Hoveround MPV5 Support Question
Hoveround MPV5 Support Question
Find answers below for this question about Hoveround MPV5.Need a Hoveround MPV5 manual? We have 1 online manual for this item!
Question posted by momof4414 on February 2nd, 2021
Mpv5 Joystick Controller Controller Flashes Once Then It Goes Off?
fully charged batteries. New batteries once it goes off it won't come back on for awhil
Current Answers
Answer #1: Posted by waelsaidani1 on February 14th, 2021 9:52 PM
waelsaidani1
Member since:
May 12th, 2013 Points: 19,501,797
Member since:
May 12th, 2013 Points: 19,501,797
If a fault occurs, you can find out what has happened by counting the number of bars on the battery gauge that are flashing. VSI Controller 1 bar: Low battery or a bad connection. Try recharging the battery. 2 bars: Bad connection to left motor. 3 bars: Short circuit, left motor to battery. 4 bars: Bad connection to right motor. 5 bars: Short circuit, right motor to battery. 6 bars: Check if battery charger is still connected to controller or controller fault. 7 bars: Joystick fault. 8 bars: Controller fault. 9 bars: Problem with brake circuit. Check that manual brake release levers are in the drive position and power seat lift is lowered (if equipped). 10 bars: An excessive voltage to the control system. This is usually caused by a poor battery connection. 10 bars Rapid Flash: Powered up when joystick deflected. Restart with joystick in neutral. 10 bars, Three Second Blink: Control is in sleep mode. Press OFF/ON twice to restart. Speed Bars Cycling: Controller locked. Speed Bars Flashing: Power seat lift is inhibiting drive. Lower the seat.
Related Hoveround MPV5 Manual Pages
User Manual - Page 5
...General Warnings / Before You Use Your MPV5 . . . . . 8 Hoveround® MPV5 / Diagram 12 Hoveround® MPV5 / Warning Labels 13
Chapter 1 Operating Instructions 15 Entering Your MPV5 15 Driving Your MPV5 16 Joystick Controller 19
Chapter 2 Batteries and Charging 22 Caring For Your Batteries and Charger 22 Battery Replacement 24 Charging Your Batteries 24
Chapter 3 Manual Brake Release...
User Manual - Page 6
...and Adjustments 36
Chapter 5 Options and Accessories 40
Chapter 6 Routine Maintenance 44
Chapter 7 Disassembling and Reassembling Your MPV5 47 Removing and Replacing Your Controller 47 Removing and Replacing the Seat 48 Removing and Replacing Batteries 50
Chapter 8 Electromagnetic Interference (EMI 52
Chapter 9 Appendixes 55 Appendix A Programmable Parameters 55 Appendix B Fault Codes...
User Manual - Page 8
... warnings. Never modify your power wheelchair, we recommend that the power is a battery-operated motor vehicle. To avoid serious... that the speed/response control be set the joystick/controller speed/response control to drive your wheelchair, and do not use... from the Americans with your Hoveround® MPV5 power wheelchair.
Always use specifically with Disabilities Act, which...
User Manual - Page 12
Hoveround-MPV5ManualRevM 1/17/14 10:36 AM Page 12
Hoveround® MPV5 - Diagram
D82008753M 10/13 Diagram
Adjustable Arm Rest
•
Joystick Controller •
Seat Belt •
• Battery Cable Connection (if equipped)
•
Seat
(Swivel Optional)
• •
•
Batteries
Brake Release Levers
Dual Motor Front Wheel Drive
•
• Anti Tip Wheels
•
...
User Manual - Page 13
... Owner's Manual before exiting the seat or changing the joystick position. Hoveround-MPV5ManualRevM 1/17/14 10:36 AM Page 13
Hoveround® MPV5 - D82008753M 10/13
REFER TO OWNER'S MANUAL FOR ...INFORMATION This vehicle has a tested immunity level of at least 20V/m.
•
Turn the power off before operating vehicle. Warning Labels
For New...
User Manual - Page 15
Entering Your MPV5
1. To locate the "ON/OFF" button on your joystick controller, see the section on joystick controller (page 18) to drive the power wheelchair. Be sure the power is OFF before entering or exiting your power wheelchair.
2.
Footplate Down Footplate Up D82008753M 10/13
Chapter 1 15 Hoveround-MPV5ManualRevM 1/17/14 10:36 AM Page 15
Chapter...
User Manual - Page 16
...control of joystick to minimum while learning to drive this power wheelchair with the seat-back reclined makes it difficult to maintain proper positioning in the seat.
Do not attempt to drive the power wheelchair.../13 Get into or out of the seat.
3. Driving Your MPV5 Power Wheelchair
• Sudden change in motion, loss of control, or tip-over may cause a collision or fall or tip-...
User Manual - Page 17
... on.
Allow plenty of the fault. Observe that , when released, the joystick returns to the right. Move the joystick lever fully right. The power wheelchair will move the joystick forward. With the power turned OFF, hold the joystick and move commands if a fault condition is flashing, the controller has sensed a fault condition. A "click" will cause the chair to...
User Manual - Page 18
...of your power wheelchair and the limits of the forward movement.
8. For each increase of control or tip-over and can result in the center position when the controller is about half ...Control, be sure you practice several stops until you may want to the right.
9.
Driving on .
18 Chapter 1
D82008753M 10/13 If the joystick is indicated. If you move the joystick gently back and to the new...
User Manual - Page 19
... - When all systems are located on and off if left idle for 5 minutes. Speed Down - Battery Gauge - D82008753M 10/13
Chapter 1 19 Controls speed and direction. This will cause the power wheelchair to stop quickly move the joystick from the forward position to turn the power on.
5. ON/OFF - Press to restart. Indicates the...
User Manual - Page 25
... NOT attempt to use extension cords to power the charger.
• DO NOT connect the charging cables directly to the battery.
• ONLY USE to charge a frozen battery. Explosive gas is emitted during the charging process.
• DO NOT smoke around your power wheelchair or charger when charging.
• DO NOT attempt to repair or open flame.
User Manual - Page 26
... charger is equipped with an off button, ensure that the charger is equipped with the joystick controller in the OFF position.
3. Follow the specific instructions for your charger. If it is fully seated in place. When the batteries are charged, and/or you are ready to use the charger.
2. Hoveround-MPV5ManualRevM 1/17/14 10:36...
User Manual - Page 27
... the charger, indicating power is fully plugged into the controller, the batteries are connected. A light will illuminate on , the charger is in the charge mode and the cable is available. When two red lights are on , please check to be fully charged and the green light is red, the batteries are being charged.
3. If the light does not...
User Manual - Page 29
... improper positioning. Do not attempt to the joystick and speed/response controller.
• Inspect all areas of skin ...wheelchair.
• Driving with seat-back reclined. D82008753M 10/13
Chapter 4 29 Press the power button to OFF before making any adjustments to your power wheelchair, a good view of the joystick/controller and comfortable hand access to drive this power wheelchair...
User Manual - Page 41
Your power wheelchair contains a lock-out feature that prevents driving when the seat is on.
The MPV5 will permit the ...Do not attempt to recline approximately 45 degrees. When seat is lit, move the joystick forward to raise the seat, back to activate the PSL mode (see where you ... indicator light is fully down, press either seat symbol button to lower. D82008753M 10/13
Chapter 5 41
User Manual - Page 45
...45
Owner Maintenance
Daily • Check drive tires. • Charge batteries (or as required). • Check that the seat belt latches...optional PSL is raised, and the controller is ON. • Check that the rubber boot around joystick is intact. • Check that ...lock engages and holds
(if equipped). • Clean power wheelchair. (See page 42 for instructions.)
A worn or improperly latching...
User Manual - Page 46
... this area. Top Cover - Wipe with a cotton swab, using a mild detergent.
Food-type contaminants can be removed from around the joystick boot by carefully cleaning with a damp cloth or towel, using a mild detergent. The controller body can be wiped with liquid. Hoveround-MPV5ManualRevM 1/17/14 10:37 AM Page 46
Cleaning your...
User Manual - Page 52
...wave sources) can be incorporated to the owner's manual for all power wheelchairs and scooters are invisible and their strength at least a 20 V/m immunity ...MPV5 power
52 Chapter 8
D82008753M 10/13 All electrical conductors act as to a certain intensity. Each power wheelchair can also permanently damage the power wheelchair's control system. It can resist EMI up to override the control...
User Manual - Page 58
... 10:37 AM Page 58
New VSI Controller
1 flash: The battery needs charging or there is a bad connection to the controller. Speed Bar Cycling: Controller locked. Make sure that the manual release levers are in the center position before switching on the controller.
8 flashes: A controller fault is usually caused by a poor battery connection. Check that the joystick is in the drive position...
User Manual - Page 59
...the joystick.
Move the joystick in reverse until the controller beeps. Move the joystick forward until the controller beeps. VSI Controller and new VSI Controller
1. To unlock, turn the controller on your MPV5. Please refer to the appropriate instructions for the controller on . There will be a long beep that indicates the controller is unlocked. Then move the joystick in...
Similar Questions
On My Joystick There Are Flashing Lights That Were Never There Before In The Seq
(Posted by Anonymous-172561 1 year ago)
Control Panel Wire Diagrams
Had to replace the control panel and I want to make sure that the wires are on the correct places
Had to replace the control panel and I want to make sure that the wires are on the correct places
(Posted by slestep59 8 years ago)
How Do I Open Mpv 5 Controller Housing?
I need to change charger connector in housing
I need to change charger connector in housing
(Posted by W4zwy 8 years ago)
Hoveround Teknique Xhd Controller Fault Light Is On. What Do We Do
Hoveround teknique xhd controller fault light is on. What do we do
Hoveround teknique xhd controller fault light is on. What do we do
(Posted by Wendynp 9 years ago)