10 years ago)