Husqvarna YTH21K46 Support Question
Husqvarna YTH21K46 Support Question
Find answers below for this question about Husqvarna YTH21K46.Need a Husqvarna YTH21K46 manual? We have 2 online manuals for this item!
Question posted by hipolitomary005 on September 14th, 2017
No Spark No Start
Have a Husqvarna riding lawn mower that won't start, there's no spark even after replacing spark plug. I have been searching for a service manual for my model# 960430120 Husqvarna YTH21K46 riding lawn mower and electrical schematics but unable to find any online as another model # comes up instead.Has this model been deleted or is compatible with another model #. If you can direct me to how I can acquire these I would greatly appreciate it
Current Answers
Answer #1: Posted by waelsaidani1 on September 15th, 2017 2:03 AM
waelsaidani1
Member since:
May 12th, 2013 Points: 19,501,777
Member since:
May 12th, 2013 Points: 19,501,777
Hello here is a video guide on how to solve this problem: https://www.youtube.com/watch?v=lG2Sqp0FUTo
Related Husqvarna YTH21K46 Manual Pages
Owners Manual - Page 1
07002
YTH21K46
Owner's Manual
Gasoline containing up to 10% ethanol (E10) is acceptable for use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.
532 44 41-83 The use in this machine.
Owners Manual - Page 2
... build-up , transporting, adjusting or making repairs, always disconnect spark plug wire and place wire where it .
• Mow up...the riding mower safely enough to occur.
Operation on the slopes slow and gradual. WARNING: In order to prevent accidental starting when...hill in the manual before storage. Always
turn off engine and wait for all times.
• Only allow the mower deck to ...
Owners Manual - Page 3
...and down for Ride-On Mowers
III. If ...
V. Adjust and service as required. • Maintain or replace safety and instruction ...spark, or pilot light such as necessary.
• Be sure the area is extremely flammable and the vapors are sharp. Replace...Mower blades are explosive.
• Extinguish all nuts and bolts tight to stop or shift while on the slope.
• Avoid starting...
Owners Manual - Page 4
...service or repair this manual. Please read and retain this tractor.
Federal laws apply on your tractor. • Follow the instructions under "Maintenance" and "Stor-
Should you experience any problem you cannot easily remedy, please contact your nearest authorized service... Capacity:
W/ Filter: 51 oz W/O Filter: 35 oz
Spark Plug:
Champion RC12YC (Gap: .030")
Ground Speed (MPH): ...
Owners Manual - Page 10
...remain fully and centrally positioned in this section of manual). • Withmowerindesiredheightofcutposition,gaugewheels
should only be assembled so... 9
TO OPERATE MOWER (See Fig. 10)
Your tractor is approximately 1" to desired height. Start mower blades by the ...pointer tab (T) to
begin movement. For healthier and better looking lawns, mow often and after moderate growth. • For best...
Owners Manual - Page 14
... & ROS Systems A Check for wear. Change more often when mowing in the Service and Adjustments section of this manual.
• At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for Loose Fasteners C Check/Replace Mower Blades T Lubrication Chart 0 Check Battery Level R Clean Battery and Terminals
Clean Debris...
Owners Manual - Page 15
.... MANDREL ASSEMBLY BLADE
• The engine should not start unless the brake pedal is fully depressed, and the attachment...immediately.
BLADE REMOVAL (See Fig. 15)
• Raise mower to highest position to allow access to stop at 6-10 ...jelly.
• Reinstall battery (See "REPLACING BATTERY" in the Service and Adjustments section of this manual).
15 However, periodic charging of the ...
Owners Manual - Page 16
...servicing, contact your expected operating temperature. Check the crankcase oil level before starting...manual.
MUFFLER
Inspect and replace corroded muffler and spark...service center/department. ENGINE COOLING SYSTEM
To ensure proper cooling, make sure the grass screen, cooling fins, and other external surfaces of the drain valve.
• Refill engine with a blocked grass screen, dirty or plugged...
Owners Manual - Page 17
... this manual. Turn the water off .
Drive the tractor to a level, clear spot on your lawn, near
enough to a water spigot for your garden hose.
4. Make sure the attachment clutch control is secure. Debris can restrict clutch/brake pedal shaft movement, causing belt slip and loss of your garden hose to using mower again.
• Plug...
Owners Manual - Page 18
...; Place attachment clutch in contact with plug.
HAVE A TIGHT GRIP ON LIFT LEVER, LOWER IT SLOWLY AND ENGAGE IN LOWEST POSITION. NOTE: Be sure mower side suspension arms (A) are pointing forward before sliding mower under tractor. • Slide mower under right side of tractor. G
M
F
R Q
G
A
E
B
P C
K
LD
Fig. 20
18 SERVICE AND ADJUSTMENTS
WARNING: TO AVOID SERIOUS...
Owners Manual - Page 22
...
Keep sparks, flame and smoking materials away from your battery is too weak to start the engine, it should be connected first to prevent sparking from ...SERVICE AND ADJUSTMENTS
FRONT WHEEL TOE-IN/CAMBER
Your new tractor front wheel toe-in and camber is normal. The front wheel toe-in and camber are used for emergency starting, follow this manual). Insert square key. • Replace...
Owners Manual - Page 24
... carburetor. TRACTOR
Remove mower from dust and dirt. • Cover your tractor with gasoline in the Service and Adjustments section of this manual). • Inspect and replace belts, if necessary ... if using fuel stabilizer. CYLINDER(S)
• Remove spark plug(s). • Pour one season to another. • Replace your gasoline can starts to be used for storage, do not store battery...
Owners Manual - Page 25
... tank with fresh
gasoline and replace fuel filter. 8. Spark plug wire loose.
10.
Bent blade mandrel. 3. Tighten loose part(s). Bad spark plug. 5. Carburetor out of grass, leaves, trash under mower. 3. CORRECTION
1. Check all wiring. 7. Contact an authorized service center/department. Hard to start
1. Recharge or replace battery. 4. See "To Adjust Carburetor...
Owners Manual - Page 27
MODEL NUMBER YTH21K46 (96045002901...SEAT SWITCH (NOT OCCUPIED)
SHORTING CONNECTOR
BLACK
IGNITION UNIT
(OPTIONAL)
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. NON-REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
27
TRACTOR - ...
HEADLIGHTS
ORANGE
IGNITION SWITCH
POSITION CIRCUIT "MAKE"
OFF
M+G+A1
RUN/OVERRIDE B+A1
RUN
B+A1
START B + S + A1
L+A2
03107
3
6
2
5
1
4
CHASSIS HARNESS CONNECTOR ...
Owners Manual - Page 28
TRACTOR - - MODEL NUMBER YTH21K46 (96045002901), PRODUCT NO. 960 45 00-29
ELECTRICAL
T05S
2 1 91
8
90 27
99 100
26
28
55
22
79
21
87
34
40
33 30
24
27 43
42 41
25
16
71 With 12V Outlet Option
103 59
102 With Service Minder Option
29
46 105
28
Owners Manual - Page 29
...-16 Washer 9/32 x 7/8 x 16 Ga.
102 532 40 44-54 Harness Pigtail
105 532 40 75-68 Switch Reverse
NOTE: All component dimensions given in U.S. MODEL NUMBER YTH21K46 (96045002901), PRODUCT NO. 960 45 00-29
ELECTRICAL
KEY PART NO. NO.
Owners Manual - Page 30
MODEL NUMBER YTH21K46 (96045002901), PRODUCT NO. 960 45 00-29
CHASSIS
297 208
15
204
18
3
203
206 234
137 5
176
176
214 14
234 137 176 175 ...
Owners Manual - Page 35
... Engine Pulley Engine Tank Fuel Cap Asm Control Throttle Screw # 10 x 0.750 Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Gasket Tube Drain Oil... 1 inch = 25.4 mm
For engine service and replacement parts, call the toll free number for your engine manufacturer listed below:
Kohler Co.
1-800-544-2444
35 MODEL NUMBER YTH21K46 (96045002901), PRODUCT NO. 960 45 00-...
Parts List - Page 2
...REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
27 MODEL NUMBER YTH21K46 (96045002601), PRODUCT NO. 960...SWITCH (NOT OCCUPIED)
SHORTING CONNECTOR
BLACK
IGNITION UNIT
(OPTIONAL)
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
BLUE
HOUR METER
BLACK
BLUE
FUEL...SWITCH
POSITION CIRCUIT "MAKE"
OFF
M+G+A1
RUN/OVERRIDE B+A1
RUN
B+A1
START B + S + A1
L+A2
03107
36
25
14
CHASSIS HARNESS CONNECTOR ...
Parts List - Page 10
...
1 inch = 25.4 mm
For engine service and replacement parts, call the toll
free number for your engine manufacturer listed below:
Kohler Co.
1-800-544-2444
35 MODEL NUMBER YTH21K46 (96045002601), PRODUCT NO. 960 45 00-...Engine Pulley Engine Tank Fuel Cap Asm Control Throttle Screw # 10 x 0.750 Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Gasket Screw Socket...
Similar Questions
Won't Start. Changed The Spark Plug, Fresh Gas, Just Won't Turn Over.
Changed the spark plug, fresh gas, just won't turn over. First time I'm running it this year. Had it...
Changed the spark plug, fresh gas, just won't turn over. First time I'm running it this year. Had it...
(Posted by dljoyce 3 years ago)
K760 No Start When Cold No Fuel On Spark Plug .
k760 no start when cold pull spark plug out not wet. Pour gas in sperk plug hole starts and runs fin...
k760 no start when cold pull spark plug out not wet. Pour gas in sperk plug hole starts and runs fin...
(Posted by billdeegan68 7 years ago)
Where Are The Spark Plugs Located On This Lawn Tractor
(Posted by mary44722 8 years ago)
Spark Plug
where is spark plug located on yth21k46 lawn tractor husqvarna??????
where is spark plug located on yth21k46 lawn tractor husqvarna??????
(Posted by wmhauth 9 years ago)
